U.S. Oil Co., Inc.
Lubricants Division
425 S. Washington St. Combined Locks, WI 54113
Phone 920-735-8298
205
PRODUCT NO.:
MATERIAL SAFETY DATA SHEET
A/R Packaging
PRODUCT TRADE NAME: Fisher EZ Flow Hydraulic Fluid
REVISION NUMBER: 1050
PREPARATION/REVISION DATE: 10/06/03
REVISED FROM (DATE): 07/24/03
EMERGENCY PHONE #: (920)-735-8298
NFPA CODE: Health: 2 Fire: 1 Reactivity: 1
HMIS CODE: Health: 1 Fire: 1 Reactivity: 1
SECTION 1 - HAZARDOUS INGREDIENTS
This material is not known to contain greater than 0.1% of any carcinogen required to be listed under the
OSHA Hazard Communication Standard (29 CFR 1910.1200).
Component Cas # OSHA PEL ACGIH TLV
5mg/m3 5 mg/m3
Hydrotreated lube oil 64742-53-6
5 mg/m3 5 mg/m3
Distillate solvent dewaxed oils 64742-65-0
10 mg/m3 10 mg/m3
Diphenylamine 122-39-4
5 mg/m3 5 mg/m3
Distillate solvent dewaxed oils 64742-55-8
5 mg/m3 5 mg/m3
Hydrotreated lube oil 64741-89-5
5 mg/m3 5 mg/m3
Hydrotreated paraffinic oils 64741-88-4
SECTION 2 - FIRE AND EXPLOSION HAZARDS
246oF
FLASH POINT:
FLAMMABLE LIMIT: 10% (Estimated value)
LOWER FLAMMABLE LIMIT: 1% (Estimated value)
EXTINGUISHING MEDIA:
CO2, dry chemical, foam, water spray, water fog
SPECIAL FIRE FIGHTING PROCEDURES:
Wear self contained breathing apparatus with full face piece. Cool exposed containers with water
spray. Avoid breathing fumes.
1
UNUSUAL FIRE & EXPLOSION HAZARDS:
Toxic fumes may be evolved on burning or exposure to heat. Pressure may increase in
overheated closed containers. Store below 120癋.
SECTION 3 - HEALTH HAZARD DATA
?ACUTE EXPOSURE ?br>
ORAL TOXICITY: The LD50 in rats is > 5000 mg/kg. Based on data from components or similar
materials.
EYE IRRITATION: Eye irritant. Based on data from components or similar material.
SKIN IRRITATION: Skin irritant. Based on data from components or similar materials. Prolonged or
repeated skin contact as from clothing wet with material may cause dermatitis.
Symptoms may include redness, edema, drying, defatting and cracking of the
skin.
DERMAL TOXICITY: The LD50 in rabbits is > 2000 mg/kg. Based on data from components or similar
materials.
INHALATION TOXICITY: High concentrations may cause headaches, dizziness, concentrations
may cause narcosis (sleepiness, drowsiness).
RESPIRATORY IRRITATION: If material is misted or if vapors are generated from heating, exposure
may cause irritation of mucous membranes and the upper respiratory
tract similar to that observed with mineral oil. Based on data from
components or similar materials. Under good industrial hygiene
practices where all exposure limits are observed respiratory irritation
should not be a problem.
DERMAL SENSITIZATION: No data available to indicate product or components may be a skin
sensitizer.
INHALATION SENSITIZATION: No data available to indicate product or components may be a
respiratory sensitizer.
?CHRONIC EXPOSURE ?br>
CHRONIC TOXICITY: No data available to indicate product or components present at greater than 1%
are chronic health hazards.
CARCINOGENICITY: No data available to indicate any components present at greater than 0.1% may
present a carcinogenic hazard.
2
MUTAGENICITY: No data available to indicate product or any components present at greater than
0.1% are mutagenic or genotoxic.
REPRODUCTIVE TOXICITY: No data available to indicate either product or components present a
greater than 0.1% that may cause reproductive toxicity.
TERATOGENICITY: No data available to indicate either product or components contained at greater
than 0.1% may cause birth defects.
