CHRISTRIO
Manufacturer of Beauty Products
1950 Compton Ave. Ste. 103
Corona, CA. 92881
Phone: (951) 808 ?4730 Fax: (951) 808 ?4734
MATERIAL SAFETY DATA SHEET
Section I: Product and Company Identification
Product name: BASIC ONE ?Xpress Gel (All Colors)
Chemical Name: N/A
CHRISTRIO CORP.
Manufacturer:
Family Name: UV GELS 1950 Compton Ave. #103
Corona, CA. 92881
Product Use: Professional use only
Emergency Phone #: 800 535- 5053
Product: #4020081 International Phone #: 1-352-323-3500
Information Contact: (951) 808 ?4730
Section II: Product composition/Ingredients
Exposure Limits Carcinogen
Chemical Identity/ INCI Name CAS# %
OSHA ACGIH IARC/NTP/
OSHA
TWA/STEL TWA/STEL
Di-HEMA Trimethylhexyl Dicarbanate 72869-86-4 N/E N/E Not Listed 73
PEG-4 Dimethacrylate 109-17-1 N/E N/E Not Listed 18
Ethyl Methacrylate 97-63-2 100 ppm 100 ppm Not Listed 4
Hydroxycyclohexyl phenyl ketone 947-19-3 N/E N/E Not Listed 3
Violet 2/CI607 3844-45-9 N/E N/E Not Listed 1
Hazard Symbols: Xi, F Risk Phrases: R20, R43 Safety Phrases: S24/25, S28A, S37, S45
May contain 0-1% of one or more of the following:
Exposure Limits Carcinogen
Chemical Identity/ INCI Name CAS# %
OSHA ACGIH IARC/NTP/
OSHA
TWA/STEL TWA/STEL
Glitters Exempt N/E N/E Not Listed 0-1
Blue 1/CI42090 N/E 2ppm 3/no/no 0-1
3844-45-9
Carmine/CI75470 N/E N/E Not Listed 0-1
1390-65-4
Glycerin N/E N/E Not Listed 0-1
56-81-5
Iron Oxide/CI77499 N/E N/E Not Listed 0-1
1309-37-1
Mica N/E N/E Not Listed 0-1
12001-26-2
Red 30/CI73360 N/E N/E Not Listed 0-1
2379-74-0
1
Red 7/CI15850 N/E N/E Not Listed 0-1
5281-04-9
Titanium Dioxide/CI77891 N/E N/E Not Listed 0-1
13463-67-7
Violet 2/CI60725 N/E N/E Not Listed 0-1
81-48-1
Yellow 5/CI19140 N/E N/E Not Listed 0-1
1934-21-0
N/E ?None Established
N/R ?Not Reviewed
ND/A ?No Data Available
N/A ?Not Available
Section III: Hazard Identification
EMERGENCY OVERVIEW
?May be slightly toxic
?May cause moderate skin injury (reddening and swelling)
?May cause chemical burn in eye
Method:
*This product is a combustible liquid. This product may ignite readily and decompose to produce
carbon oxides.
Extinguishing Media: Use dry chemical for small fires; aqueous foam or water for large
fires.
Fire Fighting Instructions: Remove all ignition sources. Wear self-contained breathing
apparatus and complete personal protective equipment when
entering confined areas where potential for exposure to vapors or
products of combustion exists.
Unusual Hazards: High temperatures and fir conditions may cause rapid and
uncontrolled polymerization which can result in explosions and the
violent rupture of storage vessels or containers. Avoid the use of a
stream of water to control fires since frothing can occur.
Section VI: Accident Release Measures
Spill or Release Procedure: Small spilled (e.g., <1 gallon). Wear appropriate protective goggles
and gloves, remove spill with absorbent materials and place into
appropriate closed container for disposal. Large spilled (e.g., >1
gallon). Eliminate all sources of heat and ignition. Use absorbent
materials for spill and wash spill material into retaining containers.
