Material Safety Data Sheet
LINSEED OIL TREATMENT -55 GAL DRUM MTO
Version 1.1 Print Date 07/04/2007
REVISION DATE: 08/27/2006
SECTION 1 - PRODUCT IDENTIFICATION / PREPARATION INFORMATION
Product Information
Trade name : LINSEED OIL TREATMENT -55 GAL DRUM MTO
Product code : 027 55
Supplier : Euclid Canada
2835 Grande-All茅e
St-Hubert, QC J4T 2R4
Telephone : 1-800-667-0920
Emergency Phone: : (613) 996-6666
Preparation Information
Prepared by: : Sewnauth Raghunandan
Date: : 08/27/2006
Telephone : (416) 421-3300
SECTION 2 - HAZARDS IDENTIFICATION
Emergency Overview
Amber. Liquid solution. May cause slight irritation to the respiratory system. May cause nausea, headaches,
and dizziness. May cause drowsiness, weakness, and fatigue. Leave area to breathe fresh air. Avoid further
overexposure. If symptoms persist, get medical attention.
Acute Potential Health Effects/ Routes of Entry
Inhalation May cause slight irritation to the respiratory system. May cause nausea, headaches, and
:
dizziness. May cause drowsiness, weakness, and fatigue.
Eyes Slightly irritating. Direct contact may cause temporary redness and discomfort.
:
Ingestion May cause irritation to the mouth, throat and stomach. May cause gastrointestinal
:
irritation, nausea, and vomiting.
Skin May cause moderate irritation.
:
Aggravated Medical Conditions
Pre-existing eye, skin, liver, kidney, and respiratory disorders may be aggravated by exposure.
Chronic Health Effects
Fillers are encapsulated and not expected to be released from product under normal conditions of use.
Prolonged or repeated exposure to mineral spirits (petroleum naphtha or stoddard solvent) may cause defatting,
drying, and irritation of the skin, dermatitis, central nervous system (CNS) effects, and adverse liver, kidney, and
lung effects.
SECTION 3 : HAZARDOUS INGREDIENTS
Chemical Name CAS-No. Weight % Range
Linseed oil 8001-26-1 40.0 - 70.0
1/5 027 55
Material Safety Data Sheet
LINSEED OIL TREATMENT -55 GAL DRUM MTO
Version 1.1 Print Date 07/04/2007
REVISION DATE: 08/27/2006
Stoddard solvent (Mineral Spirits) 8052-41-3 40.0 - 70.0
1,2,4-Trimethylbenzene 95-63-6 1.0 - 5.0
The ingredients listed above are hazardous as defined in the controlled products regulation. (CPR).
SECTION 4 - FIRST AID MEASURES
Get immediate medical attention for any significant overexposure.
Inhalation : Leave area to breathe fresh air. Avoid further overexposure. If symptoms persist, get
medical attention.
Eye contact : Flush with water for 15 minutes. If irritation persists, get medical attention.
Skin contact : Clean area of contact thoroughly using soap and water. If irritation, rash or other
disorders develop, get medical attention immediately.
Ingestion : Do not induce vomiting unless advised by a physician. Call nearest Poison Control
Center or Physician immediately.
SECTION 5: FIRE / EXPLOSION HAZARDS
Flash point : 116 掳 47 掳
F, C
Method : Tag Closed Cup
Lower explosion limit : 1.00 %(V) Solvent
Upper explosion limit : 6 %(V) Solvent
Autoignition temperature : Not available.
Extinguishing media : If water fog is ineffective, use carbon dioxide, dry chemical or foam.
Hazardous combustion : Smoke, fumes.Carbon monoxide and carbon dioxide can form.
products
Protective equipment for : Use accepted fire fighting techniques. Wear full firefighting protective
firefighters clothing, including self-contained breathing apparatus (SCBA).
Fire and explosion conditions : Product may ignite if heated in excess of its flash point.Materials soaked
in this product could undergo spontaneous combustion.Closed
container, may burst when exposed to extreme heat.Empty containers
may contain ignitable vapors.
SECTION 6 - SPILLS / LEAKS / ACCIDENTAL RELEASE MEASURES
Remove sources of ignition immediately. Stop flow of material if safe to do so. Contain spill and keep out of
water courses. Ventilate area.
SECTION 7 - HANDLING AND STORAGE
Prevent inhalation of vapor, ingestion, and contact with skin eyes and clothing. Keep container closed when
not in use. Precautions also apply to emptied containers. Do not smoke, weld, generate sparks, or use flame
near container. Do not use in confined or poorly ventilated areas. Personal protective equipment must be worn
during maintenance or repair of contaminated mixer, reactor, or other equipment. Store under dry warehouse
2/5 027 55
Material Safety Data Sheet
LINSEED OIL TREATMENT -55 GAL DRUM MTO
Version 1.1 Print Date 07/04/2007
REVISION DATE: 08/27/2006
conditions away from heat and all ignition sources. Rags and other materials containing this product may
oxidize and ignite spontaneously.
SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION
Personal protection equipment
Respiratory protection : Wear appropriate, properly fitted NIOSH/MSHA approved organic vapor or
supplied air respirator when airborne contaminant level(s) are expected to
exceed exposure limits indicated on the MSDS. Follow manufacturer's
directions for respirator use.
Hand protection : Use suitable impervious rubber or vinyl gloves and protective apparel to
reduce exposure.
Eye protection : Wear appropriate eye protection.Chemical splash goggles.
Protective measures : Use professional judgment in the selection, care, and use.
Engineering measures : Use general ventilation and/ or local exhaust to reduce the airborne
contaminant concentration below the exposure limit listed in the MSDSUse
only in well ventilated areas. Provide maximum ventilation in enclosed areas.
Exposure Limits
Chemical Name CAS Number Regulation Limit Form
Stoddard solvent (Mineral 8052-41-3 Ontario TWA: 525 mg/m3
Spirits) ACGIH TWA: 100 ppm
1,2,4-Trimethylbenzene 95-63-6 Ontario TWA: 123 mg/m3
ACGIH TWA: 25 ppm
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State : Liquid
Form : Liquid solution
Color : Amber
Odor : Solvent
pH : Not available.
Vapour pressure : Not available.
Vapor density : Heavier than air
Melting point/range : Not available.
Freezing point : Not available.
Boiling point/range : Not available.
Water solubility : Negligible
Evaporation Rate: : Not available.
Specific Gravity : 0.85
3/5 027 55
Material Safety Data Sheet
LINSEED OIL TREATMENT -55 GAL DRUM MTO
Version 1.1 Print Date 07/04/2007
REVISION DATE: 08/27/2006
% Volatile Weight : 45 %
SECTION 10 - REACTIVITY / STABILITY
Substances to avoid : Oxidizing agents, acids and bases.
Stability : Material is stable under normal storage, handling, and use.
Hazardous polymerization : Will not occur under normal conditions.
SECTION 11 - TOXICOLOGICAL INFORMATION
No Data Available
SECTION 12 - ECOLOGICAL INFORMATION
No Data Available
SECTION 13 - WASTE DISPOSAL CONSIDERATIONS
Disposal Method : Dispose according to all applicable regulations (hazardous household waste depot, or
as liquid industrial waste for industrial product).
SECTION 14 - TRANSPORTATION / SHIPPING DATA
TDG / DOT Shipping Description:
NOT REGULATED
SECTION 15 - REGULATORY INFORMATION
North American Inventories:
All components are listed or exempt from the TSCA inventory.
This product or its components are listed on, or exempt from the Canadian Domestic Substances List.
Canadian Regulations:
WHMIS Classification : B3, F
This is a "controlled product" under the Canadian Workplace Hazardous Materials Information System
(WHMIS).
This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations
(CPR) and the MSDS contains all of the information required by the CPR.
Other Regulations:
Regulatory VOC (less water and : 389 g/l
exempt solvent)
4/5 027 55
Material Safety Data Sheet
LINSEED OIL TREATMENT -55 GAL DRUM MTO
Version 1.1 Print Date 07/04/2007
REVISION DATE: 08/27/2006
SECTION 16 - OTHER INFORMATION
HMIS Rating :
Health 2 0 = Minimum
1 = Slight
Flammability 2
2 = Moderate
Reactivity 1
3 = Serious
PPE
4 = Severe
Further information:
For Industrial Use Only. Keep out of Reach of Children. The hazard information herein is offered solely for the
consideration of the user, subject to their own investigation of compliance with applicable regulations, including
the safe use of the product under every foreseeable condition.
Prepared by: Sewnauth Raghunandan
Legend
ACGIH - American Conference of Governmental Hygienists OSHA - Occupational Safety and Health Administration
DOT - Department of Transportation PEL - Permissible Exposure Limit
DSL - Domestic Substance List RCRA - Resource Conservation and Recovery Act
EPA - Environmental Protection Agency STEL - Short Term Exposure Limit
HMIS - Hazardous Materials Information System TLV - Threshold Limit Value
IARC - International Agency for Research on Cancer TSCA - Toxic Substances Control Act
MSHA - Mine Safety Health Administration TWA - Time Weighted Average
NDSL - Non-Domestic Substance List V - Volume
NIOSH - National Institute for Occupational Safety and Health VOC - Volatile Organic Compound
NTP - National Toxicology Program WHMIS - Workplace Hazardous Materials Information System
5/5 027 55
|