MANN BROTHERS PREMIUM PAINTS
MATERIAL SAFETY DATA SHEETS
Feb 1, 2009
NAME: COLOR THEMES ZERO VOC COLORANT
COLOR: L/F MEDIUM YELLOW
PRODUCT CODE: 235-17 AMY
C.A.S. NUMBER: Not Applicable
--------------------------------------------------------------------------------------------------------------------------------------------
SECTION I ?PRODUCT AND COMPANY INFORMATION
Manufacturer: TIBBETTS NEWPORT CORP.
2337 S. Birch St., Santa Ana, CA 92707
tel: 714.546-6661, fax: 714.546-5414
Contact: Shil Park Hazardous Materials Identification System
Telephone: 213.422-0539 ( 0 = none to 4=extreme )
Chemtrec (24 hour): 800.424-9300 Health 1
Product Class: Colorant Flammability 1
Product Number: 235-17 AMY Reactivity 0
Maximum Personal Protection E
---------------------- - - - - - - - - - - - -
SECTION II ?INGREDIENT AND HAZARD INFORMATION
---- NO LEAD, NO ETHYLENE GLYCOL, NO MERCURY ----
Ingredient Name CAS Number Percent(Wt) TWA(ACGIH, US CA OEL) PEL(OSHA)
Titanium dioxide 13463-67-7 10 - 30 10 mg/m3 15 mg/m3
NJTSR No. 0166490-5719P 1-5
---------------- ----- - - - - - - - - - - - - -
SECTION III ?PHYSICAL DATA
APPEARANCE: Paste Yellow Almost odorless
pH: 8.0 ?9.5
BOILING RANGE: 212 Deg F
EVAPORATION RATE: Slower than n-Butyl Acetate
VAPOR DENSITY: Heavier than Air.
NON VOLATILE VOLUME:
NON VOLATILE WEIGHT:
WEIGHT /GALLON: 10.6 Pounds
SOLUBILITY: Solubility in Water - Dispersible
MAXIMUM V.O.C. OF COATING: 0 grams per liter
------------------------------------------------------------------------------------------------------------------------------------------
SECTION IV ?FIRE AND EXPLOSION HAZARD DATA
Flammability Class: N/A Flash Point: N/A LEL: N/A
EXTINGUISHING MEDIA:
- Liquid material should not burn. Dried material will support combustion.
- In case of fire. Use water ( flood with water), dry chemical, or CO2.
SPECIAL FIRE FIGHTING PROCEDURES:
- Not applicable.
UNUSUAL FIRE & EXPLOSION HAZARDS:
1
MANN BROTHERS PREMIUM PAINTS
- Burning will produce hazardous compounds including oxides of carbon.
--------------- - - - - - - - - - - - - - - - - - -
SECTION V: HEALTH HAZARD DATA
May cause eye irritation
May cause respiratory tract irritation
May cause allergic skin reaction
PERMISSIBLE EXPOSURE LEVEL:
-See Sec. VIII
EFFECTS OF OVER-EXPOSURE:
-Eyes: Possible mild irritant.
-Swallowed: May be harmful.
- Skin Contact: Possibly irritation
May cause skin sensitization, an allergic reaction.
-Inhalation: If misted, causes irritation of mucous membranes, nose, eyes, and throat.
May cause coughing and difficulty in breathing.
Chronic Health Hazard
High concentrations of titanium dioxide dust caused microscopic lung tumors in rats in lifetime inhalation
studies. However, DuPont, the primary US manufacturer, based on a review of the test data and based on
an epidemiological study of employees, concludes that titanium dioxide pigment will not cause chronic
respiratory disease in humans at concentrations experienced in the workplace.
FIRST AID:
-Skin: Wash areas with soap and water
-Eyes: Wash with water. If irritation is evident, see physician.
-Inhalation: If inhaled, remove to fresh air. If breathing is difficult, give oxygen. If unconscious, evaluate the need
for artificial respiration. Get immediate medical attention.
-Ingestion: If swallowed, get medical immediately. Only induce vomiting if directed by a physician.