Place containers in a well ventilated area. Consult an expert on
disposal of recovered material and ensure conformity to local
disposal regulations. Keep unnecessary and unprotected personnel
entering. Contain and recover liquid when possible. Use non-
sparking tools and equipment. Collect liquid in an appropriate
container or absorb with an inert material (e.g., vermiculite, dry
sand, earth), and place in a chemical waste container. Do not use
combustible materials, such as sawdust. Do not flush to sewer! US
Regulation (CERCLA) require reporting spills and release to soil,
2
water, and air in excess of reportable quantities. The toll free
number for the US Coast Guard National Response Center is (800)
424-8802. EU Regulations require the consultation of Directive
98/24/EC. If a leak or spill has not ignited, use water spray to
disperse the vapors, to protect personnel attempting to stop leak,
and to flush spills away from exposures.
Section VII: Handling and Storage
Handling: Avoid contact with skin and eyes, and clothing. Use with adequate
ventilation and avoid breathing in vapor. Keep container closed
when not in use. Avoid prolonged exposure to light. Remove all
contaminated clothing, shoes, belts and other leather goods
immediately. Incinerate leather goods (including shoes). Wash
contaminated clothing thoroughly before reuse. Wash skin
thoroughly with soap and water after handling. Solvents should not
be used to clean skin because of increased penetration potential.
Material is extremely light sensitive. Use extreme care and do not
expose to natural or UV light. Unless using material for it's
purposes. Since the material is very photosensitive any type of light
may initiate the hardening (cure) process.
Storage: Store in a tightly closed container. Store in a cool, dry place, away
from heat and light. Store at temperatures below 100篎/38篊. Store
product in a totally opaque container.
Explosion Hazard: High temperature and fire conditions may cause rapid and
uncontrolled polymerization which can result in explosions and the
violent rupture of storage vessel or containers.
Section VIII: Exposure Controls/Personal Protective Equipment
Engineering Control Local exhaust recommended to control exposure which may result
from operations generating aerosols and hot operations generating
vapors.
Personal Protective Equipment
General To identity additional Personal Protective Equipment (PPE)
requirements, it is recommended that a hazard assessment in accordance
with the OSHA PPE Standard (29CFR1910.132), or European Standard
EN166 be conducted before using this product. Provide eye wash
station impervious clothing to prevent ANY contact with this product,
such as gloves, apron, boots, or whole body suit. Nitrile rubber is better
than PVC.
Eye/Face Protection Wear chemical splash goggles.
Skin Protection Wear impervious gloves (Neoprene).
Respirator Protection A NIOSH/MSHA approved air purifying respirator with an organic
vapor cartridge or canister may be permissible under certain limited
circumstances where airborne concentrations are expected to exceed
exposure limits. Protection provided by nuisance level organic vapor
dust masks can be used, however the use of the respirator is limited.
3
Follow OSHA respirator regulations found in 29 CFR 1910.134 or
European Standard EN 149.
Section XI: Physical and Chemical Properties
Odor & Odor Special %
Appearance pH Viscosity
Threshold Gravity Volatile
Clear, semi-viscous Characteristic (H2O = 1): By Volume:
N/A N/DA
liquid Acrylate Odor 1.15 0.5
Decomposition Octanol/Water Vapor Vapor Evaporation Ignition Solubility
Boiling
Point/ Temperature Partitioning Pressure Density Rate in Water
Freezing (20C)
Coefficient
Point Log Po/w
Not (mm Hg)
N/A N/A No Data No Data No Data Insoluble
Applicable @20篊:0.01
Flash Point Flammable Limit Auto-ignition Temperature
(篎/篊) (vol%) (vol%)
ND/A ND/A
>110篎/43篊 Penske-Martin
Section X: Stability and Reactivity
Stability: Normally Stable Incompatibility (Materials to Avoid):
Polymerization initiators including peroxides, strong
oxidizing agents, copper, copper alloys, carbon steel,
iron, rust and string bases.
