ALLIED PRESSROOM CHEMISTRY
MATERIAL SAFETY DATA SHEET
SECTION 1 PRODUCT IDENTIFICATION AND USE
PRODUCT IDENTIFIER : ALLIED M.R.C. 88
0-minimal, 1-slight, 2-moderate, 3-serious, 4-severe
(Metering Roller Cleaner for lithographic presses) HEALTH HAZARD: 2
FIRE HAZARD: 3
MANUFACTURER'S NAME: ALLIED PRESSROOM CHEMISTRY.
REACTIVITY: 0
PROTECTIVE EQUIPMENT: C
STREET ADDRESS
2040 LEE STREET, HOLLYWOOD, FLORIDA, 33020, USA
OFFICE TELEPHONE: FAX: 24 HR. EMERGENCY TELEPHONE
800-327-8487 954-923-6462 800-424-9300 CHEMTREC
DO NOT BREATHE VAPORS. DO NOT GET IN EYES,
THIS IS AN INDUSTRIAL CHEMICAL PRODUCT. ALL INDUSTRIAL CHEMICAL
SKIN. DO NOT GET ON CLOTHING. DO NOT INGEST
PRODUCTS POSE AN INHERENT HEALTH RISK. BEFORE USE ALWAYS READ
COMPLETE LABEL AND MSDS FOR SAFE HANDLING PROCEDURES
SECTION 2 ?INGREDIENT INFORMATION
INGREDIENTS % CAS NUMBER HAZARD DATA
*These ingredients are subject to the reporting
requirements of SARA 313 and 40 CFR 372
Aliphatic petroleum distillates 60.0 8032-32-4 ACGIH (TLV) 100ppm
Isobutyl alcohol 40.0 78-83-1 ACGIH (TLV-TWA) 50ppm
ALL INGREDIENTS ARE LISTED IN THE US TOXIC SUBSTANCE CONTROL ACT (TSCA)
SECTION 3 - PHYSICAL DATA
PHYSICAL STATE ODOR AND APPEARANCE WATER SOLUBILITY PH SPECIFIC GRAVITY
LIQUID Clear colorless liquid, Negligible Not applicable 0.8
Hydrocarbon/alcohol odor
VAPOR PRESSURE VAPOR DENSITY EVAPORATION RATE V.O.C.'s
BOILING POINT (癋)
(MM Hg) (AIR=1) (Butyl acetate = 1) 100% by Mass
223-288
8.8 @ 20癈 >1 <1 6.67 lb per Gallon (800 g/l)
SECTION 4 - FIRE AND EXPLOSION DATA
FLAMMABILITY IF YES, UNDER
WHICH CONDITIONS? Excess heat, sparks and open flame.
n NO ?br>
YES
EXTINGUISHING MEDIA SPECIAL FIRE FIGHTING PROCEDURES:
CARBON DIOXIDE, DRY CHEMICAL, UNIVERSAL FOAM. Use self contained breathing apparatus.
UPPER FLAMMABLE LIMIT LOWER FLAMMABLE LIMIT
FLASHPOINT (癋) AND METHOD
(% BY VOLUME) : Unknown (% BY VOLUME): Unknown
40 F by TCC
HAZARDOUS COMBUSTION PRODUCTS
AUTOIGNITION TEMPERATURE (癈)
Oxides of carbon and hydrocarbons.
Not known
Unknown
EXPLOSION SENSITIVITY TO SENSITIVITY TO STATIC DISCHARGE
NOT KNOWN IMPACT - NO NO
DATA
SECTION 5 - REACTIVITY DATA
CHEMICAL STABILITY CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERISATION
YES n NO ? None
INCOMPATIBILTY WITH OTHER SUBSTANCES
Strong oxidizing agents, strong reducing agents, strong bases
HAZARDOUS DECOMPOSITION PRODUCTS: In contact with open flame or This product is not photochemically reactive
incandescent material will liberate carbon dioxide, carbon monoxide and
hydrocarbons
Page 1 of 2
ALLIED PRESSROOM CHEMISTRY
MATERIAL SAFETY DATA SHEET
PRODUCT IDENTIFIER ALLIED M.R.C. 88
SECTION 6 - TOXICOLOGICAL PROPERTIES
ROUTES OF ENTRY
SKIN CONTACT n SKIN ABSORPTION n EYE CONTACT n INHALATION n INGESTION n
ACUTE EXPOSURE TO PRODUCT: Inhalation - Inhalation can cause severe irritation of the respiratory tract, signs of central
nervous system depression, dizziness nausea and headache. Eye - Will cause severe irritation, burning, redness and tearing. Skin -
Can cause irritation, redness burning and drying. Ingestion causes irritation of the digestive tract. Aspiration into the lungs can lead
to pulmonary odema and chemical pneumonia which can prove fatal. Prolonged over-exposure can lead to narcosis, respiratory
failure , coma.
