Material Safety Data Sheet MSDS
Section 1 ?CHEMICAL PRODUCT AND COMPANY INFORMATION
Product Brand: Product Part #:
Bar's Leaks? P30L
Product Name:
Bar's Products Power Steering Stop Leak
720 West Rose Street 24-Hour Emergency U.S. & Canada 1-800-255-3924
CHEMTEL INC. International 813-248-0585
P.O. Box 187
Information: 1-248-634-8278 /
Holly, Michigan 48442
www.barsleaks.com
Date Prepared: 09-02-05
Section 2--COMPOSITION / INFORMATION ON INGREDIENTS
Hazardous Components (Specific Chemical Identity, Common CAS NUMBER OSHA ACGIH Other %
Name(s)) PEL TLV Limits (optional)
Severely hydrotreated heavy base oil 64742-52-5 500 ppm 100 ppm
Severely hydotreated light base oil 64742-53-6 500 ppm 100 ppm
Tricresyl phosphate 68952-35-2 NE NE
Alkenyl carboxylic acid Trade Secret 1 NE NE
Heterocyclic Ether Trade Secret 2 NE NE
N. Phenylbenzeamine 68411-46-1 NA NA
Diphenlamine 122-39-4 NA NA
All other components are considered to be non-hazardous as per OSHA 29 CFR 1910.1200.
Section 3--HAZARDS IDENTIFICATION
Potential Health Effects: EYE - Irritation, redness, stinging.
SKIN - Dryness, irritation, redness.
INHALATION - Vapors may irritate nose, throat, and respiratory tract.
INGESTION - Nausea, vomiting, dizziness, headache, blurred vision.
Acute Health Hazards: Mild eye irritation, prolong or repeated exposure may cause moderate corneal injury and effect\
may be slow to heal. Exposure may cause skin irritation. Prolonged or repeated exposure
may cause drying, redness and cracking of the skin. Skin absorptions possible but harmful
effects are not expected from this route of exposure under normal conditions of handling and
use. Short-term toxicity from inhalation of mists and vapors is low. Breathing small amounts
during normal handling is not likely to cause harmful effects breathing large amounts may be
harmful to note, throat and /or respiratory tract Harmful or fatal if swallowed. Pulmonary
aspiration hazard if swallowed and/or vomiting occurs--can enter lungs and cause damage.
Chronic Health Hazards: None expected at the industrial level.
Medical Conditions Disorders or disease of the skin, or respiratory system.
Aggravated by Exposure:
Target Organ Effects: No data available.
Carcinogenicity: OSHA IARC NTP
No No No
Section 4--FIRST AID MEASURES
Eye: If symptoms develop, move individual away from exposure and into fresh air. Flush eyelids with water
while holding eyelids apart. If symptoms persist or there is any visual difficulty, get medical
attention.
Skin Contact: Wash with soap and water and then flush with water until all chemical is removed. Remove
contaminated clothing promptly and wash before reuse. If irritation persists get medical attention.
Inhalation: Remove to fresh air. If breathing has stopped, give artificial respiration, provided a qualified individual
is available. If breathing is difficult, give oxygen, provided a qualified operator is available. Get
prompt medical attention.
Ingestion: DO NOT induce vomiting. This material is an aspiration hazard. Drink large amounts of water. If
vomiting occurs, give additional water. If drowsy or unconscious, place on left side with head down.
Seek medical attention immediately.
Note To Physician: Treat for clinical symptoms.
1
Section 5--FIRE FIGHTING MEASURES
Flash Point (Method Used): >250癋
Flammable LEL (lower explosion limit): N/E
Limits UEL (upper explosion limit): N/E
Extinguishing Media: Regular foam, dry chemical, carbon dioxide.
Special Fire Fighting Procedures: Wear a self contained breathing apparatus with full face-piece operated in the
positive pressure demand made with appropriate turnout gear and chemical
resistant personal protective equipment. Do not use a direct stream of water,
product will float and can be re-ignited on surface of water.
