Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: +01-813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 26BR HIGH TEMP RTV RED SILICONE GASKET MAKER 3 OZ
Item No: 81160
Product Type: Silicone
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL
POLY (DIMETHYLSILOXANE), >60 Not listed Not listed
HYDROXY TERMINATED
70131-67-8
AMORPHOUS SILICA 5-15 Not listed 20 mppcf
7631-86-9
5 mg/m3
DISTILLATES (PETROLEUM), <7 Not listed
HYDROTREATED MIDDLE
64742-46-7
5 mg/m3 10 mg/m3
IRON OXIDE <5
1309-37-1
ETHYLTRIACETOXYSILANE <5 Not listed Not listed
17689-77-9
METHYLTRIACETOXYSILANE <5 Not listed Not listed
4253-34-3
POLYDIMETHYLSILOXANE <5 Not listed Not listed
63148-62-9
3
15 mg/m3
TITANIUM DIOXIDE <2 10 mg/m
13463-67-7
5 mg/m3 10 ppm; 25 mg/m3
ACETIC ACID 0.5-2.0
64-19-7
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. May irritate lips, gums, tongue, mouth, nose and throat. ****When this
Toxicity:
product is exposed to moisture, acetic acid may be formed. May irritate respiratory system upon frequent
or prolonged use. Note: This product does not contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Acetic acid produced during curing irritates eyes, nose and throat..
Signs and Symptoms of Exposure:
Component Weight% NTP ACGIH Carcinogens IARC
AMORPHOUS SILICA 5-15 Group 3 Monograph 68, 1997
7631-86-9
IRON OXIDE <5 A4 - Not Classifiable Group 3, Supplement 7 1987;
1309-37-1 Monograph 1 1972
TITANIUM DIOXIDE <2 male rat-negative, A4 Group 2B; Vol 93,2006; Vol
13463-67-7 female rat-negative, 47,1989
male mice-negative,
female mice-negative
Methyltriacetoxysilane: Eye, skin and pulmonary disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
Rinse mouth. If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wipe off material with paper towel or cloth. Wash off with soap and water. If skin irritation persists, call a
Skin Contact:
physician.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
1 of 3
Product Name: 26BR HIGH TEMP RTV RED SILICONE Item No: 81160
GASKET MAKER 3 OZ
5. FIRE FIGHTING MEASURES
>200?F TCC
Flash Point 癋(C?:
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Water spray may be ineffective on flames but should be used to keep fire-
Special Fire-Fighting Procedures:
exposed containers cool.
Acetic acid, Formaldehyde, Silica fume, Oxides of nitrogen, Oxides of
Hazardous Products of Combustion:
carbon, Oxides of sulfur, Metal oxide fumes
None.
Unusual Fire/Explosion Hazards:
Acetic acid: 4%
Lower Explosive Limit:
Acetic acid: 19..9%
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Wipe or scrape up spill material. Maintain good ventilation for large spills. Place scrap material in a well-
Spill Procedures:
ventilated area and allow to cure to rubber. Clean up spills thoroughly as residue is slippery.
7. HANDLING AND STORAGE
Store away from water or moisture. Keep away from oxidizers.
Storage:
Avoid contact with skin and eyes. Do not wear contact lenses. Use only in a well ventilated area. Do not
Handling:
take internally.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this product.
An approved organic vapor respirator should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
When heated to temperatures above 300 degrees F. in the presence of air, this product can form
Comments:
formaldehyde vapors. Formaldehyde is a potential cancer hazard and a known skin and respiratory
sensitizer. Safe handling conditions may be maintained by keeping vapor concentrations below the OSHA
permissible limit for formaldehyde
9. PHYSICAL AND CHEMICAL PROPERTIES
Red paste
Appearance:
Acetic acid
Odor:
Not applicable, polymeric material
Boiling Point:
Does not apply
pH:
Polymerized
Solubility in Water:
1.0
Specific Gravity:
3.0%; 0.25 lb/gal; 30 g/l
VOC(Wt.%):
10 mm Hg
Vapor Pressure:
Not Determined
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur.
Hazardous Polymerization:
Polymerized by contact with moisture. Acetic acid liberated.
Incompatabilities:
Exposure to moisture.
Conditions to Avoid:
Acetic acid, Formaldehyde, Silica fume, Oxides of nitrogen, Oxides of
Hazardous Products of Combustion:
carbon, Oxides of sulfur, Metal oxide fumes
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
2 of 3
Product Name: 26BR HIGH TEMP RTV RED SILICONE Item No: 81160
GASKET MAKER 3 OZ
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations..
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Ground Transport (DOT)
Not Regulated
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Not regulated
Proper Shipping:
None
Hazard Class:
None
UN Number:
None
Marine Pollutant:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
NONE
California Proposition 65: No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level
TSCA Inventory Status: All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: October 26, 2009
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 2
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|