MATERIAL SAFETY DATA SHEET: CRYSTAL COAT
February 16, 2004
SECTION 1 鈥? CHEMICAL PRODUCT AND COMPANY INFORMATION
Company information: Hot Foot庐 America L.P.
P.O. Box 1339
Sausalito, CA 94966
Tel: 415 789-5135 Fax: 415 789-0564
Medical emergency: Tel: 1 800 228 5635 Ext. 018
Transport emergency: (CHEMTREC) Tel: 1 800 424 9300
Product Information: Hot Foot庐 Crystal Coat spray coating
SECTION 2 鈥? COMPOSITION & INFORMATION ON CONTENTS
This Material Safety Data Sheet is prepared to comply with the United States Occupational Safety and Health
Administration (OHSA) Hazard Communication Standard (29 CFR 1910.1200) and the Canadian Workplace
Hazardous Materials Information System (WHMIS). Unlisted ingredients are not 鈥榟azardous鈥? per the OSHA
standard and/or are not found on the WHMIS ingredient disclosure list.
Chemical/CAS Number: 1,2-Butylene Oxide 106-88-7; (70-75%)
Xylene 1330-20-7; (15-20%)
Carbon Dioxide 124-38-9 (3%)
OSHA PEL: 100ppm of Xylene and 5000 ppm of Carbon dioxide
ACGIH TLV: 100ppm of Xylene and 5000 ppm of Carbon dioxide
Vapor pressure: in mmHG @ C:44; 75 psig
This product is an aerosol, plastic coating pressurized spray powered by carbon dioxide gas.
SECTION 3 鈥? HEALTH HAZARDS
EFFECTS OF OVER EXPOSURE
Eyes: Can cause eye irritation and chemical burns are possible.
Skin: Causes skin irritation and chemical burns are possible.
Skin absorption:A single prolonged skin exposure is not likely to result in harmful amounts.
Inhalation: High concentrations of the vapor are irritating to the respiratory tract, may cause headaches,
drowsiness and unconsciousness. Repeated inhalation of high concentrations may cause lung,
kidney, liver, urinary, blood, bone marrow, heart, eye, reproductive and fertility effects, and other
central nervous system effects including death.
Ingestion Toxic: Harmful if swallowed. May cause liver and kidney effects.
Aspiration Hazard:
Small amounts of this product aspirated into the respiratory system during ingestion or vomiting
may cause mild to severe pulmonary injury, possibly progressing to death.
2/16/04 1
SECTION 4 鈥? EMERGENCY AND FIRST AID MEASURES
If in eye: Flush immediately with large amounts of water for at least 15 minutes, occasionally lifting upper
and lower eyelids. Call a physician.
If on skin: Thoroughly wash affected area with soap and water. Launder contaminated clothing before re-
use. Should any irritation persist, seek medical attention.
Inhalation: Remove from exposure. If breathing is difficult administer oxygen. If breathing has stopped give
artificial respiration. Call a physician.
If ingested: Ingestion is not considered a potential route of exposure as an aerosol but, if swallowed, do not
induce vomiting. Immediately drink two glasses of water. Never give anything by mouth to an
unconscious person. Get immediate medical attention and transport to an emergency medical
facility immediately.
SECTION 5 鈥? FIRE FIGHTING MEASURES
Flash point: No flame extension as an aerosol.
Flammability Limits: non flammable
Upper explosive limit/ Lower explosive limit: UEL 12.3%, LEL 1.9%
Auto ignition Temperature: Not established.
Appropriate extinguishers: The solvent will not burn
Special fire fighting procedures: Persons exposed to products of combustion should wear self-contained breathing
apparatus and full protective equipment. Shut off all sources of ignition if possible. Keep exposed containers cool
with water spray to prevent rupture. Evacuate all non trained personnel. Wear full protective clothing including
helmet. Ventilate area.
Unusual Fire and Explosive Hazards: None
SECTION 6 鈥? ACCIDENTAL RELEASE MEASURES
Spill or leak procedures:
Ventilate area, avoid breathing vapors. Extinguish all ignition sources. For small spills, mop, dike and contain spill
with inert absorbent and transfer to container for disposal. Remove to outside or to vent hood while awaiting
disposal. Avoid ground contamination. For large spills, evacuate the area, contain spill (dike area) and transfer
contained liquid to a DOT approved container for disposal. Keep out of water supply. Water spray can be used to
disperse any vapors that may become concentrated or form in poorly ventilated areas.
