Material Safety Data Sheet U.S. Department of Labor
May be used to comply with Occupation Safety and Health Administration
OSHA's Hazard Communication Standard (Non-Mandatory Form)
29 CFR 1910.1200. Standard must be Form Approved
consulted for specific requirements OMB No. 1218-0072
Note: Blank spaces are not permitted. If any item is not applicable, or no
IDENTITY
information is available, the space must be marked to indicate that.
MADD (110105)
Section I
Manufactured For: Emergency Telephone Number
Beaver Research Company 1-800-255-3924 (Chem-Tel)
Address (Number, Street, City, State, and ZIP Code) Telephone Number For Information
3700 E. Kilgore Road, Portage, MI 49002 269-382-0133
NPCA RATINGS: Health: 2 Date Prepared
Flammability: 0 07/22/99
Reactivity: 0 Signature of Preparer (optional)
Maximum Personal Protection: B
Section II - Hazardous Ingredients/Identity Information
Hazardous Components (Specific Chemical TWA- STEL- %
Identity; Common Name(s)) CAS No. PEL TLV TLV (optional)
Water 7732-18-5 to 100
1mg/M3 1mg/M3 3mg/M3
Phosphoric Acid 7664-38-2 30to35
Glucoric Acid 526-95-4 0 to 5
Anionic Surfactant 27176-87-0 0 to 5
Nonionic Surfactant 127087-87-0 0 to 5
Nonionic Surfactant 61788-90-7 0 to 5
Dye N/A 0 to 5
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the Emergecy Planning and Community
Right-To-Know Act of 1986 and of 40 CFR 372:
Phosphoric Acid 7664-38-2 30.0
Section III - Physical/Chemical Characteristics
Boiling Point (癋) 218癋 initial Specific Gravity (H2O = 1) 1 .1 8
Vapor Pressure (mm Hg) <20mmHg@68癋 % V o l a ti l e 60+
Vapor Density (AIR = 1) >1 Evaporation Rate (Waater = 1) <1
S o l u b i l i ty i n W a te r pH Total VOC: 1%
100% 1.5 - 2.0
Appearance and Odor
Thin yellow liquid with no odor.
Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LE L UEL
N/A N/A N/A N/A
Extinguishing Media
N/A
Special Fire Fighting Procedures
N/A
Unusual Fire and Explosion Hazards
N/A
Section V - Reactivity Data
S ta b i l i ty Unstable Conditions to N/A
A v oi d
S ta b l e X
Incompatibility (Materials to Avoid)
Strong alkalies, oxidizers, reactive metals.
Hazardous Decomposition or Byproducts
Phosphorous oxide vapors in a fire.
Hazardous May Occur Conditions to N/A
A v oi d
Polymerization Will Not Occur X
MADD - Page 2 07/22/99
Section VI - Health Hazard Data
Route(s) of Entry: In h a l a ti o n ? S k i n? In g e s ti o n ?
Yes Yes Yes
Health Hazards (Acute and Chronic)
Skin: Severe skin irritant. Prolonged or repeated contact can cause chemical burns or deratitis.
Eyes: Severe eye irritant. Liquid and mists may burn or injure the eyes.
Inhalation: May be irritating to mucous membranes of the nose, throat and lungs.
Ingestion: May be irritating or corrosive to the mouth and throat. Can cause nausea and vomiting.
Carcinogenicity: NTP? IARC Monographs? OSHA Regulated?
N/A N/A N/A
Signs and Symptoms of Exposure
See above "Health Hazards".
Medical Conditions Generally Aggravated by Exposure
N/A
Emergency and First Aid Procedure
Skin: Remove contaminated clothing. Flush exposed area with large quantities of water. Seek medical attention if
irritation persists. Eyes: Flush eyes with large quantities of water, holding eyelids open. Seek medical attention if
irritation persists. Inhalation: Get to fresh air. Seek medical attention if symptoms persist. Ingestion: Do not induce
vomiting. Give large quantities of water or milk. Seek medical attention immediately.
Section VII - Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or Spilled
Mop up or otherwise absorb and hold for disposal.
Waste Disposal Method
Any method in accordance with applicable laws.
Precautions to be Taken in Handling and Storage
Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For
institutional and industrial use only.
Other Precautions
N/A
Section VIII - Control Measures
Respiratory Protection (Specify Type)
Use iwth adequate ventilation.
V e n ti l a ti o n Local Exhaust S pec i al
Yes N/A
Mechanical(General) Other
N/A N/A
Protective Gloves Eye Protection
Acid proof. Safety glasses.
Other Protective Clothing or Equipment
N/A
Work/Hygienic Practices
N/A