RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 1 of 7
Section 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME
RENOLITH WP
SYNONYMS
"Product Code: REN-6"
PRODUCT USE
Used according to manufacturer' s directions.
SUPPLIER
Company:Albright & Wilson (Australia) Ltd (ABN:
36 004 234 137)
Address:
22 Davis Rd
Wetherill Park
NSW, 2164
AUS
Telephone:+61 2 9609 1000
EmergencyTel: 1800 033 111
EmergencyTel: +800 73 4607 NZ
Fax: +61 2 9725 2219
HAZARD RATINGS
Flammability
Toxicity
Body Contact
Reactivity
Chronic
SCALE: Min/Nil=0 Low=1 Moderate=2 High=3 Extreme=4
Section 2 - HAZARDS IDENTIFICATION
STATEMENT OF HAZARDOUS NATURE
NON-HAZARDOUS SUBSTANCE. NON-DANGEROUS GOODS. According to the Criteria of NOHSC, and the ADG Code.
POISONS SCHEDULE
None
RISK
None under normal operating conditions.
SAFETY
Safety Codes Safety Phrases
S23 Do not breathe gas/fumes/vapour/spray.
S39 Wear eye/face protection.
S27 Take off immediately all contaminated clothing.
S26 In case of contact with eyes, rinse with plenty of water and
contact Doctor or Poisons Information Centre.
continued...
RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 2 of 7
Section 3 - COMPOSITION / INFORMATION ON INGREDIENTS
NAME CAS RN %
acrylic copolymer latex Not avail. <10
calcium chloride, hydrated 10035-04-8 <20
ingredients not contributing to the classification, includin >60
water 7732-18-5
Section 4 - FIRST AID MEASURES
SWALLOWED
路 If swallowed do NOT induce vomiting.
路 If vomiting occurs, lean patient forward or place on left side (head-down position, if possible) to maintain open airway and
prevent aspiration.
EYE
If this product comes in contact with the eyes:
路 Wash out immediately with fresh running water.
路 Ensure complete irrigation of the eye by keeping eyelids apart and away from eye and moving the eyelids by occasionally lifting
the upper and lower lids.
SKIN
If skin or hair contact occurs:
路 Flush skin and hair with running water (and soap if available).
路 Seek medical attention in event of irritation.
INHALED
路 If fumes or combustion products are inhaled remove from contaminated area.
路 Other measures are usually unnecessary.
NOTES TO PHYSICIAN
Treat symptomatically.
Section 5 - FIRE FIGHTING MEASURES
EXTINGUISHING MEDIA
路 There is no restriction on the type of extinguisher which may be used.
路 Use extinguishing media suitable for surrounding area.
FIRE FIGHTING
路 Alert Fire Brigade and tell them location and nature of hazard.
路 Wear breathing apparatus plus protective gloves for fire only.
路 Prevent, by any means available, spillage from entering drains or water courses.
路 Use fire fighting procedures suitable for surrounding area.
路 DO NOT approach containers suspected to be hot.
路 Cool fire exposed containers with water spray from a protected location.
路 If safe to do so, remove containers from path of fire.
路 Equipment should be thoroughly decontaminated after use.
FIRE/EXPLOSION HAZARD
路 Non combustible.
路 Not considered a significant fire risk, however containers may burn.
Decomposition may produce toxic fumes of: hydrogen chloride.
May emit poisonous fumes.
FIRE INCOMPATIBILITY
None known.
HAZCHEM: None
continued...
RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 3 of 7
Section 6 - ACCIDENTAL RELEASE MEASURES
EMERGENCY PROCEDURES
MINOR SPILLS
路 Clean up all spills immediately.
路 Avoid breathing vapours and contact with skin and eyes.
路 Control personal contact by using protective equipment.
路 Contain and absorb spill with sand, earth, inert material or vermiculite.
路 Wipe up.
路 Place in a suitable labelled container for waste disposal.
MAJOR SPILLS
Moderate hazard.
路 Clear area of personnel and move upwind.
路 Alert Fire Brigade and tell them location and nature of hazard.
