HURST CHEMICAL COMPANY
Date Prepared: November 1993
Revised: December 2008
MATERIAL SAFETY DATA SHEET
I. PRODUCT INFORMATION
Trade Name: Amberclean 455
Chemical names, common names: Mixture
Manufacturer's Name: Hurst Chemical Company.
Address: 16623 Valley View Ave., Cerritos, CA, 90703
For Product Information, call: (800) 723-2004
For Emergency, Call CHEMTREC, 24 Hour: (800) 424-9300
DOT Information: COMPOUND, CLEANER NOIBN
II. HAZARDOUS INGREDIENTS
ACGIH OSHA OSHA Oral Rat Weight
TLV PEL IDLH LD50 Percent
CAS Chemical
(ppm) (ppm) (ppm) (mg/kg) Range
106-65-0 Dimethyl succinate -- 100 -- >5 <5%
111-42-2 Diethanolamine 3* 3 0.6 uL/kg <1%
1119-40-0 Dimethyl glurarate 1.5 0.025 -- >5000 1-5%
128-37-0 N-Methyl-2-Pyrrolidone 1.1, A4 1000 1.1 890 1-5%
25322-68-3 Polyethylene Glycol -- 200 -- 28000 <1%
56-81-5 Glycerin 2.4 400 3.7,1.2 12600 <1%
5989-27-5 d-Limonene -- -- -- 4400 1-5%
627-93-0 Dimethyl adipate -- 50* -- -- 1-5%
9036-19-5 Tetramethylbutyl Polyethlylene Glycols -- -- -- 5.61 1-5%
96-48-0 Dihydro-2(3H)-Furanone -- -- -- 1540 <1%
* Skin
None of the components listed above are considered carcinogens in humans by
IARC, NTP, USEPA, or OSHA.
Remaining components are primarily fatty acid methyl esters (67784-80-9) and
Polyethylene glycol nonylphenyl ether (9016-45-9).
Date Printed: 4Dec08 Page 1 of 4
Amberclean 455 MSDS 455
Section IIA -This product contains the following chemicals listed in the subject
regulations:
CAS Chemical 302 304 CERCLA 355 313 RCRA CAA212 CAA602 CWA HAP Prop65
YES YES YES YES
111-42-2 Diethanolamine no no no no no no no
302 Section 302 of the Emergency Planning and Community Right-to-Know Act (EPCRA)
304 Section 304 of the Emergency Planning and Community Right-to-Know Act (EPCRA)
CERCLA Comprehensive Environmental Response, Compensation, and Liability Act ("SUPERFUND")
355 The List of Extremely Hazardous Substances Under SARA
313 Toxic Release Inventory (TRI) Reporting Under SARA
RCRA Resource Conservation and Recovery Act
CAA212 Clean Air Act Section 212
CAA602 Clean Air Act Section 602
CWA Clean Water Act
HAP Hazardous Air Pollutant
Prop65 California Proposition 65
All ingredients are listed under the Toxic Substance Control Act (TSCA).
III. PHYSICAL PROPERTIES
Vapor density (air= 1): Approx. 1
Specific Gravity: 0.93 gm/ml
Density: 7.75 lb/gallon
Solubility in water: Forms an emulsion
VOC Composite Partial Pressure, mm Hg at 20癈: 2
Evaporation rate (Bu Ac=1): Approx. 0.1
Boiling Range 癋: Approx. 300
Appearance and odor: Clear liquid, yellowish color, mild odor
Volatile Organic Content (VOC, ASTM Method D2369): 1.55 lbs/gal. (PPG)
IV. FIRE AND EXPLOSION
0 = Least 3 = High
HMIS Health Hazard = 0
1 = Slight 4= Extreme
HAZARD Flammability = 2
2 = Moderate
CLASS Reactivity = 0
Flash Point: >200癋
Flammable limits in air, volume%: not established
Flammable Class IIIB
Fire extinguishing materials:
Water Spray: Yes
Carbon Dioxide: Yes
Foam: Yes
Dry Chemical: Yes
Other: No
Special firefighting procedures: The product is not flammable.
