MATERIAL SAFETY DATA SHEET
DT Silicone Wax Remover
Emergency Numbers: Chemtrec (800) 424-9300
MSDS or Product Information: 281 588 3000
---------------------------------------------------------------------------------------------------------------------------------------
SECTION I PRODUCT IDENTIFlCATION
---------------------------------------------------------------------------------------------------------------------------------------
Printed 11/16/2006
Manufacturer: Leather Magic Inc
1396 Walkup Ave.
Monroe, NC 28110
Product : Special Industrial Solvent A-2
Synonyms: Silicone Wash SIS A/2SIS formula A/3
Chemical Family: Alcohol
ID No.: UN1986
DOT Guide No.: 131
--------------------------------------------------------------------------------------------------------------------------------------
SECTION II HAZARDOUS INGREDIENTS
---------------------------------------------------------------------------------------------------------------------------------------
Ingredients CAS# Weight % TLV NFPA UN#
Ethanol 64-17-5 86 1000 0-3-0 1170
Methanol 67-56-1 13 200 1-3-0 1230
MIBK 108-10-1 1 50 2-3-0 1245
________________________________________________________________________________
---------------------------------------------------------------------------------------------------------------------------------------
SECTION III PHYSICAL DATA
---------------------------------------------------------------------------------------------------------------------------------------
Boiling Range: 74 - 80
Vapor pressure at 20C (mm Hg): ca 50 Solubility in Water: Complete
Evaporation Rate (n-Butyl Acetate=1): ca2 Volatiles by wt. %: >99
Appearance: Clear liquid, Alcohol Odor Vapor Density (Air = 1): ca 1.5
Specific Gravity @ 60/60f (air): 0.79 (200pf) - (190pf)
---------------------------------------------------------------------------------------------------------------------------------------
SECTION IV FIRE AND EXPLOSION HAZARD DATA
---------------------------------------------------------------------------------------------------------------------------------------
Flash point: (TCC) 5C Flammable Limits (UEL/LEL): 20.0/4.0
Autoignition Temperature (ASTM D 2155): ca 400C
-Extingushing Media: Fight source of fire. Water spray, dry chiemicals, "alcohol" foam
-Special Firefigbting Procedures: NlOSH approved self contained breathing apparatus and protective clothing
should be worn to prevent contact with skin and eyes.
-Unusual Fire & Explosion Hazards: Flammable liquid, Vapors are heavier than air and may cause
ignition/flashback.
---------------------------------------------------------------------------------------------------------------------------------------
SECTION V HEALTH HAZARD DATA
---------------------------------------------------------------------------------------------------------------------------------------
-Exposure Limits:
Component ACGIH TLV STEL SKIN OSHA
TLV TWA PEL TWA
Ethanol 1000 - NO 1000
Methanol 200 250 YES 200
MIBK 50 75 NO 100
-Effects Of Overexposure:
Primary Routes of Entry: (X) Skin Contact, (X) Eye Contact, (X) InhaIation, (X) Ingestion
Signs and Symptoms of Exposure:
Prolonged exposure to excessive concentrations of ethanol may result in irritation of mucous membranes,
headache, drowsiness, fatigue and narcosis. The other componants are not expected to add significantly to the
toxicity of the product.
Inhalation: High vapor concentrations may cause upper respiratory tract irritation and narcosis.
Eyes: Liquid or vapor may cause irritation.
Skin: No specific hazards are known.
Ingestion: Contains methanol, may cause blindness.
Acute: not determined
-FIRST AID: lnhaIation: Remove from exposure, treat symptomatically and get medical help.
Eye Contact: Flush with large amounts of water until all material is removed. If irritation persists, get medical
attention immediately.
Ingestion: Do not induce vomiting unless directed by a poison control center or doctor. Seek medical attention.
Emergency Procedures: Remove contaminated clothing and wash contaminated ares with plenty of water.
Animal Toxicity:
Componant Acute Oral Inhalation Skin
LD 50 on rat LC 50 on rat Irritation
Ethanol 6.2 to 17.8 g/kg ca 16,000 ppm per 8 hrs. Slight
Methanol 6200 mg/kg >22,500 ppm per 8 hrs. Slight
MIBK 1.6 - 5.7 ml/kg 2000 - 4000 ppm per 4 hrs. Moderate
---------------------------------------------------------------------------------------------------------------------------------------
SECTION VI REACTIVITY DATA
---------------------------------------------------------------------------------------------------------------------------------------
STABILITY: ( ) Unstable, (X) Stable
HAZARDOUS POLYMERIZATION: ( ) May occur, ( X ) Will not occur
INCOMPATIBILITY: Oxidizing material can cause vigorous reaction.