路 Wear breathing apparatus plus protective gloves.
路 Prevent, by any means available, spillage from entering drains or water course.
路 Stop leak if safe to do so.
路 Contain spill with sand, earth or vermiculite.
路 Collect recoverable product into labelled containers for recycling.
路 Neutralise/decontaminate residue.
路 Collect solid residues and seal in labelled drums for disposal.
路 Wash area and prevent runoff into drains.
路 After clean up operations, decontaminate and launder all protective clothing and equipment before storing and re-using.
路 If contamination of drains or waterways occurs, advise emergency services.
Personal Protective Equipment advice is contained in Section 8 of the MSDS.
Section 7 - HANDLING AND STORAGE
PROCEDURE FOR HANDLING
路 Avoid all personal contact, including inhalation.
路 Wear protective clothing when risk of exposure occurs.
路 Use in a well-ventilated area.
路 Avoid contact with moisture.
路 Avoid contact with incompatible materials.
路 When handling, DO NOT eat, drink or smoke.
路 Keep containers securely sealed when not in use.
路 Avoid physical damage to containers.
路 Always wash hands with soap and water after handling.
路 Work clothes should be laundered separately. Launder contaminated clothing before re-use.
路 Use good occupational work practice.
路 Observe manufacturer's storing and handling recommendations.
路 Atmosphere should be regularly checked against established exposure standards to ensure safe working conditions are maintained.
SUITABLE CONTAINER
路 Polyethylene or polypropylene container.
路 Packing as recommended by manufacturer.
路 Check all containers are clearly labelled and free from leaks.
STORAGE INCOMPATIBILITY
None known.
STORAGE REQUIREMENTS
路 Store in original containers.
路 Keep containers securely sealed.
路 Store in a cool, dry, well-ventilated area.
路 Store away from incompatible materials and foodstuff containers.
路 Protect containers against physical damage and check regularly for leaks.
路 Observe manufacturer's storing and handling recommendations.
continued...
RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 4 of 7
Section 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION
EXPOSURE CONTROLS
Source Material TWA ppm TWA mg/m鲁 STEL ppm STEL mg/m鲁 Peak ppm Peak mg/m鲁 TWA F/CC
_________ _________ _____ _____ _____ _____ _____ _____ _____
Australia calcium 10
Exposure chloride,
Standards hydrated
(Inspirabl
e dust
(Not
specified)
)
The following materials had no OELs on our records
鈥? water: CAS:7732-18-5
PERSONAL PROTECTION
RESPIRATOR
Type A-P Filter of sufficient capacity
EYE
路 Safety glasses with side shields.
路 Chemical goggles.
路 Contact lenses may pose a special hazard; soft contact lenses may absorb and concentrate irritants. A written policy document,
describing the wearing of lens or restrictions on use, should be created for each workplace or task. This should include a review
of lens absorption and adsorption for the class of chemicals in use and an account of injury experience. Medical and first-aid
personnel should be trained in their removal and suitable equipment should be readily available. In the event of chemical
exposure, begin eye irrigation immediately and remove contact lens as soon as practicable. Lens should be removed at the first
signs of eye redness or irritation - lens should be removed in a clean environment only after workers have washed hands
thoroughly. [CDC NIOSH Current Intelligence Bulletin 59].
HANDS/FEET
Wear chemical protective gloves, eg. PVC.
Wear safety footwear or safety gumboots, eg. Rubber.
OTHER
路 Overalls.
路 P.V.C. apron.
路 Barrier cream.
路 Skin cleansing cream.
路 Eye wash unit.
ENGINEERING CONTROLS
General exhaust is adequate under normal operating conditions. Local exhaust ventilation may be required in specific
circumstances. If risk of overexposure exists, wear approved respirator. Correct fit is essential to obtain adequate protection.
Provide adequate ventilation in warehouse or closed storage areas.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE
Thin white liquid (emulsion)with a slight characteristicodour; mixes with water.
PHYSICAL PROPERTIES
Liquid.
Mixes with water.