Unusual fire and explosion hazards: None
Date Printed: 4Dec08 Page 2 of 4
Amberclean 455 MSDS 455
V. HEALTH HAZARD INFORMATION
SYMPTOMS OF OVEREXPOSURE FOR EACH POTENTIAL ROUTE OF
EXPOSURE
Inhaled: Not a normally a route of entry.
Contact with skin or eyes: This material may cause skin and eye irritation. Direct
contact may cause redness, tearing & burning of the eyes. Irritation is possible
on prolonged skin contact.
Absorbed through skin: No data is available on harmful effects resulting from skin
absorption.
Swallowed: Ingestion can cause nausea, vomiting and gastrointestinal irritation.
HEALTH EFFECTS OR RISKS FROM EXPOSURE
Acute:
Inhaled: Not a normal route or entry.
Contact with skin or eyes: This material may cause skin and eye irritation. Direct
contact may cause redness, tearing & burning of the eyes. Possible irritation on
prolonged skin contact.
Absorbed through skin: No data available of harmful effects through skin
absorption.
Swallowed: Ingestion can cause nausea, vomiting and gastrointestinal irritation.
Chronic: N/A.
FIRST AID: EMERGENCY PROCEDURES
Eye Contact: For direct contact, hold eyelids apart and flush the affected eye (s)
with clean water for 15 minutes, If irritation or redness develops, seek medical
attention.
Skin Contact: Remove contaminated clothing; cleanse affected area(s)
thoroughly by washing with mild soap & water. If irritation or redness develops,
seek medical attention.
Inhaled: N/A
Swallowed: Give two glasses of water. Induce vomiting. Consult a physician.
COMMENTS: This substance has not been identified as a carcinogen or probable
carcinogen by NTP, IARC, USEPA, or OSHA.
VI. REACTIVITY DATA
Stability: Stable under ordinary use & storage. 1 year at ambient temperature.
Avoid freezing & excessive temperature.
Incompatibility (materials to avoid): N/A
Date Printed: 4Dec08 Page 3 of 4
Amberclean 455 MSDS 455
Hazardous Decomposition products (including combustion products): Oxides of
carbon on incineration.
Hazardous polymerization: Will not occur.
VII. SPILL, LEAK, AND DISPOSAL PROCEDURES
For small spills, wipe up, use absorbent pads. Keep out of drains, sewers or
waterways. Use sand or other inert material to dam and contain spill.
If spill in excess of EPA Reportable quantity is made into the environment,
immediately notify the National Response Center (Phone NO: 800-424-8802).
Reportable Quantities (lbs) DOT/CERCLA:
Chemical RQ (lbs)
Diethanolamine 100
Preparing wastes for disposal: Dispose of product in accordance with local
ordinance. Dispose of empty containers by flushing thoroughly with water before
discarding.
VIII. SPECIAL HANDLING INFORMATION
Ventilation and engineering controls: Normal shop ventilation is adequate.
Respiratory Protection: Not normally needed.
Eye Protection: Not normally needed.
Gloves: Not normally needed.
Other clothing and equipment: Not normally needed.
OTHER HANDLING AND STORAGE REQUIREMENTS:
Keep containers tightly closed. Keep containers cool, dry and away from sources
of ignition. Use good personal hygiene practice.
Hurst Chemical Company furnishes Material Safety Data Sheets based upon
information from raw material suppliers. This information is provided in
compliance with Federal Regulation 29CFR 1910. HOWEVER, NO WARRANTY
OF MERCHANTABILITY, FITNESS FOR ANY PARTICULAR PURPOSE OR
ANY OTHER WARRANTY IS EXPRESSED OR IS TO BE IMPLIED
REGARDING THE ACCURACY OR COMPLETENESS OF THIS
INFORMATION, THE RESULTS TO BE OBTAINED FROM THE USE OF THIS
INFORMATION OR THE PRODUCT, THE SAFETY OF THIS PRODUCT, OR
THE HAZARDS RELATED TO ITS USE. This information and product are
furnished on the condition that the person receiving them shall make his own
determination as to the suitability of the product for his particular purpose and on
the condition that he assumes the risk of his use thereof.
Date Printed: 4Dec08 Page 4 of 4
|