8/20/2008
Material Safety Data Sheet
Product No.: 2000, 2012, 2014, 2178, 2180X, 2183
1. CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Product Name: Concentrated Tire & Tube Mounting Compound
MSDS Preparation Date: 8/20/2008
Manufacturer: REMA TIP TOP/NO. AMERICA, 119 Rockland Avenue, Northvale, NJ 07647
24-Hour Emergency Phone Number: 800-424-9300 (CHEMTREC)
2. PRODUCT INGREDIENTS
CHEMICAL NAME: CAS NUMBER: % RANGE: OSHA PEL:
Water 7732-18-5 95-98 Not Established
Proprietary Not Available 0.1-1 Not Established
This product is considered not hazardous under 29 CFR 1910.1200 (Hazard Communication).
This product is not regulated under the Canadian Controlled Products Regulations.
3. HAZARDS IDENTIFICATION
POTENTIAL HEALTH EFFECTS:
This product is an amber paste. This product may be slightly irritating to the eyes and skin.
EYE: This product may cause slight irritation to the eyes.
SKIN: This product may cause slight irritation to the skin.
INGESTION: Swallowing large amounts of this product may irritate the digestive system.
INHALATION: Not expected to be an inhalation hazard.
4. FIRST AID
EYES: Immediately flush eyes with plenty of water for at least 15 minutes. If irritation persists get medical attention.
SKIN: For skin contact flush with large amounts of water while removing contaminated clothing. Wash affected area
with mild soap and water. If irritation persists, get medical attention. Wash contaminated clothing before reuse.
INGESTION: Do not induce vomiting, seek medical attention.
INHALATION: If inhaled, immediately remove the affected person to fresh air. If not breathing, give artificial
respiration, preferably mouth-to-mouth. If breathing is difficult, give oxygen. Seek medical attention.
NOTE TO PHYSICIAN: Provide general supportive measures and treat symptomatically.
Page 1 of 6 MSDS ID: RTT-044
8/20/2008
Material Safety Data Sheet
Product No.: 2000, 2012, 2014, 2178, 2180X, 2183
5. FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES:
Flash Point: >104癈 (>220癋) Method Used: Not Available, contains water
Upper Flammable Limit (UFL): Not Available Lower Flammable Limit (LFL): Not Available
Auto Ignition: Not Available Flammability Classification: Not Applicable
HAZARDOUS COMBUSTION PRODUCTS: Upon decomposition, this product emits carbon monoxide, carbon
dioxide and/or low molecular weight hydrocarbons.
EXTINGUISHING MEDIA: Water, water fog, alcohol foam, carbon dioxide, or dry chemical.
FIRE FIGHTING INSTRUCTIONS: This product poses a slight fire hazard. Contain fire run-off if possible.
PROTECTIVE EQUIPMENT FOR FIRE FIGHTERS: Firefighters should wear full-face, self-contained breathing
apparatus and impervious protective clothing.
6. ACCIDENTAL RELEASE MEASURES
CONTAINMENT PROCEDURES: Containment of this material should not be necessary.
CLEAN-UP PROCEDURES: Shovel or gather material and place in appropriate container for disposal. Wash spill area
thoroughly. Wear appropriate protective equipment during cleanup.
EVACUATION PROCEDURES: None necessary.
SPECIAL PROCEDURES: Do not allow product to enter sewer or waterways.
7. HANDLING & STORAGE
HANDLING: Avoid contact with skin and eyes. Wash thoroughly after handling. DO NOT eat, drink or smoke in
product area.
STORAGE: Keep the container tightly closed and in a dry, cool, and well-ventilated place.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Provide adequate local exhaust ventilation to maintain worker exposure below
exposure limits.
PERSONAL PROTRECTIVE EQUIPMENT
EYE/FACE PROTECTION: Wear safety glasses with side shields.
SKIN PROTECTION: Use impervious gloves.
Page 2 of 6 MSDS ID: RTT-044
8/20/2008
Material Safety Data Sheet
Product No.: 2000, 2012, 2014, 2178, 2180X, 2183
RESPIRATORY PROTECTION: Not normally required.
EXPOSURE GUIDELINE(s):
Component Exposure Limits
ACGIH, OSHA, and NIOSH have not developed exposure limits for any of this product's components.
Component Exposure Limits - Canada
The provinces of Canada have not developed exposure limits for any of this product's components. Consult local
authorities for acceptable exposure limits.
9. PHYSICAL & CHEMICAL PROPERTIES
APPEARANCE: Amber paste
ODOR: Bland ODOR THRESHOLD: Not Available
BOILING POINT: >104癈 (>220癋)
SOLUBILITY IN WATER: Complete solubility in water
SPECIFIC GRAVITY: 1.0
VAPOR PRESSURE: Not Available
% VOLATILE: 55
10. STABILITY & REACTIVITY
INCOMPATIBILITY WITH OTHER MATERIALS: Reactive alloys such as aluminum, brass, and bronze. Avoid
contact with strong oxidizing agents.
