UTILITY MANUFACTURING CO., INC. MATERIAL SAFETY DATA SHEET
700 MAIN STREET, WESTBURY, NY 11590
(516) 997-6300 - FAX # (516) 997-6345
CYCLONE FIN & COIL CLEANER
FOR CHEMICAL EMERGENCY: Spill, Leak, Fire, Exposure, or Accident - Call INFOTRAC - Day or Night: 1-800-535-5053
THIS MSDS COMPLIES WITH 29 CFR 1910.1200 (HAZARD COMMUNICATION STANDARD) IMPORTANT: Read this MSDS
before handling & disposing of this product. Pass this information on to employees, customers and users of this product.
HMIS: H2 FO RO PB
NFPA: H2 FO RO P-
Level 1 Aerosol
PRODUCT IDENTIFICATION
DOT Shipping name: CAS NO.: MIXTURE
CONSUMER COMMODITY, ORM-D
Chemical Family: UN/NA #: N/A
CHLORINATED SOLVENTS
DOT Hazard Class: DATE OF ISSUE: 4/08
PRESSURIZED CONTAINER, ORM-D
SECTION I - HAZARDOUS INGREDIENTS/EXPOSURE LIMITS
Hazardous Ingredients: CAS # TLV/PEL AGENCY TYPE SARA-313(% Range)
TETRACHLOROETHYLENE* 127-18-4 25PPM ACGIH TWA 40-50
1,1,1-TRICHLOROETHANE * 71-55-6 350 PPM ACGIH TWA 40-50
CARBON DIOXIDE 124-38-9 5000PPM ACGIH TWA
* These chemicals are subject to the reporting requirements of SARA, Section 313
SECTION II - EMERGENCY AND FIRST AID PROCEDURES
WARNING: CONTENTS UNDER PRESSURE
EYE CONTACT: Move person away from exposure and into fresh air. If irritation or redness develops, flush eyes with clean water and
seek medical attention. For direct contact hold eyelids apart for at least 15 minutes. Seek medical attention.
SKIN CONTACT: Remove contaminated shoes and clothing and cleanse affected areas thoroughly by washing with mild soap and water.
If irritation persists seek medical attention.
INHALATION: (breathing) Not expected to be a hazard under normal operating conditions..
INGESTION: (swallowing) If swallowed, seek emergency medical attention. Do not give anything by mouth. .
SECTION III - HEALTH HAZARDS / ROUTES OF ENTRY
EYE CONTACT: One or more components of this material may be an eye irritant.
SKIN CONTACT: Continuous contact with this material may cause drying of skin. Chemical itself is an irritant or sensitizer.
SKIN ABSORPTION: Symptoms of toxicity are anticipated by this route .
INHALATION: (breathing) Not expected to be a hazard under normal operating conditions.
INGESTION: (swallowing) Ingestion of large quantities may cause the following: Irritation of digestive tract, signs of nervous system
depression, such as headache, drowsiness, dizziness, loss of coordination, fatigue, and nausea.
SECTION IV - SPECIAL PROTECTION INFORMATION
VENTILATION: If current ventilation practices are not adequate to maintain airborne concentrations below established exposure limits
(see section I), additional ventilation or exhaust systems may be required.
RESPIRATORY PROTECTION: The use of respiratory protection is advised when concentrates exceed the established exposure limits
(see Section I). Depending on the airborne concentration use a respirator or gas mask with appropriate cartridges or canisters
(NIOSH approved) or supplied air.
PROTECTIVE GLOVES: The use of gloves impermeable to the specific material handled is advised to prevent possible irritation.
EYE PROTECTION: Approved eye protection to safeguard against potential eye contact, irritation or injury is recommended.
SECTION V - REACTIVITY DATA
STABILITY: Stable
INCOMPATIBILITY: (materials to avoid) This product is incompatible with: Oxidizing agents, strong acids and bases
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition in the presence of air may yield carbon monoxide, carbon
dioxide.
