?br>
ITW CHEMTRONICS MSDS #0310
SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Company Address:
8125 Cobb Center Drive
Kennesaw, GA 30152
Product Information: 800-TECH-401 Emergency: (Chemtrec) 800-424-9300
Customer Service: 800-645-5244 Revision Date: February 10, 2010
Product Identification
FLUX-OFF?HEAVY DUTY
Product Code: ES1631, ES831B, ES1631C, ES831BC
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name CAS# Wt. % Range
Fluorinated Hydrocarbon (HFE) 163702-07-6/163702-08-7 30.0-50.0
trans-1,2-Dichloroethylene 156-60-5 30.0-50.0
Ethanol 64-17-5 1.0-5.0
1,1,1,2-Tetrafluoroethane 811-97-2 10.0-40.0
Carbon Dioxide 124-38-9 1.0-5.0
SECTION 3: HAZARD IDENTIFICATION
Emergency Overview: Clear, colorless liquid with faint ethereal odor. This product is nonflammable. Liquid may irritate eyes and skin under repeated or prolonged
exposure. Breathing high concentrations of product vapor may produce dizziness and nausea.
Potential Health Effects:
Eyes: Liquid, aerosols and vapors of this product may be irritating and can cause pain, tearing, reddening and swelling accompanied by a stinging sensation.
Skin: Prolonged contact can cause skin irritation, including redness, burning, drying and/or cracking of skin..
Ingestion: May be harmful if swallowed. Swallowing this material may result in nausea, vomiting and weakness followed by central nervous system depression.
Inhalation: Can be harmful if inhaled. High concentrations of vapors in immediate area can cause dizziness, nausea, vomiting, unconsciousness and death.
SECTION 4: FIRST AID MEASURES
Eyes: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Have eyes examined
and tested by medical personnel if irritation develops or persists.
Skin: Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation develops or persist. Wash clothing before reuse.
Ingestion: If swallowed, do not induce vomiting. If conscious, give 2 glasses of water. Never give anything by mouth to an unconscious person. Keep head below knees
to minimize chance of aspirating material into the lungs. Get medical attention immediately.
Inhalation: Remove to fresh air. If breathing is difficult, give oxygen. Get medical attention.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point: None to boiling(TCC)
Extinguishing Media: Use water spray or fog, CO2, dry chemical or water stream when fighting fires involving this material.
Fire Fighting Instructions: As in any fire, wear self-contained breathing apparatus (pressure-demand, MSHA/NIOSH approved or equivalent) and full protective gear.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Spills: Shut off leak if possible and safe to do so. Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal.
Do not flush to sewer. Avoid runoff into storm sewers and ditches which lead to waterways.
SECTION 7: HANDLING AND STORAGE
Avoid prolonged or repeated contact with eyes, skin, and clothing. Wash hands before eating. Use with adequate ventilation. Avoid breathing product vapor or mist.
Do not reuse this container. Store in a cool dry place away from heat, sparks and flame. Keep container closed when not in use. Do not store in direct sunlight.
KEEP OUT OF REACH OF CHILDREN.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Guidelines:
CHEMICAL NAME ACGIH TLV OSHA PEL OTHER
Fluorinated Hydrocarbon(HFE) NE NE 750 ppm (3M)
trans-1,2-Dichloroethylene 200 ppm 200 ppm
1,1,1,2-Tetrafluoroethane NE NE 1000 ppm (Dupont)
Ethanol 1,000ppm 1000ppm
NE = Not Established
NFPA and HMIS Codes: NFPA HMIS
Health 1 1
Flammability 1 1
Reactivity 1 1
Personal Protection - B
Work/Hygienic Practices: Good general ventilation should be sufficient to control airborne levels. If vapor concentration exceeds TLV, use NIOSH approved organic
vapor cartridge respirator. Wear safety glasses with side shields (or goggles) and rubber or other chemically resistant gloves.
Page 1 of 2
?br>
ITW CHEMTRONICS MSDS #0310
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Clear, colorless liquid Solubility in Water: Negligible
Odor: Ethereal Odor Specific Gravity: 1.32
pH: NA (Water =1)
Vapor Pressure: 450 mmHg@ 70F Evaporation Rate: >1 (Butyl acetate=1)
Boiling Point: 106癋 (41C) Percent Volatile: 100%
SECTION 10: STABILITY AND REACTIVITY
Stability - This product is stable.
Conditions to Avoid: Steam, oxidizers, elevated temperatures. Do not spray near open flames, red hot surfaces or other sources of ignition.
Incompatibility: Do not mix with alkali metals, pure oxygen, strong base, open flames, and welding arcs.
Products of Decomposition: Thermal decomposition may release hydrogen chloride, hydrogen fluoride, perfluoroisobutylene and small amounts of phosgene and
chlorine. Solvent decomposition occurs when catalyzed by metal chlorides which can be produced by reaction of HCl and metals in the system. In the presence of
aluminum and excessive water, the decomposition can proceed rapidly with production of large amounts of heat and HCl fumes.
Hazardous Polymerization: Will not occur
Conditions to Avoid: Finely divided active metals, alkali and alkaline earth metals
SECTION 11: TOXICOLOGICAL INFORMATION
Inhalation: Ingestion:
Fluorinated Hydrocarbons (HFE) LC50 rats > 100 000 ppm (4hr)* Fluorinated Hydrocarbon(HFE) LD50/rats >5000 mg/kg*
trans-1,2-Dichloroethylene LC50 rats 24,100 ppm (4hr)* trans-1,2-Dichloroethylene LD50/rats >5 000 mg/kg*
Tetrafluoroethane Rats ALC 567,000ppm/4hrs Ethanol LD50 rat 7060mg/kg
Ethanol LC50 rats 20,000ppm/10hr
Carbon Dioxide LCLo/Human 9pph/5min
Skin Eye:
Fluorinated Hydrocarbon(HFE) 500 mg/rats MLD* Fluorinated Hydrocarbon(HFE) 150 mg/rats/24H MLD*
trans-1,2-Dichloroethylene LD50 rabbit >5,000 mg/kg trans-1,2-Dichloroethylene MOD-SEV*
Ethanol rabbit 400 mg open MLD Ethanol rabbit 500 mg SEV
*Information provided by manufacturer.
Cancer Information: No ingredients in this product are listed as human carcinogens by IARC or NTP.
Reproductive effects: none Teratogenic effects: none Mutagenic effects: none
SECTION 12: ECOLOGICAL INFORMATION
Avoid runoff into storm sewers and ditches which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations require reporting spills of this material that could reach any surface waters.
The toll free number for the US Coast Guard National Response Center is: 1-800-424-8802
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORTATION INFORMATION
Proper Sub. Pkg. Hazard Pkg. Max.
Shipping Name UN Number Class Risk Group Label Instr. Quantity
Air: Aerosols non-flammable UN 1950 2.2 NA NA. Non-flammable 203 75 kg; 150 kg
Ground: Consumer Commodity NA ORM-D NA NA ORM-D Pkg. 173.306
ORM-D Auth.
SECTION 15: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION
This product contains no chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40
CFR 372).
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
All ingredients of this product are listed on the TSCA Inventory.
WHMIS: Class A; Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION
This product is a Level 1 aerosol. Do not puncture or incinerate containers. Normal ventilation for standard manufacturing practices is usually adequate. Local
exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards that may exist.
Page 2 of 2
|