?ADDITIONAL INFORMATION ?br>
OTHER: No other health hazards known.
EXPOSURE LIMITS: See Hazardous Ingredients Section for any applicable exposure limits for
components.
SECTION 3A - EMERGENCY FIRST AID PROCEDURES
SKIN: Wash with soap and water. Get medical attention if irritation develops. Launder
contaminated clothing before reuse.
EYE: Flush with water at least 15 minutes. Get medical attention if eye irritation develops or
persists.
INHALATION: Remove exposed person to fresh air if adverse effects are observed.
ORAL: DO NOT INDUCE VOMITING! If conscious, give 2 glasses of water. Get immediate
medical attention.
ADDITIONAL: Note to physician: treat symptomatically.
SECTION 4 - SPECIAL PROTECTION INFORMATION
VENTILATION PROCEDURE: Use local exhaust ventilation to control dust.
GLOVE PROTECTION: Neoprene or Nitrile Gloves Recommended.
EYE PROTECTION: Safety glasses recommended.
RESPIRATORY PROTECTION: Normally not required, mask or respirator for mists.
CLOTHING RECOMMENDATION: As needed to prevent repeated or prolonged contact.
3
SECTION 5 - PHYSICAL DATA
VAPOR PRESSURE: Less than 0.01 mm Hg @ 20 C
PH: Essentially Neutral
SPECIFIC GRAVITY: 0.8
LB/GAL: 7.4
WATER SOLUBILITY: Insoluble
PERCENT VOLATILE: Negligible from open container in 4 hours @ 38 C (100 F)
VAPOR DENSITY: Greater than 1 (Air = 1)
EVAPORATION RATE: Less than 0.01 (@1 ATM and 25 C. n-butyl acetate = 1)
ODOR: Mild Petroleum oil like
APPEARANCE: Blue Viscous Liquid
VISCOSITY: 14.0 ?16.0cSt @ 40? C 5.1 Ref. cSt @ 100癈
SECTION 6 - STABILITY
STABILITY: Stable
INCOMPATIBILITY: Oxidizing agents and acids.
POLYMERIZATION: Will not occur.
THERMAL DECOMPOSITION: Smoke, carbon monoxide, aldehydes and other products of
incomplete combustion. Hydrogen sulfide and short chain alkyl
mercaptans may also be released. Under combustion
conditions, oxides of the following elements will be formed:
Nitrogen, Phosphorus, Sulfur.
SECTION 7 - SPILL OR LEAK PROCEDURES
SPILL PROCEDURES: Prevent entry into sewers and waterways. Pick up free liquid for recycle or
disposal. Absorb small amounts with an inert material.
WASTE DISPOSAL: Dispose according to current local, state and federal regulations. Materials may
become hazardous waste through use. If permitted, incineration may be
practical. Consider recycling.
4
SECTION 8 - SPECIAL PRECAUTIONS
SPECIAL PRECAUTIONS: Keep containers closed when not in use. Do not handle or store near
high heat or flames. Avoid breathing oil mists, wash skin thoroughly with
soap and water after handling.
SECTION 9 - TRANSPORTATION AND OSHA LABELING INFORMATION
TRANSPORTATION INCIDENT INFORMATION: For further information relative to spills resulting
from transportation incidents, refer to latest Department of Transportation Emergency Response
Guidebook for Hazardous Materials Incidents.
U.S. DOT HAZARDOUS MATERIALS SHIPPING DESCRIPTION: Not Regulated.
OSHA REQUIRED LABEL INFORMATION: In compliance with hazard and right-to-know
requirements, where applicable OSHA Hazard Warnings may be found on the label, bill of lading
or invoice accompanying this shipment.
The information presented herein has been compiled from sources considered to be dependable
and is accurate to the best of seller's knowledge, however, seller makes no warranty whatsoever,
expressed, implied or of merchantability regarding the accuracy of such data or the results to be obtained
from the use thereof, seller assumes no responsibility for injury to buyer or to third persons or for any
damage to any property and buyer assumes all such risks.
N.A. = Not Applicable N.D. = Not Determine N.E. = Not Established
5
|