Atlantic Chemical Equipment Co.
MATERIAL SAFETY DATA SHEET
3471 Atlanta, Industrial Parkway
Suite 200
Atlanta, GA 30331
404-505-6626
PRODUCT NAME: PIPE-KOTE COLD PIPE INSULATION (PKA)
EMERGENCY PHONE: 1-800-424-9300 VII - PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE CONTAINER IS PUNCTURED AND MATERIAL IS RELEASED:
Allow propellant to evaporate. Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat sources and open flames far away from
May be used to comply with OSHA'S Hazard Communications Standard (HSC) 29 CRF 1910, 1200. HMIS SYMBOLS
spill or leak. Cover with absorbent material and sweep up. Wash area to prevent slipping. Dispose of soaked absorbent material in accordance with
2
Standard must be consulted for specific requirements. This product contains HEALTH
Federal, State, and Local laws.
3
no substances subject to SARA TITLE III and 40 CRF. FLAMMABILITY
0 WASTE DISPOSAL METHOD: Aerosol cans, when emptied and depressurized through normal use, pose no disposal hazard and should be recycled.
REACTIVITY
Consult federal, state, and local authorities for approved procedures.
1 - IDENTIFICATION
PACKAGE TYPE: Aerosol
PRODUCT NAME: (PKA) PIPE-KOTE COLD PIPE INSULATION VIII - SPECIAL PROTECTION INFORMATION
PREPARED DEPARTMENT OF HAZARDOUS COMMUNICATIONS DATE PREPARED: February 2006 RESPIRATORY: None needed for proper use in accordance with label directions.
EYE: None needed unless it is anticipated that a splash or spray back will occur, then wear safety glasses or chemical proof goggles.
II - HAZARDOUS INGREDIENTS
PRINCIPLE HAZARDOUS COMPONENT(S) CAS NO ACGIH TLV OSHA PEL % or RANGE
(CHEMICAL NAMES)
20-25%
1,1,1 - Trichloroethane 71-55-6 350 ppm 350 ppm SKIN: None needed for proper use in accordance with label PROTECTIVE GLOVES: Neoprene, Nitrile Rubber or polyvinyl
directions. Use chemical resistant gloves if hand contact will be recommended.
05-10%
Steric Acid 57-11-4 N/E N/E
made.
40-60%
Liquefied Petroleum Gas 68476-85-7 1000 ppm 1000 pmm
OTHER: Do not eat, drink, or smoke in work area. Wash hands before eating.
VENTILATION REQUIREMENTS: Provide sufficient mechanical (general) and/or local exhaust ventilation to maintain exposure below TLV(S).
III - PHYSICAL DATA
0 0
BOILING POINT ( F) : N/D SPECIFIC GRAVITY (H20= 1) : @ 75 F of Concentrate 1.208
VAPOR PRESSURE (mm Hg) : 50 MELTING POINT: IX - SPECIAL PRECAUTIONS
0
VAPOR DENSITY (Air = 1) : > 1 EVAPORATION RATE (H20 = 1) : PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Do not store at temperatures above 120 F. Store in a cool dry place away from
open flame or heat.
pH : NA APPEARANCE AND ODOR : Clear liquid, mild sweet odor
SOLUBILITY IN WATER : Slight SPECIAL PRECAUTIONARY STATEMENTS: Please read and follow the directions on the label: They are your best guide to using this product in
the most effective way, and they also give the necessary safety precautions to protect your health.
Keep this and all chemicals out of reach of children.
IV - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per CPSC FLAME EXTENTION TEST: Extremely Flammable NOTICE: We believe that the information contained on this material safety data sheet is accurate. The suggested procedures are based on experience as
of the date of publication. They are not necessarily nor fully adequate in every circumstance. Also, the suggestions should not be confused with nor
SPECIAL FIRE FIGHTING PROCEDURES: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
followed in violation of applicable laws, regulations, rules or insurance requirements. No warranty, expressed or implied, of merchantability fitness or
otherwise is made.
0
UNUSUAL FIRE AND EXPLOSION HAZARDS: At elevated temperatures (above 120F) containers may vent, rupture, or burst.
X - REGULATORY INFORMATION AND REFERENCES
V - REACTIVITY DATA
0
CHEMICAL UNSTABLE SARA Title III Reporting Requirements
CONDITIONS TO AVOID: Do not exposed to temperatures above 120F
STABILITY STABLE X 302 (Extremely Hazardous Substances): Reporting not required.
304/CERCLA
INCOMPATIBILITY (Materials to avoid): Strong oxidizing agents, strong acids and bases, and selected amines (Spills Notification): Not required.
HAZARDOUS DECOMPOSITION PRODUCTS: Hydrogen, Chloride, Phosgene.
311
HAZARDOUS MAY OCCUR CONDITIONS TO AVOID: None Community Right-To-Know, RTK):Reporting not required.
POLYMERIZATION WILL NOT OCCUR X
Aerosol products present a limited hazard during storage or use if label precautions are followed. Intentional misuse by deliberately concentrating and inhaling the 312 (RTK Inventory Data): Not required.
contents can be harmful, or fatal. Pressurized containers must not be exposed to temperatures above 1200F and spray should not be directed towards face or eyes, open
flame or other source of ignition.
313 (Emissions and Releases): Reporting not required.
DOT NOT HAZARDOUS
VI - HEALTH HAZARD AREA
ROUTE(S) OF ENTRY: EYES Yes SKIN Primary INGESTION Yes INHALATION Yes
References
EFFECTS OF OVER EXPOSURE:
TOXIC SUBSTANCE CONTROL CT LIST (TSCA) - INGREDIENTS LISTED
INHALATION: Inhalation of mist can cause irritation of nasal passages. Abusive or excessive inhalation may cause irritation to the upper respiratory tract, dizziness,
nausea, other central nervous system effects. PERMISSIBLE EXPOSURE REFERENCES:
Registry of Toxic Effects of Chemical Substances.
SKIN CONTACT/ABSORPTION: Frequent or prolonged contact may cause irritation.
Title 29 Code of Federal Regulations.
INGESTION: Can cause gastrointestinal irritation, nausea, vomiting, and diarrhea. Aspiration of material into lungs can cause chemical pneumonitis.
National Toxicology Program (NTP) Report on Carcinogens.
International Agency for Research on Cancer (IARC) Monographs.
EYES: May cause slight irritation, but does not injure eye tissue.
Title 40 Code of Federal Regulations
CARCINOGENICITY: No NTP? No IARC MONOGRAPHS? No OSHA REGULATED? Yes
REGULATORY STANDARDS:
EMERGENCY AND FIRST AID PROCEDURES:
DOT Title 49 Code of Federal Regulations 172.101
EYES AND SKIN: EYES - Flush with water for at least 15 minutes while lifting upper and lower lids. GET MEDICAL ATTENTION.
SKIN - Wash exposed areas
with soap and water. If irritation persists get medical attention. SARA Title III
Nuclear Regulatory Commission
INHALATION: Remove to fresh air. SEEK IMMEDIATE MEDICAL ATTENTION.
INGESTION: Do NOT induce vomiting. GET IMMEDIATE MEDICAL ATTENTION.
1
|