Material Safety Data Sheet U.S. Department of Labor
May be used to comply with Occupational Safety and Health Administration
OSHA's Hazard Communication Standard, (Non-Mandatory Form)
29 CFR 1910.1200. Standard must be Form Approved
consulted for specific requirements. OMB No. 1218-0072
Degreaser Note: Blank spaces are not permitted. If any item is not applicable, or no
IDENTITY (As Used on Label and List)
information is available, the space must be marked to indicate that.
CMD-10-1, CMD-10-A
Section I
Emergency Telephone Number
Manufacturer's Name
Crow Marketing & Distribution, Inc. 800-255-3924
Address (Number, Street, City, State, and ZIP Code) Telephone Number for Information
972-245-4070
P. O. Box 29171, Dallas, TX 75229
Date Prepared
09-09-91 REVIEWED 08/18/2006
Signature of Preparer (Optional)
Section II -- Hazardous Ingredients/Identity Information
Other Limits
Hazardous Components (Specific Chemical Identity; Common Name(s) OSHA PEL ACGIH TLV Recomended % (optional)
CH3CC13 1,1,1 Trichloroethane NA2831 CAS # 71-55-6 STEL 450 ppm-
350 ppm-8 hr TWA
1993-1994
15 minute
Trichloroethylene CAS # 000079-01-6
1994-Present
UN1710 Packing Group III
200 PPM 15 Minute STEL
TSCA Inventory # 79-01-6
50 PPM, 8 Hour Weighted
Section III -- Physical/Chemical Characteristics
Boiling Point Specific Gravity (H2 O = 1)
@ 25?25癈 1.3
165.4癋
Vapor Pressure (mm Hg.) Melting Point
135
at 25癈 N/A
Vapor Density (AIR = 1) Evaporation Rate
4.54 0.35
(Ethyl Ether =1)
Solubility in Water
Negligible
Appearance and Odor
Clear, colorless liquid, ether like odor.
Section IV -- Fire and Explosion Hazard Data
LEL
Flash Point (Method Used) Flammable Limits UEL
N/A N/A 7% 15%
Extinguishing Media
Water, dry chemical or carbon dioxide
Special Fire Fighting Procedures
Fire fighters should wear a NIOSH/MSHA approved pressure demanded self-contained breathing apparatus for possible exposure to
hydrogen chloride and possible traces of phosgene.
Unusual Fire and Explosion Hazards
Vapors concentrated in a confined or poorly ventilated area can be ignited on contact with a spark, flame or high intensity source of heat. This
can occur in concentrations ranging between 7 to 15% by volume.
CMD-10
Section V -- Reactivity Data
Unstable Conditions to Avoid
Stability
Avoid open flames, hot glowing surfaces or electric arcs.
Stable X
Incompatiblity (Materials to Avoid)
Strong Oxidizing Materials
Hazardous Decomposition or Byproducts
N/A
Hazardous Conditions to Avoid
May Occur
Avoid contamination with caustic soda, caustic potash or oxidizing materials.
Polymerization
Will Not Occur X
Section VI -- Health Hazard Data
Ingestion?
Route(s) of Entry: Inhalation? Skin?
Yes Yes Yes
Health Hazards (Acute and Chronic)
I NHALATION: Not significantly toxic; SKIN: liquid mildly irritating; EYES: irritant; INGESTION: not significantly toxic. .
NTP? IARC Monographs? OSHA Regulated?
Carcinogenicity:
None known No No
No evidence to support carcinogenicity
Signs and Symptoms of Exposure
Irritation
Medical Conditions
None known.
Generally Aggravated by Exposure
Emergency and First Aid Procedures INHALATION: Remove to fresh air, SKIN: Flush with soap & water, EYES: flush with water, INGESTION:
drink large quantities of water, do not induce vomiting. Take immediately to the hospital.
Section VII -- Precautions for Safe Handling and Use
Steps to Be Taken in Case Material is Released or Spilled
Evacuate area, ventilate, stage upwind, dike and contain spill, keep spill from ground water, use sawdust or vermiculite to absorb spill, put in
containers and dispose, do not dispose of in sanitary sewer.
Waste Disposal Method
Contaminated sawdust, vermiculite must be disposed of in hazardous waste management facility. May be reprocessed or incinerated or treated in
hazardous waste facility.
Precautions to Be Taken in Handling and Storing
Use in well ventilated area. Vapors will collect in low areas, keep container closed when not in use.
Other Precautions
Keep away from strong oxidants.
Section VIII -- Control Measures
Respiratory Protection (Specify Type)
Not required if good ventilation is maintained.
Local Exhaust Recommended
Ventilation Special N/A
Yes Mechanical (General) Other
N/A N/A
Protective Gloves Eye Protection
Splashproof goggles
Polyethylene, neoprene
Other Protective Clothing or Equipment
None required.
Work/Hygienic Practices
Avoid prolonged breathing of vapors in work area. Do not eat, drink or smoke.
Page 2
|