------------- - - - - - - - - - - - - - - - - - - - -
SECTION VI ?REACTIVITY DATA
Stability: [ ] Unstable [ X ] Stable
Hazardous Polymerization: [ ] May Occur [ X ] Will not Occur
INCOMPATIBILITY:
- No hazardous reactions are expected to occur, except materials which react with water.
CONDITIONS TO AVOID:
- Do not permit water reactive璵aterial to mix with this product.
HAZARDOUS DECOMPOSITION PRODUCTS:
-Incomplete combustion may release carbon monoxide.
--------------------------------------------------------------------------------------------------------------------------------------------
SECTION VII ?SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Use personal protective equipment as described in section VIII. Absorb spill with inert material and place
in a chemical waste container. Obey relevant local, state, provincial and federal laws and regulations.
Do not contaminate any lakes, streams, ponds, groundwater, storm water, or soil.
2
MANN BROTHERS PREMIUM PAINTS
WASTE DISPOSAL METHOD:
- Disposal should be done in accordance with prevailing regulations.
--------------------- - - - - - - - - - - - - -
SECTION VIII 璖PECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION:
A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 or applicable federal/provincial
Requirements must be followed whenever workplace conditions warrant respirator use. NIOSH's "Respirator
Decision Logic" may be useful in determining the suitability of various types of respirators.
VENTILATION:
-Provide sufficient mechanical (general and/or local exhaust) ventilation to maintain
exposure below TLV.
HAND PROTECTION:
-Use impermeable gloves.
Personal protective equipment that provides a barrier to prevent dermal exposure to this substance
is required.
EYE PROTECTION:
-Chemical splash goggles in compliance with OSHA regulations are advised; however
OSHA regulations also permit other type of safety glasses. (Consult your safety equipment
Supplier).
OTHER PROTECTIVE EQUIPMENT:
-Protective apron if splashing is expected.
---------------- - - - - - - - - - - - - - - - - - -
---SECTION IX ?SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
-Do not allow material to freeze.
OTHER PRECAUTIONS:
-Prevent from freezing.
U.S. DEPARTMENT OF TRANSPORTATION CLASSIFICATION:
-Not Regulated.
D.O.T. PROPER SHIPPING NAME:
-Paint.
EMERGENCY RESPONSE GUIDEBOOK:
-Not Applicable.
ABBREVIATIONS: ACGIH = American conference of Governmental Industrial Hygienists.
OSHA = Occupational Safety and Health Administration.
TLV = Threshold Limit Value
LEL = Lower Explosive Limit
TSCA = Toxic Substance Control Act.
PEL = Permissible Exposure Limit.
TWA = Time Weighted Limit.
STEL = Short-Term Exposure Limit
CAS # = Chemical Abstracts Service Registry Number.
DOT = U.S. Department of Transportation
3
MANN BROTHERS PREMIUM PAINTS
EMERGENCY CONTACT: "CHEMTREC" 800.424-9300. This telephone number is to be used ONLY in case
of transportation emergencies involving a spill, leak, fire, exposure or accident involving chemicals.
NO WARRANTY: We cannot reasonably anticipate or control the many different and varying conditions under, or
methods by which this MSDS information and our product may be used. Therefore, we do not guarantee the
applicability of this MSDS information or the suitability of this product in any individual situation. All
purchasers and users of this product are hereby put on notice that any advice provide over-the counter is not a
warranty and is not to be relied upon, and further that no one is authorized to make any representations or
warranties relative to this product, including any and sellers of this product. This product is sold WITHOUT
WARRANTY, expressed or implied, and any claim of any kind is limited to the purchase price of this product.
---------------------- - - - - - - - - - - - -
SECTION X: ADDITIONAL REGULATORY INFORMATION
SARA TITLE III SECTION 313: This product contains the following toxic chemicals subject to the reporting
requirements of section 313 of the Emergency Planning and Community right to Know Act of 1986 and
CFR 372:
None listed
Toxic Substances Control Act (TSCA)
If listed below, non-proprietary substances are subject to export notification under Section 12 (b)
of TSCA:
None listed
California Proposition 65
A warning under the California Drinking Water Act is required only if listed below:
None listed
4
|