Molecular Weight: Not Available Boiling Range (掳C): 100 approx
Melting Range (掳C): Not Available Specific Gravity (water=1): 1.08 approx
Solubility in water (g/L): Miscible pH (as supplied): 6- 9
pH (1% solution): Not Available Vapour Pressure (kPa): Not Available
Volatile Component (%vol): Not Available Evaporation Rate: Not Available
Relative Vapour Density (air=1): Not Available Flash Point (掳C): Not Applicable
Lower Explosive Limit (%): Not Applicable Upper Explosive Limit (%): Not Applicable
Autoignition Temp (掳C): Not Available Decomposition Temp (掳C): Not Available
State: Liquid Viscosity: Not Available
continued...
RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 5 of 7
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Section 10 - CHEMICAL STABILITY AND REACTIVITY INFORMATION
CONDITIONS CONTRIBUTING TO INSTABILITY
路 Presence of incompatible materials.
路 Product is considered stable.
路 Hazardous polymerisation will not occur.
Section 11 - TOXICOLOGICAL INFORMATION
POTENTIAL HEALTH EFFECTS
ACUTE HEALTH EFFECTS CHRONIC HEALTH EFFECTS
TOXICITY AND IRRITATION
Not available. Refer to individual constituents.
Section 12 - ECOLOGICAL INFORMATION
No data
Section 13 - DISPOSAL CONSIDERATIONS
路 Recycle wherever possible.
路 Consult manufacturer for recycling options or consult local or regional waste management authority for disposal if no suitable
treatment or disposal facility can be identified.
路 Dispose of by: Burial in a licenced land-fill or incineration in a licenced apparatus (after admixture with suitable
combustible material).
路 Decontaminate empty containers. Observe all label safeguards until containers are cleaned and destroyed.
路 Containers may still present a chemical hazard/ danger when empty.
路 Return to supplier for reuse/ recycling if possible.
Otherwise:
路 If container can not be cleaned sufficiently well to ensure that residuals do not remain or if the container cannot be used to
store the same product, then puncture containers, to prevent re-use, and bury at an authorised landfill.
路 Where possible retain label warnings and MSDS and observe all notices pertaining to the product.
Section 14 - TRANSPORTATION INFORMATION
HAZCHEM: None
NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS:UN
Section 15 - REGULATORY INFORMATION
POISONS SCHEDULE: None
REGULATIONS
acrylic copolymerlatex (CAS No:Not avail):
No regulationsapplicable
calcium chloride, hydrated(CAS: 10035-04-8)is found on the following regulatorylists;
Australia - Australia New Zealand Food StandardsCode - Food Additives - Schedule1 Permitted uses of food additives by food
type
Australia - Australia New Zealand Food StandardsCode - Food Additives - Schedule2 Miscellaneousadditives permitted in
continued...
RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 6 of 7
Section 15 - REGULATORY INFORMATION
accordancewith GMP in processedfoods specified in Schedule1
Australia - AustralianCapital Territory - EnvironmentProtectionRegulation:Ambient environmentalstandards(Domesticwater
supply - inorganic chemicals)
Australia - AustralianCapital Territory - EnvironmentProtectionRegulation:Pollutantsentering waterwaystaken to cause
environmentalharm (IRRIG)
Australia - AustralianCapital Territory EnvironmentProtectionRegulationPollutantsentering waterways- Agriculturaluses
(Stock)
Australia - AustralianCapital Territory EnvironmentProtectionRegulationPollutantsentering waterways- Domestic water
quality
Australia ExposureStandards
Australia High Volume Industrial Chemical List (HVICL)
Australia Inventoryof Chemical Substances(AICS)
CODEX General Standard for Food Additives (GSFA) - Additives Permitted for Use in Food in General, Unless Otherwise Specified,
in Accordancewith GMP
InternationalCouncil of Chemical Associations(ICCA) - High ProductionVolume List
OECD RepresentativeList of High ProductionVolume (HPV) Chemicals
