H.M.I.S. RATING
Health 1
Flammability 0
Reactivity 0
Protective Equip. E
Material Safety Data Sheet ?OSHA 174
Material Safety Data Sheet US Department of Labor
May be used to comply with OSHA's Hazard Occupational Safety and Health Administration
communication Standard, 29 CFR 1910.1200. (Non-Mandatory Form) Form Approved OMB No.
Standard must be consulted for specific 1218-0072
requirements.
Color Concentrate ?Gray ?With Sand Product No. C1140
SECTION I - Manufacturer / Product Information
Manufacturer's Name: Emergency Telephone No.: Chemtrec: 1-800-424-9300
ThorWorks Industries, Inc. Telephone Number for Information: 1-800-326-1994
Address: 2520 South Campbell Street Date Prepared: August 10, 2004
Sandusky, Ohio 44870
SECTION II - Chemical Identity Information
Ingredient CAS # OSHA_PEL ACGIH_TLV Other Limits Percent
Titanium Dioxide 13463-67-7 15 mg/m3 10 mg/m3
Silicon Dioxide 14808-60-7 0.1 mg/m3 0.1 mg/m3
Ethylene Glycol 107-21-1 100 mg/m3 100 mg/m3
Texanol 25265-77-4 N/A N/A
Fibers 9004-34-6 15 mg/m3 10 mg/m3
Iron Oxide 1332-37-2 10 mg/m3 5 mg/m3
SECTION III - Physical / Chemical Characteristics
Specific Gravity (H2O = 1): 1.48
Boiling Point: 100? Celsius (212? Fahrenheit)
Melting Point: N/A
Vapor Pressure (mm Hg): Nearly equal to water.
Vapor Density (AIR = 1): <1 Evaporation Rate (Butyl Acetate = 1): Approximately 1.8
Solubility in Water: Easily dispersible in the liquid state.
Appearance and Odor: Gray liquid, mild odor.
SECTION IV - Fire and Explosion Hazard Data
Flash Point (Method Used): N/A Flammable Limits: N/A LEL: N/A UEL: N/A
Extinguishing Media: Foam, CO2, dry chemical, water fog, other.
Special Fire Fighting Procedures: Full protective equipment, including self-contained breathing
apparatus to be worn. Water cool sealed containers in area of fire to prevent rupture due to steam
generation.
Unusual Fire and Explosion Hazards: N/A
SECTION V - Reactivity Data
Stability: Unstable: Stable: X Conditions to Avoid: Keep from freezing and extreme heat.
Incompatibility (Materials to Avoid): Strong oxidizers.
Hazardous Decomposition or Byproducts: Combustion may yield fumes, smoke, carbon monoxide,
carbon dioxide and other toxic pyrolysis products.
Hazardous Polymerization: May Occur: Will Not Occur: X Conditions to Avoid: N/A
SECTION VI - Health Hazard Data
Route(s) of Entry: Inhalation? Yes Skin Contact? No Ingestion? Yes Eye Contact? Yes
Health Hazards (Acute and Chronic):
(Acute): Dizziness, weakness, nausea, headache.
(Chronic): Gastrointestinal irritation ?prolonged or repeated exposure to high vapor concentrations may
cause damage to kidneys, liver, lungs, blood, or central nervous system. Repeated ingestion may cause
liver damage.
Carcinogenicity: NTP? No IARC Monographs? No OSHA Regulated? No
Signs and Symptoms of Exposure:
Inhalation: Vapor could cause headache, irritation to nose and throat, dizziness, weakness and nausea.
Ingestion: Can cause nausea, vomiting, diarrhea.
Skin: Not easily absorbed ?prolonged or repeated exposure may be mildly irritating to the skin. May cause
allergic skin reactions in some people.
Eye: Irritation from vapor or liquid.
Medical Conditions Generally Aggravated by Exposure: None known.
Emergency and First Aid Procedures:
Inhalation: Remove to fresh air and provide oxygen if breathing is difficult. If not breathing, give artificial
resuscitation. IMMEDIATELY CALL A PHYSICIAN.
Ingestion: If vomiting begins keep head below hips to avoid aspiration into lungs. DO NOT INDUCE
VOMITING. Give victim a glass of water or milk. Never give anything by mouth to an unconscious
person. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
Skin Contact: Wash area with soap and water. Remove contaminated clothing. IF IRRITATION
OCCURS, CALL A PHYSICIAN.
Eye Contact: Gently flush with large amounts water for at least 15 minutes or until eye is clear.
IMMEDIATELY CALL A PHYSICIAN.
SECTION VII - Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled: Dike and contain spill with inert material (sand,
sawdust, diamateous earth, etc.). Pump liquid into storage tanks. Remaining liquid may be taken up with
inert materials. Place in closed container for proper disposal.
Waste Disposal Method: Dispose of in accordance with Local, State, and Federal regulations.
Precautions to Be Taken in Handling and Storage: Keep container closed and upright to prevent
leakage. Avoid freezing or temperatures above 50? Celsius.
Other Precautions: Do not take internally. Keep away from children. Avoid breathing vapors. For
external use only.
SECTION VIII - Control Measures
Respiratory Protection (Specify Type): None required if good ventilation is maintained. Otherwise use
NIOSH approved respirator designed to remove particles and vapor.
Ventilation: Local Exhaust: Yes Special: N/A
Mechanical (General): N/A Other: N/A
Protective Gloves: Yes Eye Protection: Yes
Other Protective Clothing or Equipment: A rubber apron is recommended to protect clothing from
splash during application.
Work/Hygienic Practices: Do not apply during or just before (within one hour) of rain to avoid
contamination of runoff water. Wash hands before eating.
SECTION IX - Disclaimer
All information, recommendations, and suggestions concerning this product are based upon tests, literature
references, and/or calculations, believed to be reliable. The manufacturer makes no guarantee, expressed
or implied, as to the affect of use, or the safety and toxicity of the product. The information contained in
this sheet cannot be taken as the sum total of all protective measures to be taken.
|