?br>
ITW CHEMTRONICS MSDS #3104L
SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Company Address:
8125 Cobb Center Drive
Kennesaw, GA 30152
Product Information: 800-TECH-401 Emergency: (Chemtrec) 800-424-9300
Customer Service: 800-645-5244 Revision Date: February 10, 2007
Product Identification
FLUX-OFF ?CZ (Liquid)
Product Code: ES7201, ES7205, ES7255, ES7208L, ES7201C, ES7205C, ES7208LC
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name CAS# Wt. % Range
CirozaneTM Mixture 55.0-90.0
trans-1,2-dichloroethylene 156-60-5 5.0-50.0
Methylcyclohexane 108-87-2 1.0-10.0
Methanol 67-56-1 1.0-3.0
SECTION 3: HAZARD IDENTIFICATION
Emergency Overview: Clear, colorless liquid with faint ethereal odor. This product is nonflammable. Liquid may irritate eyes and skin under repeated or prolonged
exposure. Breathing high concentrations of product vapor may produce dizziness and nausea.
Potential Health Effects:
Eyes: Liquid, aerosols and vapors of this product may be irritating and can cause pain, tearing, reddening and swelling accompanied by a stinging sensation.
Skin: Prolonged contact can cause skin irritation.
Ingestion: May be harmful if swallowed. Swallowing this material may result in nausea, vomiting and weakness followed by central nervous system depression.
Inhalation: Can be harmful if inhaled. High concentrations of vapors in immediate area can cause dizziness, nausea and vomiting.
SECTION 4: FIRST AID MEASURES
Eyes: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Have eyes examined
and tested by medical personnel if irritation develops or persists.
Skin: Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation develops or persist. Wash clothing before reuse.
Ingestion: If swallowed, do not induce vomiting. If conscious, give 2 glasses of water. Never give anything by mouth to an unconscious person. Keep head below knees
to minimize chance of aspirating material into the lungs. Get medical attention immediately.
Inhalation: Remove to fresh air. If breathing is difficult, give oxygen. Get medical attention.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point: None to boiling (TCC)
Extinguishing Media: Use water spray or fog, CO2, dry chemical or water stream when fighting fires involving this material.
Fire Fighting Instructions: As in any fire, wear self-contained breathing apparatus (pressure-demand, MSHA/NIOSH approved or equivalent) and full protective gear.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Spills: Shut off leak if possible and safe to do so. Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal.
Do not flush to sewer. Avoid runoff into storm sewers and ditches which lead to waterways.
SECTION 7: HANDLING AND STORAGE
Avoid prolonged or repeated contact with eyes, skin, and clothing. Wash hands before eating. Use with adequate ventilation. Avoid breathing product vapor or mist.
Do not reuse this container. Store in a cool dry place away from heat, sparks and flame. Keep container closed when not in use. Do not store in direct sunlight.
KEEP OUT OF REACH OF CHILDREN.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Guidelines:
CHEMICAL NAME ACGIH TLV OSHA PEL OTHER
CirozaneTM NE NE 750 ppm*
trans-1,2-dichloroethylene 200 ppm 200 ppm
Methanol 200ppm 200ppm
Methylcyclohexane 400 ppm 500 ppm
NE = Not Established
* Chemtronics Recommended Threshold Limit Value
Work/Hygienic Practices: Good general ventilation should be sufficient to control airborne levels. If vapor concentration exceeds TLV, use NIOSH approved organic
vapor cartridge respirator. Wear safety glasses with side shields (or goggles) and rubber or other chemically resistant gloves when handling this material.
NFPA and HMIS Codes: NFPA HMIS
Health 1 1
Flammability 0 0
Reactivity 1 1
Personal Protection - B
Page 1 of 2
?br>
ITW CHEMTRONICS MSDS #3104L
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Clear, colorless liquid Solubility in Water: Negligible
Odor: Ethereal Odor Specific Gravity: 1.36
pH: NA (Water =1)
Vapor Pressure: 220 mmHg@ 70F Evaporation Rate: >1
Percent Volatile: 100% (Butyl acetate=1)
Boiling Point: 90癋 (32C) initial Viscosity: NA
SECTION 10: STABILITY AND REACTIVITY
Stability - This product is stable.
Conditions to Avoid: Steam, oxidizers, elevated temperatures. Do not spray near open flames, red hot surfaces or other sources of ignition.
Incompatibility: Do not mix with chemically active metals such as potassium, magnesium, zinc and powdered aluminum, strong base, caustic soda, caustic potash or
oxidizing.
Products of Decomposition: Thermal decomposition may release carbon monoxide, carbon dioxide, hydrogen chloride and hydrogen fluoride.
Hazardous Polymerization: Will not occur
Conditions to Avoid: Finely divided active metals, alkali and alkaline earth metals
SECTION 11: TOXICOLOGICAL INFORMATION
Inhalation: Ingestion:
trans-1,2-dichloroethylene LC50 rats 24,100 ppm/4hrs Methylcyclohexane LD50 Mouse 2,250 mg/kg
Methanol LC50 rats 64,000ppm/4hrs Methanol LD50 rats 5,628 mg/kg
41,500 mg/m3/2 hrs
Methylcyclohexane LC50/mouse trans-1,2-dichloroethylene LD50 rats >5,000 mg/kg
Skin Eye:
Methanol 20mg/24H MLD Methanol 40 mg MOD
trans-1,2-dichloroethylene LD50 rabbit >5,000 mg/kg trans-1,2-dichloroethylene MOD-SEV
Methylcyclohexane LD50 rabbit >86,700 mg/kg
Cancer Information: No ingredients listed as human carcinogens by NTP or IARC
Reproductive effects: none Teratogenic effects: none Mutagenic effects: none
SECTION 12: ECOLOGICAL INFORMATION
Avoid runoff into storm sewers and ditches which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations require reporting spills of this material that could reach any surface waters.
The toll free number for the US Coast Guard National Response Center is: 1-800-424-8802
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORTATION INFORMATION
Proper
Shipping Name
Air and Ground: Cleaning Compound,
Not Regulated
SECTION 15: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION
This product contains the following toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know
Act of 1986 (40 CFR 372).
Methanol CAS# 67-56-1 1.0-3.0%
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
All ingredients of this product are listed on the TSCA Inventory.
WHMIS: Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION
Normal ventilation for standard manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards that may exist.
Page 2 of 2
|