HAZARDOUS POLYMERIZATION: Will not occur
SECTION VI - SPILL OR LEAK PROCEDURES
PRECAUTIONS IN CASE OF LEAK OR SPILL: Keep all sources of ignition and hot metal surfaces away from spill/release. Stay
upwind and away from spill/release. Isolate hazard area and limit entry to emergency crew only. Stop spill/release if it can be done
without risk. Wear appropriate protective equipment including respiratory protection as conditions warrant (see Section IV). Prevent
spilled material from entering sewers, storm drains, and natural waterways. Dike far ahead of spill for later recovery and disposal. Spilled
Page 1 10-6010
UTILITY MANUFACTURING CO., INC. MATERIAL SAFETY DATA SHEET
700 MAIN STREET, WESTBURY, NY 11590
(516) 997-6300 - FAX # (516) 997-6345
CYCLONE FIN & COIL CLEANER
material may be absorbed by an appropriate absorbent. Notify fire authorities and appropriate federal, state, and local agencies. If
spill/release is excess of EPA reportable quantity, immediately notify the National Response Center. Phone 800-424-8802
WASTE DISPOSAL METHOD: Dispose of product in accordance with local, county, state, and federal regulations.
SECTION VII - STORAGE AND SPECIAL PRECAUTIONS
HANDLING AND STORAGE PRECAUTIONS: Do not get in eyes, skin or clothing. Do not breathe vapor mist or gas. Keep
containers tightly closed, cool, dry, and away from all sources of ignition. Use and store this product with adequate ventilation.
Avoid inhalation of vapors and personal contact with the product. Use good personal hygiene practices. Bond and ground
equipment when transferring to another container. "Empty" containers contain residue (liquid and/or vapor) and can be
dangerous. Do not puncture, cut, weld, braze, solder, drill, grind, or expose such containers to heat, flame, sparks, or other
sources of ignition. They may explode and cause injury and death. Contents under pressure. Do not puncture or incinerate
container. All other containers should be disposed of in an environmentally safe manner and in accordance with governmental
regulations. Before working in or on tanks which contain or has contained this product, refer to OSHA or ANSI Z49.1
regulations and other governmental and industrial references pertaining to cleaning, repairing, welding, or other contemplated
operations.
SECTION VIII - FIRE AND EXPLOSION HAZARD DATA
EXTINGUISHING MEDIA: Extinguish with dry chemical, CO2, or a universal type foam.
FIRE AND EXPLOSION HAZARD: May decompose during contact with flames, heating elements, or in combustion engines releasing
irritating gases. Exposure in excess of 120 deg F may cause bursting of can.
FIRE FIGHTING PROCEDURES: Wear appropriate protective equipment including respiratory protection as conditions warrant (see
Section IV). Stop spill/release if it can be done without risk. Water spray may be useful in minimizing or dispersing vapors and
cooling equipment exposed to heat and flame. Avoid spreading burning liquid with water used for cooling purposes.
SECTION IX - PHYSICAL DATA
APPROXIMATE BOILING POINT (DEG F): PER CENT VOLATILE:
103 100
SPECIFIC GRAVITY (68 F): FLASH POINT (TCC, DEG F):
1.4 NONE, TOC
RELATIVE EVAPORATION RATE PER CENT SOLUBILITY IN
>1 Negligible
(ESTIMATED): WATER:
VAPOR PRESSURE @70 DEG f 95 PSIG
g (CALCULATED):
SECTION X - OTHER REGULATORY DATA
SARA HMIS
SECTION 302: LISTED Health: 2
SECTION 311 & 312: LISTED Flammability: 1
SECTION 313: See Section I.I Reactivity: 0
TSCA
CALIFORNIA PROPOSITION 65
All components are in full compliance
with the TSCA inventory. LISTED
RCRA CERCLA
Waste material would be a D008 CHLORINATED SOLVENT RQ: 1000 LBS.
CARCINOGENICITY:
NTP: Yes or IARC Monographs: Yes
OSHA Regulated: Yes
NOTICE
The supplier disclaims all expressed or implied warranties of merchantability or fitness for a specific use, with respect to the product or the information
provided herein, except for conformation to contracted specifications. All information appearing herein is based upon data obtained from manufactures
and/or recognized technical sources. While the information is believed to be accurate, we make no representations as to its accuracy or sufficiency.
Conditions of use are beyond our control, and therefore users are responsible for verifying the data under their own operating conditions to determine
whether the product is suitable for their particular purposes and they assume risks of their use, handling, and disposal of the product. Users also assume all
risks in regards to the publication or use of, or reliance upon, information contained herein. This information relates only to the product designated herein,
and does not relate to its use in combination with any other material or process.
Page 2 10-6010
|