WASTE DISPOSAL: When disposing of unused contents, the preferred options are to send to a licensed
reclaimer or to permitted incinerator. Any disposal practice must be in accordance with federal, state and local
laws and regulations. Do not dump into sewers, on the ground or into any body of water.
SECTION 7 鈥? HANDLING AND STORAGE
Handling Information: Store in tightly sealed containers. Keep away from heat, sparks and open flame. Do not
get in eyes, on skin or clothing. Do not breathe vapor, mist or gas. Do not store or transfer to an unmarked
container. Do not throw empty containers in trash compactor. Do not store in direct sun. Store containers below
120 degrees F. Read label before using.
SECTION 8 鈥? EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye protection: Wear safety glasses to reduce the potential for eye contact; Have eye washes available
where eye contact can occur.
Skin protection: Prevent contact by using rubber gloves and appropriate protective clothing. Launder
contaminated clothing before reuse.
Respiratory Protection: Use NIOSH/MSHA approved equipment - organic vapor respirators when airborne
exposure limits are exceeded.
Ventilation: Local exhaust ventilation preferred. Provide ventilation to control
contaminant levels below airborne exposure limits.
2/16/04 2
PROTECTIVE GLOVES for brief contact no precautions should be needed. When prolonged or frequently
repeated contact occurs, use protective gloves such as Viton or Norfoil.
EYE PROTECTION: Chemical splash goggles in compliance with OSHA regulations are recommended.
Use protective clothing which is impervious to this product. Selection of specific gloves, boots, apron or full
body suit will depend on operation.
SECTION 9 鈥? STABILITY AND REACTIVITY DATA
Stability: stable
Incompatibility: materials to avoid; Strong oxidizers and temperatures above 130 degrees F.
Strong acids and bases; organic and inorganic acid chlorides, acid anhydrides,
halogen and molten sulfur.
Hazardous decomposition: Hydrogen Bromide and/or bromide, carbon monoxide and carbon dioxide.
Hazardous Polymerization: will not occur
Hmis ratings Health=2; Flammability=1, Reactivity=0.
SECTION 10 鈥? TRANSPORTATION INFORMATION
United States Department of Transportation (DOT)
DOT proper shipping name: Acrylic spray
DOT hazard class / ID code: class 2.2 , UN-1950
DOT label: Non Flammable
SECTION 11 鈥? REGULATORY INFORMATION
SUPERFUND AMMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) TITLE 111
CHEMICAL CAS NO. CONCENTRATION %
1,2-Butylene Oxide 106-88-7 70-76
Xylene 1330-20-7 15-20
FEDERAL EPA: Comprehensive environmental response, compensation and Liability Act of 1980 (CERCLA)
requires the notification of the National Response Center of release of quantities of hazardous substances equal
to or greater than the reportable quantities (RQS) in 40CFR 302.4
CHEMICAL CAS NO. CONCENTRATION % RQs#s
Xylene 1330-20-7 15-20 100
CALIFORNIA PROP 65: NO
MASSACHSETTS RIGHT TO KNOW: Yes
1,2-Butylene Oxide 106-88-7 70-76
Xylene 1330-20-7 15-20
Carbon Dioxide 124-38-9 3
PENNSYLVANIA RIGHT TO KNOW : Yes
1,2-Butylene Oxide 106-88-7 70-76
Xylene 1330-20-7 15-20
Carbon Dioxide 124-38-9 3
NEW JERSEY RIGHT TO KNOW :Yes
1,2-Butylene Oxide 106-88-7 70-76
Xylene 1330-20-7 15-20
Carbon Dioxide 124-38-9 3
2/16/04 3
TOXIC SUBSTANCES CONTROL ACT (TSCA) : Listed
California VOC鈥橲 97%
NFPA RATING AS AN AEROSOL : LEVEL 1
CARCINOGENITY CHEMICAL IARC NTP OSHA NCI ACIGH
None Listed.
The information and recommendations set forth herein are believed to be accurate. Because some of the
information is derived from information provided to Hot Foot庐 American L.P. from its suppliers, and because Hot
Foot庐 America L.P. has no control over the conditions of handling and use, Hot Foot庐 America L.P. makes no
warranty, express or implied, regarding the accuracy of the data or the results to be obtained from the use
thereof. The information is supplied solely for your information and consideration, and Hot Foot庐 America L.P.
products to comply with all applicable federal, state and local laws and regulations.
2/16/04 4
|