VIRGINIA ICE MACHINE CLEANER (revised September 2007)
Material Safety Data Sheet
SECTION I - COMPANY IDENTIFICATION
PRODUCT: VIRGINIA ICE MACHINE CLEANER CAT. NO.: H418, H418-16OZ
MANUFACTURED BY: TELEPHONE NUMBERS:
Sporlan Division-Parker Hannifin Corporation Office: 1-(636) 239-1111
206 Lange Drive Emergency Only: 1-(800) 424-9300
Washington, MO 63090
SECTION II - HAZARDOUS INGREDIENTS
OSHA Hazardous Components (29 CFR 1910.1200) EXPOSURE LIMITS: 8 HR. TWA
OSHA PEL ACGIH TLV
3 3
Phosphoric acid (CAS# 7664-38-2) 1 mg/m 1 mg/m
3 3
STEL 3 mg/m STEL 3 mg/m
SECTION III - HAZARDS IDENTIFICATIONS
EMERGENCY OVERVIEW: DANGER! Corrosive to all body tissues. Causes destruction of eye and skin tissue. Harmful if inhaled or swallowed.
POTENTIAL HEALTH EFFECTS:
INHALATION: Corrosive to respiratory passages. May cause coughing, wheezing, laryngitis, shortness of breath, headache, nausea.
EYE CONTACT: Immediate irritation and burning followed by destruction of eye tissue.
SKIN CONTACT: Immediate irritation and burning followed by destruction of skin tissue. Moderately toxic when absorbed through skin.
Aggravates pre-existing skin disorders.
INGESTION: Corrosive to gastrointestinal tract. May cause nausea, vomiting, loss of consciousness.
CHRONIC Effects: Kidney and liver damage possible.
NOTE:
CARCINOGENICITY: LISTED IN NTP? No IARC? No OSHA Regulated? No
SECTION IV - FIRST AID MEASURES
INHALATION: Remove victim to fresh air and, if needed, immediately begin artificial respiration. Give oxygen if breathing is labored. Get emergency
medical help. Contact a physician immediately.
EYE CONTACT: Flush eyes with water for 15 minutes. Get medical attention if symptoms develop and persist.
SKIN CONTACT: Flush with water or soap and water for 15 minutes or until all traces have been removed. Seek medical attention if symptoms develop
and persist.
INGESTION: Do not induce vomiting. Rinse mouth out with water. Get immediate medical attention.
SECTION V - FIRE FIGHTING MEASURES
FLASHPOINT (TEST METHOD): NA
FLAMMABLE LIMITS: LOWER: NA UPPER: NA
AUTOIGNITION TEMPERATURE: NE
GENERAL HAZARD:
FIRE FIGHTING INSTRUCTIONS: Approach fire from upwind side. Avoid breathing smoke, fumes, mist, or vapors on the downwind side. Firefighters
wear protective clothing and self contained breathing apparatus.
EXTINGUISHING MEDIA: Dry powder, carbon dioxide (CO2), water fog or spray.
HAZARDOUS COMBUSTION PRODUCTS: Smoke, CO, CO2, toxic fumes of POx
SECTION VI - ACCIDENTAL RELEASE MEASURES
LAND SPILL: Emergency response coordinator must have mandated training. Eliminate all ignition sources. SMALL SPILLS: Pick up with absorbent
materials and place in non-leaking containers; seal tightly for proper disposal or reuse. LARGE SPILLS: Evacuate the hazard area of
unprotected personnel. Wear appropriate respirator and protective clothing. Shut off source of leak if safe to do so. Dike and contain.
Remove with vacuum trucks or pump to storage/salvage vessels.
WATER SPILL: Notify proper authorities. Clean up spills/leaks immediately to prevent soil or water contamination.
SECTION VII - HANDLING AND STORAGE
HANDLING: Always add acid to water; never water to acid. Avoid contact with skin, eyes, and clothing. After handling this product, wash hands
before eating, drinking, or smoking. If contact occurs, remove contaminated clothing. If needed, take first aid action shown in section
IV. Launder contaminated clothing before reuse.
STORAGE: Store away from caustic / alkalines.
SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Local exhaust recommended.
PERSONAL PROTECTION: Use NIOSH approved respirator, chemical impervious gloves, chemical goggles or full face shield. Use boots, aprons, drench
showers, eye wash as needed for protection against spills and/or splashes.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
VIRGINIA ICE MACHINE CLEANER (revised September 2007)
VAPOR PRESSURE (Air=1): 0.3 mmHg VAPOR DENSITY (Air=1): ND
SPECIFIC GRAVITY: 1.6 EVAPORATION RATE (N-BUTYL ACETATE=1): ND
SOLUBILITY IN WATER: Soluble VOC (G/L): 0
pH: 1 - 2 FREEZING POINT: ND
BOILING POINT: >266 F
APPEARANCE & ODOR: Clear colorless liquid
SECTION X - STABILITY AND REACTIVITY
STABILITY: Stable.
CONDITIONS TO AVOID: High temperatures.
MATERIALS TO AVOID: Alkaline materials, caustics.
HAZARDOUS DECOMPOSITION PRODUCTS: From combustion: smoke, CO, CO2, POx
HAZARDOUS POLYMERIZATION: Will not occur.
SECTION XI - TOXICOLOGICAL INFORMATION
Phosphoric acid LDLo: 220 mg/kg (unr - man)
LD50: 1530 mg/kg (oral - rat)
LD50: 2740 mg/kg (skin - rat)
SECTION XII - ECOLOGICAL INFORMATION
Dangerous to aquatic life in high concentrations. Phosphoric acid 138 ppm / 24 hr. / mosquito fish / TLm / fresh water
SECTION XIII - DISPOSAL CONSIDERATIONS
Dispose as hazardous waste. Classification and documentation is required before disposal. Follow all local, state and federal regulations.
SECTION XIV - TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Consumer Commodity ORM-D
HAZARD CLASS: NA
IDENTIFICATION NUMBER: NA
DOT Emergency Guide #: 154
Reportable Quantity (RQ): Not applicable
International: UN 1805, Phosphoric acid, 8, PG III, LTD QTY
SECTION XV - REGULATORY INFORMATION
TSCA (Toxic Substance Control Act): Components of this product are listed on the TSCA Inventory.
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act): The reportable quantity is 5000 pounds (phosphoric acid).
Contact local authorities for other reporting requirements.
SARA TITLE III (Superfund Amendments and Reauthorization Act): Not listed.
CALIFORNIA PROPOSITION 65: Not listed.
SECTION XVI - OTHER INFORMATION
State Right-to-Know Programs: NJ, MA, PA
NFPA Ratings
Health: 2
Flammability: 0
Reactivity: 0
HMIS Protective Equipment: X See your supervisor
Prepared by: Sporlan Division-Parker Hannifin Corporation
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Parker Hannifin. The data on this
sheet related only to specific material designated herein. Parker Hannifin assumes no legal responsibility for use or reliance upon these data.
|