Rayovac Corporation
601 Rayovac Drive
Madison WI 53711
Phone: 608-275-3340
Fax: 608-275-4577
http://www.rayovac.com
MATERIAL SAFETY DATA SHEET
1. We would like to inform our customers that these batteries are exempt articles and are not subject to the 29 CFR
1910.1200 OSHA requirements, or to the Canadian WHMIS requirements and the sheets are supplied as a service to you.
For other MSDSs and related information, visit: http://www.rayovac.com/technical/msds.htm
2. THESE BATTERIES MAY NOT BE SUITABLE FOR LANDFILL DISPOSAL (SEE SECTION 7).
1. IDENTIFICATION
PRODUCT NAME: Lithium Iron Disulfide Batteries (FR)
Environmental Health & Safety Information: 608-275-4846
EDITION DATE: 3-01-2010 APPROVED BY: Kevin J. Domack
2. INGREDIENTS
INGREDIENT NAME CAS # % TLV*
Iron Disulfide 12068-85-8 30-40 None established
Steel as metal -- 35-45 None established
Carbon Black 1333-86-4 1-3 3.5 mg/m3 TWA
Graphite 7782-42-5 1-3 15 mppcf
Propylene Carbonate 108-32-7 <1 None Established
Lithium Perchlorate 7791-03-9 0.5 - 2 None established
Dimethoxyethane (1,2) 110-71-4 2-4 None Established
Lithium 7439-93-2 1-3 None Established
1,3 Dioxolane 646-06-0 5-9 20 ppm TWA**
*Source: OSHA 29 CFR 1910.1000 Table Z-1, 2 or 3 3-01-2010 **ACGIH
3. PHYSICAL DATA
Boiling Point @ 760 mm Hg (癈): NA
Vapor Pressure (mm Hg @ 25癈): NA
Vapor Density (Air = 1): NA
Density (grams/cc): NA
Percent Volatile by Volume (%): NA
Evaporation Rate (Butyl Acetate = 1): NA
Physical State: NA
Solubility in Water (% by Weight): NA
pH: NA
Appearance and Odor: cylindrical solid product - AA and AAA sizes
NA = Not Applicable Lithium Iron Disulfide Batteries-(FR) AA and D 3-01-2010.doc Page
1 of 3
NA = Not Applicable Lithium Iron Disulfide Batteries-(FR) AA and D 3-01-2010.doc Page
2 of 3
4. FIRE & EXPLOSION HAZARD DATA
FLASH POINT: NA LOWER (LEL): NA
FLAMMABLE LIMITS IN AIR (%): NA UPPER (UEL): NA
EXTINGUISHING MEDIA: Use foam, dry powder, Lithex (or water*) as appropriate.
AUTO-IGNITION: NA
SPECIAL FIRE FIGHTING PROCEDURES: As with any fire, wear self-contained breathing apparatus to avoid
inhalation of hazardous decomposition products (See section 2). Water will cool the fire but may react with available lithium
in the batteries producing hydrogen. Use fire fighting materials and techniques appropriate to the specific fire situation.
*Do not use water on these batteries if fire fighting within an enclosed area. Evolving hydrogen may build up
and autoignite.
SPECIAL FIRE OR EXPLOSION HAZARDS: DO NOT RECHARGE. As a typical sealed battery they may
rupture when exposed to excessive heat. Rupture may expose lithium that will react or release flammable or corrosive
materials. Batteries in fire may produce sulfur dioxide gas or lithium hydroxide fumes.
5. HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE (TLV) AND SOURCE: NA
EFFECTS OF OVEREXPOSURE: None in normal use
EMERGENCY FIRST AID PROCEDURES:
Skin and Eyes:
In the event that battery ruptures, flush exposed skin with copious quantities of flowing lukewarm water for a minimum of 15
minutes. Get immediate medical attention when eyes may have been exposed to contents.
Swallowing:
LITHIUM COIN CELL SAFETY NOTICE: Keep lithium coin batteries out of the reach of small
children; coin cell batteries can be accidentally ingested. If ingested, these batteries may leak harmful
contents causing chemical burns, perforation of soft tissue, and in severe cases may cause death. Lithium
coin batteries must be removed immediately if swallowed. Seek medical attention immediately. If you or
your doctor suspects that a battery has been ingested-for assistance in the US call the NATIONAL
BATTERY INGESTION HOTLINE any time at (202) 625-3333: in Canada call 416-813-5900
For more information, visit: http://www.nema.org/gov/ehs/committees/drybat/.
6. REACTIVITY DATA
STABLE OR UNSTABLE: Stable INCOMPATIBILITY (MATERIALS TO AVOID): NA
HAZARDOUS DECOMPOSITION PRODUCTS: NA DECOMPOSITION TEMP.(0癋): NA
HAZARDOUS POLYMERIZATION: Will Not Occur
CONDITIONS TO AVOID: Avoid electrical shorting or rupturing the battery.
NA = Not Applicable Lithium Iron Disulfide Batteries-(FR) AA and D 3-01-2010.doc Page
3 of 3
7. SPILL OR LEAK PROCEDURES
PROCEDURES TO CONTAIN AND CLEAN UP LEAKS OR SPILLS: In the event of a battery rupture,
prevent skin contact and collect all released material in a plastic lined metal container.
REPORTING PROCEDURE: Report all spills in accordance with Federal, State and Local reporting
requirements.
WASTE DISPOSAL METHOD: Always comply with Federal, state or local requirements. Hazardous waste
generators should check with the USEPA or their state authorized agency for guidance. For a list of facilities
that may treat quantities of waste lithium batteries visit:
http://www.nema.org/gov/ehs/committees/drybat/
8. PROTECTION INFORMATION
RESPIRATORY PROTECTION (SPECIFY TYPE): NA
VENTILATION: Local Exhaust: NA
Mechanical (General): NA
Special: NA
Other: NA
PROTECTIVE GLOVES: NA
EYE PROTECTION: NA
OTHER PROTECTIVE CLOTHING: NA
9. SPECIAL PRECAUTIONS
HANDLING AND STORAGE: Store in a dry place. Storing unpackaged cells together with other combustible materials
could result in cell shorting and fire. Do not recharge. Do not puncture or abuse.
TRANSPORTATION-SHIPPING: These are lithium metal batteries and cells, also known as primary or non-
rechargeable lithium. These batteries, unless exempted, are regulated as Class 9, UN3090. Our batteries meet the requirements
listed in the provisions and when in our original packaging meet the packing instructions noted below and may be classified as
non-dangerous goods for transportation.
USDOT ?See Special provision 188.
IMDG/Ocean ?See Special provision 188.
ICAO/Air ?See packing instruction 968. (Note for lithium metal batteries packed with equipment use packing instruction 969
instead and for lithium metal batteries packed in equipment use packing instruction 970.)
For more information, visit: www.rayovac.com/technical/index.htm
10. SARA 313
Notification is not required because these products are article(s) that do not release a covered toxic chemical under the normal
conditions of storage, use, or handling.
NOTICE: The information and recommendations set forth are made in good faith and are believed to be accurate at the date
of preparation. Rayovac Corporation makes no warranty expressed or implied.
NA = Not Applicable Lithium Iron Disulfide Batteries-(FR) AA and D 3-01-2010.doc Page
4 of 3