Hazardous Decomposition Products: Fumes produced Hazardous Polymerization:
when heated to decomposition may include: carbon May occur--Uncontrolled polymerization may cause
monoxide, carbon dioxide. rapid evolution of heat and increased pressure that could
result in violent rupture of sealed storage vessels or
containers.
Condition to Avoid:
Storage > 100篎/38篊, exposure to light, loss of dissolved air, loss of polymerization inhibitor, contamination with
incompatible materials.
Section XI: Toxicological Information
Acute Oral Acute Dermal Acute Irritation-Skin Irritation-Eye
Toxicity Toxicity Inhalation
Toxicity
ND/A ND/A ND/A ND/A ND/A
?Since this product contains a very low concentration of active components, the primary
toxicological information is derived from the oligomers. Further hazardous properties cannot be
excluded. The product should be handled with care when dealing with chemicals.
Sensitization Mutagenicity Sub-chronic Toxicity
ND/A ND/A ND/A
Section XII: Ecological Information
4
Acute Toxicity Acute Toxicity Acute Toxicity Bioconcentration Toxicity to
Fish to Invertebrate to Algae Sewage
Bacteria
ND/A ND/A ND/A ND/A ND/A
Chemical Fate Information
Biodegradability ND/A
Chemical Oxygen Demand ND/A
*To be best of our knowledge, the ecotoxocological and chemical fate properties have not been thoroughly
investigated.
*Do not allow to entering water supplies, waste water, or soil.
Section XIII: Disposable Concentrations
Dispose of diking materials and absorbent in compliance with State, Local, and Federal regulations. Residual vapors
may explode on ignition; do not cut, drill, or weld on or near the container. Mix with compatible chemical which is
less flammable and incinerate. Whatsoever, it cannot be save for recovery or recycling should be handle as
hazardous waste and sent to a RCRA approved waste facility. Processing, use or contamination of this product may
change the waste management options. State and local disposal regulations may differ from Federal disposal
regulations. Dispose of container and unused contents in accordance with Federal, State and local requirements. For
EU members, please refer to any relevant Community provision relate to waste. In their absence, it is useful to
remind the user that national or regional provision may be in force.
Section XIV: Transport Information
DOT (49 CFR 172)
Shipping Name: UN1993, Flammable liquids, n.o.s., (ethyl methacrylate, acrylate esters), 3, PG III
Identification Number: UN1993
Marine Pollutant: No
Special Provisions: None
Emergency Response
128
Guidebook (ERG) #:
IATA (DGR)
Proper Shipping Name: UN1993, Flammable liquids, n.o.s., (ethyl meacrylate, acrylate esters), 3, PG III
Class or Division: 3.2
UN or ID Number: UN1993
Packaging Instructions: None
Emergency Response
Guidance (ICAO) #:
IMO (IMDG):
Proper Shipping Name: UN1993, Flammable liquids, n.o.s., (ethyl meacrlate, acrylate esters), 3, PG III
Class of Division: 3
UN or ID Number: UN1993
Special Provision &
None
Storage/Segregation:
Emergency Schedule
(EmS)#:
Other Information:
43篊
Flash point >
5
Section XV: Regulatory Informatio
This product contains the following Hazardous Air Pollutant (
Clean Air act: HAP's):
HAP/ODS ?None
This product does not contains Ozone Depleting Substances (ODS's).
This product contains no chemicals listed under the U.S. Clean Water
Clean Water Act:
Act (CWA) This product contains no chemical that are a Priority or
Priority Pollutant List
Pollutant under Clean Water Act (CWA)
FDA: Food Packaging This product had not been cleared by FDA for use in food packaging
Status and/or other applications an indirect food additive.