HAZARDOUS DECOMPOSITION PRODUCTS: As with any organic material, combustion will produce
Carbon Monoxide, Carbon Dioxide.
---------------------------------------------------------------------------------------------------------------------------------------
SECTION VII SPILL OR LEAK PROCEDURES
---------------------------------------------------------------------------------------------------------------------------------------
-STEPS TO BE TAKEN IN CASE MATERIAL RELEASED OR SPILLED: Confine as much as possible.
Dike and absorb with inert material such as vermiculite. Transfer to containers for disposal.
-WASTE DISPOSAL METHOD: Dispose of waste in accordance with all Federal, State, and Local ondinances.
--------------------------------------------------------------------------------------------------------------------------------------
SECTION Vlll SPECIAL PROTECTION INFORMATION
---------------------------------------------------------------------------------------------------------------------------------------
.RESPIRATORY PROTECTION: An appropriate NIOSH approved respirator for organic vapors should be
worn.
-VENTILATION: At least ten air changes per hour are recommended for good room ventilation. Local exhaust if
needed to control vapors.
-PROTECTIVE GLOVES: Impervious rubber gloves
-EYE PROTECTION: Chemical splash goggles (ANSI Z 87.1 or approved eqaivalent.)
-OTHER PROTECTIVE EQUIPMENT: wear protective clothing to prevent contact with product. Eye bath and
washing facilities should be available. Wash thoroughly after handling.
---------------------------------------------------------------------------------------------------------------------------------------
SECTION IX SPECIAL PRECAUTIONS
---------------------------------------------------------------------------------------------------------------------------------------
-PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Wear gloves and protective clothing to
prevent contact with product. Store product at temperatures between 49 C/120- F and 2 C/36-F. Do not store
container in direct sunlight.
-SHIPPING INFORMATION:
DOT SHIPPING NAME: Flammable, Toxic, N.O.S. (ethyl alcohol, methanol)
DOT HAZARD CLASS: Class 3 Flammable Poison Liquid
ID Number: UN1986
Emergency Response: 131
---------------------------------------------------------------------------------------------------------------------------------------
SECTION X OTHER REGULATORY REQUIREMENTS
---------------------------------------------------------------------------------------------------------------------------------------
Toxic Substance Control Act: This product is a mixture and each componant is listed in the TSCA Inventory of
Chemical Substances.
SARA TITLE III - Extremely Hazardous Substances
Componant CAS # TPQ RQ
NONE
SARA TITLE III - Toxic Chemical Section 372 (SARA 313)
Componant CAS # WT %
Methanol 67-56-1 13
MIBK 108-10-1 1
CERCLA- Comprehensive Environmental Response Compensation and Liability
Componant CAS # WT % RQ(LBS)
Methanol 67-56-1 13 5000
MIBK 108-10-1 1 5000
This material is listed in all states under the Right to Know Act.
Empty containers should be reconditioned by certified firms(drums, pails). Sale of empty containers should be in
accordance with all applicable laws and reguIations.
-OTHER PRECAUTIONS: Neither this data sheet or any statement contained herem grants or extends
any license, expressly implied in connection with patents issued or pending which may be the property of
the manufacturer or others. The information in this data sheet has been assembled by the manufacturer
based on its own studies and the work of others. The manufacturer makes no warranties, express or
implied, as to the accuracy, completeness, or adequacy of the information contained herein. The
manufaeturer shall not be liable (regardless of fault) to the vendee, the vendee's employees, or anyone for
any direct special or ~consequential damages arising out of or in connection with the accuracy,
completeness, adequacy, or furnishing of such information
.
EFFECTIVE JANUARY 1,1989: Anyone selling or distributing a mixture or trade name product containing a
toxic chemical (ie., a chemical or member of chemical category in 4O CFR Part 372) must provide written notice to
the recipient with the first shipment in each calendar year. This is pursuant to these legal requirements. Please note
that if you are repackage or otherwise redistribute this product, a notice including the SARA 310 information
should be sent to the recipients. If you are unsure of what you must report or require more information, call the EP
A Emergency Planning and Community Right To Know Hotline: (800) 535-0202 or (202) 479-2449.
MSDS's are an important part of employee hazard communication information and training programs required of
employers under the OSHA hazard communication Standard (29 CFR 1910.1200).
|