Unusual Fire and Explosion Hazards: Keep fire or heat exposed containers cool to prevent explosion.
NFPA National Fire Protection Agency: Health 1 Flammability 1 Reactivity 0
HMIS Hazardous Material Identification: Health 1 Flammability 0 Reactivity 0 PPE B
Section 6--ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedures: Dike or pillow area. Remove all sources of irrigation. Ventilate area if necessary.
Absorb free liquid with earth, sand, clay or absorbent pads and place in non-leak
containers for disposal. Flush area for trace residue and dispose of as below. Wear
respiratory protection for large spill, leak or release. Use personal protective
equipment as stated in Section 8. Do not flush to drain/storm sewer.
Section 7--HANDLING AND STORAGE
Storage Temperature (MIN/MAX): Shelf Life:
N/E N/E
Handling/Storage Precautions: Store in original container in area inaccessible to children and pets. Do not reuse
container. Do not sore sealed container near extreme heat. Do not store or mix with
strong oxidizers. Avoid exposing product to freezing temperatures.
Section 8--EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls: Mechanical to maintain exposure below TLV(s).
Respiratory Protection: Normally not needed in well ventilated area. If workplace exposure limit(s) of product or any
component is exceeded (See exposure guidelines), A NIOSH approved air supplies respirator is
advised.
Skin Protection: Rubber gloves and full work clothing to minimize exposure.
Eye Protection: Goggles or safety glasses. Provide eye wash station and washing facilities near use or handling
facilities.
Section 9--PHYSICAL / CHEMICAL PROPERTIES
Physical State: Freezing Point:
Liquid N/D
Appearance: Melting Point:
Amber liquid, slight hydrocarbon N/A
Odor: Boiling Point 癋 (癈):
Slight hydrocarbon odor >480 degrees F
Solubility in Water: Evaporation Rate:
Negligible <1
2 Vapor Density (AIR = 1):
.872 @ 20癈 >1
Specific Gravity (H 0 = 1):
pH: Vapor Pressure (mm Hg):
N/A N/D
Percent Volatiles (VOC): 0%
Section 10--STABILITY AND REACTIVITY
Chemical Stability: Stable
Incompatibility: Oxidizing materials
Hazardous Decomposition Products: Thermal decomposition products are highly dependent on the combustion
conditions. A complex mixture of airborne solid, liquid, particulates and gases will
evolve when this material undergoes pyrolysis or combustion. Carbon monoxide,
heat. Other unidentified organic compounds may be formed during combustion.
Hazardous Polymerization: Will not occur
2
Contact with open flame, heat other
Conditions to Avoid:
Section 11--TOXICOLOGICAL INFORMATION
Long-term toxicological studies have not been conducted fro this product.
Section 12--ECOLOGICAL INFORMATION
Ecotoxicological Information: No data available
Environmental Fate: No data available
Section 13--DISPOSAL CONSIDERATIONS
Spilled material, unused contents and empty containers must be disposed of in accordance with local, state and federal
regulations.
Section 14--TRANSPORTATION INFORMATION
U.S. Proper Shipping Name: N/A
DOT (Domestic Surface) Hazard Class or Division: N/A
IMO / IMDG (Ocean) Hazard Class Division Number: N/A
ICAO / IATA (Air) Hazard Class Division Number: N/A
Section 15--REGULATORY INFORMATION
SARA Title III Section 302 Extremely Hazardous Substances: None
SARA Title III Section 311/312 Hazard Categories: N/A
SARA Title III Section 313 Toxic Chemicals: None
OSHA Status: Not regulated
TSCA Status: Chemical components listed on TSCA inventory
CERCLA Reportable Quantity: N/A
Section 16--OTHER INFORMATION
N/A Not Applicable N/E Not Established
N/D Not Determined
Last Page
3
|