HAZARDOUS POLYMERIZATION: Will not occur.
DECOMPOSITION PRODUCTS: Upon decomposition, this product emits carbon monoxide, carbon dioxide and/or
low molecular weight hydrocarbons.
11. TOXICOLOGICAL INFORMATION
ACUTE TOXICITY
This product may be slightly irritating to the eyes and skin. It may be harmful by ingestion.
CHRONIC TOXICITY
No additional information available.
Page 3 of 6 MSDS ID: RTT-044
8/20/2008
Material Safety Data Sheet
Product No.: 2000, 2012, 2014, 2178, 2180X, 2183
CARCINOGENICITY
No carcinogenicity data available for this product.
Component Carcinogenicity
None of this product's components are listed by ACGIH, IARC, OSHA, NIOSH, or NTP.
12. ECOLOGICAL INFORMATION
Product is expected to biodegrade.
Component Analysis - Ecotoxicity - Aquatic Toxicity
No ecotoxicity data are available for this product's components.
13. DISPOSAL CONSIDERATIONS
DISPOSAL: Dispose of waste material according to Local, State, Federal, and Provincial Environmental Regulations.
UNUSED & UNCONTAMINATED PRODUCT:
Component Waste Numbers
No EPA Waste Numbers are applicable for this product's components.
Material, if discarded, is not expected to be a characteristic hazardous waste under RCRA.
14. TRANSPORT INFORMATION
US DOT Information
Shipping Name: This product is not regulated as a hazardous material for transport.
TDG Information
Shipping Name: This product is not regulated as dangerous goods for transport.
IMDG Information
Additional Info.: This product is not regulated as dangerous goods for transport.
IATA Information
Additional Info.: This product is not regulated as dangerous goods for transport.
Page 4 of 6 MSDS ID: RTT-044
8/20/2008
Material Safety Data Sheet
Product No.: 2000, 2012, 2014, 2178, 2180X, 2183
15. REGULATORY INFORMATION
US FEDERAL REGULATIONS
SARA 313 INFORMATION:
Component Analysis
None of this products components are listed under SARA Section 313 (40 CFR 372.65).
SARA HAZARD CATEGORY:
Acute Health: No Chronic Health: No Fire: No Pressure: No Reactive: No
COMPREHENSIVE ENVIRONMENTAL RESPONSE COMPENSATION AND LIABILITY ACT (CERCLA):
Component Analysis
None of this products components are listed under CERCLA (40 CFR 302.4).
TOXIC SUBSTANCES CONTROL ACT (TSCA): Components of this product have been checked against the non-
confidential TSCA inventory by CAS Registry Number. Components not identified on this non-confidential inventory are
either exempt from listing (i.e. polymers, hydrates) or are listed on the confidential inventory as declared by the supplier.
Component Analysis - Inventory
Component CAS # TSCA CAN EEC
Water 7732-18-5 Yes DSL EINECS
STATE RIGHT-TO-KNOW:
Component Analysis - State
None of this product's components are listed on the state lists from CA, MA, MN, NJ, PA, or RI.
Other state regulations may apply. Check individual state requirements.
CANADIAN REGULATIONS
This product is not regulated under the Canadian Controlled Products Regulations.
WHMIS INFORMATION:
Component Analysis - WHMIS IDL
No components are listed in the WHMIS IDL.
EUROPE:
Component Analysis
Component (CAS#) EC #
Water (7732-18-5) 231-791-2
Page 5 of 6 MSDS ID: RTT-044
8/20/2008
Material Safety Data Sheet
Product No.: 2000, 2012, 2014, 2178, 2180X, 2183
16. OTHER INFORMATION
NATIONAL FIRE PROTECTION ASSOCIATION (NFPA) RATINGS:
NFPA Ratings: Health: 0 Fire: 1 Reactivity: 0
Hazard Scale: 0 = Minimal 1 = Slight 2 = Moderate 3 = Serious 4 = Severe
MEDICAL EMERGENCIES: FOR ANY OTHER INFORMATION:
Call CHEMTREC 24 hours a REMA TIP TOP/NO. AMERICA
Day for emergency information 119 Rockland Ave.
800-424-9300 NORTHVALE, NJ 07647
201-768-8100
NOTICE: REMA TIP/TOP USA believes that the information contained on this material safety
data sheet is accurate. The suggested procedures are based on experience as of the date of
publication. They are not necessarily all-inclusive nor fully adequate in every circumstance.
Also, the suggestions should not be confused with nor followed in violation of applicable laws,
regulations, rules or insurance requirements.
NO WARRANTY IS MADE, EXPRESS OR IMPLIED, OF MERCHANTABILITY,
FITNESS FOR A PARTICULAR PURPOSE OR OTHERWISE.
Page 6 of 6 MSDS ID: RTT-044
|