MATERIAL SAFETY DATA SHEET
A Degreasing Solvent
I - PRODUCT IDENTIFICATION
Company Name: Nu-Calgon Wholesaler, Inc. Tel No: (314) 469-7000, (800) 554-5499
Address: 2008 Altom Court, St. Louis, MO 63146-4151 CHEMTREC: (800) 424-9300
Product Name: Degreasing Solvent Product Number: 4161
Synonyms: Chlorinated Hydrocarbon Solvent
II - HAZARDOUS INGREDIENTS OF MIXTURES
MATERIAL CAS# % By Wt TLV PEL
Stoddard Solvent* (ORAL LD50 8052-41-3 60 100ppm 100ppm
>10mg/kg) 71-55-6 40 350ppm 350ppm
# 1,1,1-trichlorethane** (ORAL LD50
rabbit 5660mg/kg)
*STEL=200ppm; **STEL=450ppm
# Ingredient subject to reporting under
Section 313 of Title III (SARA) and 40
CFR 372.
All ingredients are TSCA listed.
III - PHYSICAL DATA
Vapor Pressure: mm Hg: Unknown Vapor Density (Air=1) 60-90?F: Unknown
Evaporation Rate: (ether=1): N/A VOC Content (% by wt.): 100
Solubility in H 2O: Slight pH @ Solution: N/A
pH as Distributed: N/A
Freezing Point 癋: N/A
Appearance: Clear liquid
Boiling Point 癋: 165癋
Odor: Hydrocarbon odor
Specific Gravity H 2O=1 @25?C: 0.982
IV - FIRE AND EXPLOSION
Flash Point F: 116F TOC Flammable Limits: N/AV
Extinguishing Media: Dry chemical, foam, CO2.
Special Fire Fighting Procedures : Exercise caution when fighting any chemical fire. Respiratory
protection is essential.
Unusual Fire and Explosion Hazards : Toxic gases and vapors such as hydrogen chloride, phosgene and
carbon monoxide may be released if involved in a fire.
V - REACTIVITY DATA
Stability - Conditions to avoid : Keep away from heat and flame.
Incompatibility: Strong oxidizers, aluminum and magnesium powders and sodium potassium.
Hazardous Decomposition Products : See Section IV.
Conditions Contributing to Hazardous Polymerizations : None known.
VI - HEALTH HAZARD DATA
EFFECTS OF OVEREXPOSURE (Medical Conditions Aggravated /Target Organ Effects ),
A. ACUTE (Primary Route of Exposure ) EYES & SKIN: Causes irritation. May defat, dry and cause
scaling of skin upon contact. INHALATION: Harmful if inhaled. May cause nausea, vomiting, coughing
and respiratory irritation. INGESTION: Aspiration into lungs can occur resulting in pneumonitis,
pulmonary edema & hemorrhage.
B. SUBCHRONIC, CHRONIC, OTHER : CHRONIC: Inhalation of Stoddard Solvent show results of
hepatic and hematopoietic changes.
C. MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE :
VII - EMERGENCY AND FIRST AID PROCEDURES
INHALATION: If inhaled, remove to fresh air. If not breathing, give artificial respiration, preferably mouth
to mouth.
If breathing is difficult, give oxygen. Call a physician.
EYES: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Call a
physician.
SKIN: In case of contact, flush skin with water. Wash clothing before reuse.
INGESTION: If swallowed, DO NOT induce vomiting. Call a physician immediately. Never give anything
by mouth to an unconscious person.
VIII - SPILL OR LEAK PROCEDURE
Spill Management: Dike area, contain as much spilled material as possible. Remove any remaining
material by absorbing on vermiculite or other suitable absorbing material. Dispose of in approved landfill.
Waste Disposal Methods : Dispose of in accordance with above described (or similarly approved) disposal
procedure. Dispose of in accordance with local, state and federal regulations.
IX - PROTECTION INFORMATION /CONTROL MEASURES
Respiratory: NIOSH - approved respirator is recommended if exceeds OSHA TLV's for Stoddard Solvent
& 1,1,1-trichloroethane.
Eye Protection: Eye goggles or full face shield. Glove: Solvent-resistant rubber.
Other Clothing and Equipment : Not required.
Ventilation: Local and mechanical exhaust is recommended.
X - SPECIAL PRECAUTIONS
Precautions to be taken in Handling and Storing : Avoid contact with eyes, skin and clothing. Avoid
breathing vapors. Wash thoroughly after handling. Keep container closed.
Additional Information : Vapors are heavier than air and will collect in low areas. Use only in
well-ventilated areas that will maintain air levels below limits established by federal, state, and local
regulations.
NFPA HMIS RATING
Health Hazard.....: 1 Health Hazard.........: 1
Fire Hazard.......: 2 Fire Hazard...........: 2
Reactivity........: 0 Reactivity............: 0
Specific Hazard...: Personal Protection ...: X (Sec. 9)
Revision Date: 09/09/2002
Seller makes no warranty, expressed or implied, concerning the use of this product other than indicated on the label. Buyer assumes all risk of
use and/or handling of this material when such use and/or handling is contrary to label instructions. While Seller believes that the information
contained herein is accurate, such information is offered solely for its customers' consideration and verification under their specific use
conditions.
|