This product is considered to be hazardous under the OSHA Hazard
Communication Standard. It's hazards are:
Occupational Safety and
?Immediate (acute) health hazard
Health Act
?Delayed (chronic) health hazard
?Reactive hazard
This product is not considered to be hazardous waste under RCRA
(40 CFR 261). This product is considered to be hazardous waste
RCRA under RCRA (40 CFR 261) RCRA Code:\
?Ethyl Methacrylate, CAS# 97-63-2, RCRA Code: U118
?Characteristic of Ignitability, RCRA Code: D001
SARA Title III: Section This product contains chemicals regulated under Sec. 302 as extreme
302 (TPQ) hazardous substances that carry TPQ.
This product contains chemicals regulated under Sec. 302 as
extremely
SARA Title III: Section
hazardous chemical for emergency release notification ("CERCLA"
302(RQ)
List).
?Ethyl Meacrylate, CAS#97-63-2, RQ (lbs): 1000.
This product is considered to be hazardous under OSHA Hazard
Communication Standard and is regulated under Section 311-312 (40 CFR
370). Is hazard are:
SARA Title III:
?Immediate (acute) health hazard
Section 311-312
?Delayed (chronic) health hazard
?Reactive hazard
this product contains the no chemicals subject to the reporting requirements
SARA Title III: Section
of Section 313 of Title III of the Superfund Amendments and
313
Reauthorization Act of 1986 and 40 CFR part 372.
State Regulations:
CA Right-to-Know law: NONE
NONE
CA No Significant Risk Rule:
MA Right-to-Know Law: This product contains the following hazardous chemicals on the
Massachusetts Substance List: Ethyl Methacrylate, CAS# 97-63-2
NJ Right-to-Know Law: This product contains the following hazardous components subject to
disclosure under New Jersey Right-to-Know legislation: Ethyl
Methacrylate. CAS# 97-63-2
PA Right-to-Know Law: This product contains the following hazardous components subject to
disclosure under Pennsylvania Right-to-Know legislation: Ethyl
6
Methacrylate, CAS# 97-63-2
FL Right-to-Know Law: This product contains the following hazardous components subject to
disclosure under Florida Right-to-Know legislation: Ethyl Methacrylate,
CAS# 97-63-2.
MN Right-to-Know Law: NONE
International Regulations:
CDSL: Canadian Inventory Ethyl Methacryliate, CAS# 97-63-2 is on the DSL List. WHMIS = B2, D2B
Tetraethyllene glycol dimethacrylate, CAS# 109-17-1 is not on the DSL list.
(on Canadian Transitional
WHMIS = n/da Hydroxycyl phenyl ketone, CAS# 947-19-3 is on the DSL
List)
List. D&C Violet #2, CAS#81-48-1 is not on the DSL List. WHMIS = n/da.
EINECS: European Inventory ?Hazard Symbol: Xi: Irritant, F: Flammable
*Risk Phrases: R20: Harmful inhalation, R43: May cause
sensitization by skin contact.
*Safety Phrases: S24/25: Avoid contact with skin and eyes,
S28A: After contact with skin, wash immediately, S37: Wear suitable
protective clothing and gloves, S45: In case of accident, or feel unwell,
seek medical advise immediately (show label where possible).
Section XVI: Other Information
Hazard Rating System
NFPA: Health 2/ Flammability 2/ Reactivity 1
HMIS: Health 2/ Flammability 2/ Reactivity 1
Revised: July 3rd, 2009
Revised Sections since Last Version Section 2 contents and format update throughout.
The information presented herein was obtained from sources considered to be liable. However,
this information is provided without any warranty, expressed or implied, regarding its
correctness or suitability for consumers intended to use and/or application. For this and other
reasons, we assume no responsibility and expressly disclaim liability for loss, damage or expense
arising out of any way connected with handling, storage, use or disposal of the product. This
MSDS was prepared expressly for this product. Use the materials only directed. If the product
is used as a component of other product, the information contained within the MSDS may not be
applicable. If one could have any concerns with or problems understanding this MSDS form,
please direct all questions to INFOTRAC, Chemical Emergency Resources System at (800) 535-
5053.
7
|