WHO Guidelinesfor Drinking-waterQuality - Chemicalsfor which guideline values have not been established
calcium chloride, hydrated(CAS: 7774-34-7)is found on the following regulatorylists;
Australia - Australia New Zealand Food StandardsCode - Food Additives - Schedule1 Permitted uses of food additives by food
type
Australia - Australia New Zealand Food StandardsCode - Food Additives - Schedule2 Miscellaneousadditives permitted in
accordancewith GMP in processedfoods specified in Schedule1
Australia - AustralianCapital Territory - EnvironmentProtectionRegulation:Ambient environmentalstandards(Domesticwater
supply - inorganic chemicals)
Australia - AustralianCapital Territory - EnvironmentProtectionRegulation:Pollutantsentering waterwaystaken to cause
environmentalharm (IRRIG)
Australia - AustralianCapital Territory EnvironmentProtectionRegulationPollutantsentering waterways- Agriculturaluses
(Stock)
Australia - AustralianCapital Territory EnvironmentProtectionRegulationPollutantsentering waterways- Domestic water
quality
Australia ExposureStandards
Australia High Volume Industrial Chemical List (HVICL)
Australia Inventoryof Chemical Substances(AICS)
CODEX General Standard for Food Additives (GSFA) - Additives Permitted for Use in Food in General, Unless Otherwise Specified,
in Accordancewith GMP
InternationalCouncil of Chemical Associations(ICCA) - High ProductionVolume List
OECD RepresentativeList of High ProductionVolume (HPV) Chemicals
WHO Guidelinesfor Drinking-waterQuality - Chemicalsfor which guideline values have not been established
calcium chloride, hydrated(CAS: 22691-02-7)is found on the following regulatorylists;
Australia - Australia New Zealand Food StandardsCode - Food Additives - Schedule1 Permitted uses of food additives by food
type
Australia - Australia New Zealand Food StandardsCode - Food Additives - Schedule2 Miscellaneousadditives permitted in
accordancewith GMP in processedfoods specified in Schedule1
Australia - AustralianCapital Territory - EnvironmentProtectionRegulation:Ambient environmentalstandards(Domesticwater
supply - inorganic chemicals)
Australia - AustralianCapital Territory - EnvironmentProtectionRegulation:Pollutantsentering waterwaystaken to cause
environmentalharm (IRRIG)
Australia - AustralianCapital Territory EnvironmentProtectionRegulationPollutantsentering waterways- Agriculturaluses
(Stock)
Australia - AustralianCapital Territory EnvironmentProtectionRegulationPollutantsentering waterways- Domestic water
quality
Australia ExposureStandards
Australia High Volume Industrial Chemical List (HVICL)
Australia Inventoryof Chemical Substances(AICS)
CODEX General Standard for Food Additives (GSFA) - Additives Permitted for Use in Food in General, Unless Otherwise Specified,
in Accordancewith GMP
InternationalCouncil of Chemical Associations(ICCA) - High ProductionVolume List
OECD RepresentativeList of High ProductionVolume (HPV) Chemicals
WHO Guidelinesfor Drinking-waterQuality - Chemicalsfor which guideline values have not been established
water (CAS: 7732-18-5)is found on the following regulatorylists;
Australia Inventoryof Chemical Substances(AICS)
OECD RepresentativeList of High ProductionVolume (HPV) Chemicals
No data available for acrylic copolymerlatex as CAS: Not avail.
continued...
RENOLITH WP
Chemwatch Material Safety Data Sheet
Issue Date: 20-Apr-2007 CHEMWATCH 6606-07
CC317SCP Version No:1
CD 2007/1 Page 7 of 7
Section 16 - OTHER INFORMATION
INGREDIENTS WITH MULTIPLE CAS NUMBERS
Ingredient Name CAS
calcium chloride, hydrated 10035- 04- 8, 7774- 34- 7, 22691- 02- 7
This document is copyright. Apart from any fair dealing for the purposes of private study, research, review or criticism, as permitted under the Copyright Act,
no part may be reproduced by any process without written permission from CHEMWATCH. TEL (+61 3) 9572 4700.
Issue Date: 20-Apr-2007
Print Date: 24-Apr-2007
|