CHRONIC EXPOSURE TO PRODUCT: Prolonged skin contact may aggravate an existing dermatitis. Prolonged and repeated
exposure to the pure solvent contained in this product has been reported to cause permanent brain and central nervous system
damage.
CARCINOGENICITY: No ingredient has been identified as carcinogenic or potentially carcinogenic by IARC, NTP, OSHA
TARGET ORGAN EFFECTS: Eyes, skin irritation
EMERGENCY FIRST AID PROCEDURES:
EYES: Flush with running water for at least 15 minutes. Seek medical attention.
SKIN: wash affected area with soap and water. Remove contaminated clothing and launder before re-use.
INHALATION: Remove victim to fresh air. Administer oxygen and/or artificial respiration if breathing difficulties occur. Seek medical
attention.
INGESTION: Do not induce vomiting. Material is an aspiration hazard, may enter lungs and cause lung damage. Seek immediate
medical attention.
SECTION 7 - PREVENTATIVE MEASURES
GLOVES RESPIRATOR: Use NIOSH approved SCBA in EYE (SPECIFY)
Nitrile for incidental, non-immersion contact. emergency situations or confined areas. Splash proof goggles or face shield
CLOTHING : Boots, aprons , or chemical suits should be used when necessary to prevent skin contact.
ENGINEERING CONTROLS (SPECIFY, EG. VENTILATION, ENCLOSED PROCESS) : Use local exhaust or dilution ventilation as
appropriate to control exposure below permissible levels. Vapors are heavier than air and will collect in low areas
LEAK AND SPILL PROCEDURE: Extinguish all sources of ignition. Provide maximum ventilation. Dike area to contain spill. Take
precautions to prevent contamination of ground and surface waters. Recover spilled material using absorbent material such as
vermiculite and sweep into closed containers for disposal.
WASTE DISPOSAL: Contaminated vermiculite or porous surface must be disposed of in a permitted hazardous waste facility.
Recovered liquids may be reprocessed or incinerated in a permitted hazardous waste facility. In all cases material should be
disposed of in accordance with all applicable regulations.
HANDLING PROCEDURES AND EQUIPMENT: Keep container closed when not in use. Store only in closed, properly labeled
containers. Store as FLAMMABLE LIQUID. Store in a cool, dry, well ventilated area away from heat sparks and open flames. Treat
empty containers as containing hazardous residues.
ADDITIONAL INFORMATION
.
CALIFORNIA PROPOSITION 65: This regulation does not address de minimis levels. Therefore even trace amounts of chemicals on these lists
must be identified. Trace quantities refer low levels of materials whose exact concentrations may not always be determined because of their minuteness.
This product contains the following chemicals known by the state of California to cause cancer : benzene. This product contains
following chemicals known by the state of California to cause reproductive harm : benzene, toluene,
SHIPPING INFORMATION: Flammable liquids, NOS (petroleum distillates, isobutyl alcohol), 3, UN 1993, PG II
SECTION 9 - PREPARATION AND DATE OF MSDS
PREPARED BY (GROUP DEPARTMENT, ETC.) PHONE NUMBER DATE
ALLIED PRESSROOM CHEMISTRY TECHNICAL SERVICES DEPARTMENT 1-800-327-8487 Jan 2007
The above information is believed to be correct as of the date hereof and is based on data supplied by raw material suppliers, however, no warranty of merchantability, fitness
for use, or any other warranty is expressed or is to be implied regarding the accuracy of these data, the results to be obtained from the use of the material, or the hazards
connected with each use. Since the information contained herein may be applied under conditions beyond our control and with which we are unfamiliar, and since the data
made available subsequent to the date hereof may suggest modifications of the information, we do not assume responsibility for the results of its' use. This information is
furnished on the condition that the person receiving it shall make his own determination as to the suitability of the material for his particular purpose and on the condition that
he assume risk of his use thereof.
Page 2 of 2
|