COASTWIDE LABORATORIES Hazard Rating HMIS NFPA
Formerly Paulsen & Roles Laboratories Health 2 2
10000 SW Commerce Circle Flammability 1 1
Wilsonville, OR 97070 Reactivity 0 0
Office PHONE: 503-416-5300 or FAX 503-416-5301 Special None None
MEDICAL 800-808-4691 DOT CHEMTREC: 800-424-9300
24-HR EMERGENCIES:
MATERIAL SAFETY DATA SHEET
Complies with ANSI Z400.1 Format
SECTION 1: PRODUCT IDENTIFICATION
METAL MIRACLETM MSDS CODE: CL3360.0702
Product:
GENERIC DESCRIPTION DATE ISSUED SUPERSEDES PREPARED BY
Acid Cleaner for Copper/Stainless Steel 7-1-02 New Regulatory Affairs Dept.
SECTION 2: COMPOSITION AND INFORMATION ON INGREDIENTS
Components % by Wt. CAS # Exposure Limit
3
Phosphoric Acid** 30-45 7664-38-2 1 mg/m (PEL & TLV/TWA)
Dowanol PM 10-25 107-98-2 100 ppm (PEL & TLV/TWA)
Balance is water and similar non-hazardous ingredients.
**This is the only component in this product that is currently reportable in either SARA Title III: Section 313, 40
CFR part 372 or the California Proposition 65 requirements.
NA = Not applicable NSR = No Special Requirements ND = Not Determined PEL = OSHA TLV-TWA = ACGIH
SECTION 3: HAZARD IDENTIFICATION
Primary Entry Routes: Skin, eyes, inhalation and ingestion. Signs & Symptoms of Exposure: Direct contact of product
with eyes or skin may cause irritation. May be harmful if swallowed. Effects of Overexposure: Can cause eye
damage. Avoid contact with eyes, skin and clothing. When handling concentrate, wear eye protection and
rubber gloves. Keep out of the reach of children.
SECTION 4: FIRST AID MEASURES
Emergency First Aid Procedures: Wash skin with plenty of water. If irritation persists, seek medical aid. If eye
contact occurs, flush eyes with water for 15-20 minutes, then get prompt medical aid. If product is swallowed,
drink large amounts of water or milk and seek medical aid. 24-HR MEDICAL PHONE: 800-808-4691
SECTION 5: FIRE FIGHTING MEASURES
Flash Point: 195F Flammable Limits: ND Extinguishing Media: Foam. CO2. Dry Chemical. Water Fog.
Special Fire Fighting Procedures: Normal fire fighting procedures may be used.
Unusual Fire and Explosion Hazards: Corrosive Material. Container may melt and leak in heat of fire. Liquid run-off
to sewers may create fire and explosion hazard.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Release or Spill: Before attempting clean-up, refer to Hazard Data above. Remove ignition sources. Contain
spill. Use mop, absorbent, or wet vacuum to collect material for proper disposal. Rinse area with water.
SECTION 7: HANDLING AND STORAGE
Store in a cool, dry place with adequate ventilation. Wash thoroughly after handling. Keep from freezing. Keep
out of reach of children. Do not use on aluminum. Keep away from ammonia and chlorine.
COASTWIDE Laboratories
Material Safety Data Sheet
TM
Page 2 璏ETAL MIRACLE CL3360.0702
SECTION 8: EXPOSURE CONTROLS AND PERSONAL PROTECTION
Respiratory Protection: No special requirements under normal use conditions. Maintain adequate ventilation.
Protective Gloves: For undiluted product and where contact is possible, wear rubber or other impervious gloves.
Eye Protection: For undiluted product and where contact is possible, wear chemical workers splash-proof
goggles and/or face shield.
Other Protective Measures: Use good personal hygiene practices. Launder contaminated clothing/equipment.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Appearance/Odor: Clear liquid Boiling Point: 212F Evap. Rate: NA pH: 1.5 pH (1%): 2.5
Vapor Density: ND Vapor Pressure: NA Specific Gravity: 1.1 Solubility in Water: Complete %Volatile: NA
SECTION 10: STABILITY AND REACTIVITY
Stability: Stable Conditions to Avoid: None known to COASTWIDE Incompatibility: Chlorine and Ammonia
Hazardous Decomposition Products: Thermal decomposition may yield hydrogen chloride and oxides of carbon.
Hazardous Polymerization: Will not occur. Conditions to Avoid: None known to COASTWIDE.
SECTION 11: TOXICOLOGICAL INFORMATION
Oral Toxicity: Non-toxic based upon current information available to COASTWIDE.
SECTION 12: ECOLOGICAL INFORMATION
Contains phosphates.
SECTION 13: DISPOSAL CONSIDERATIONS
Waste Disposal Information: For undiluted product, disposal is regulated under the Resource Conservation and
Recovery Act as a corrosive waste. Disposal of regulated quantities should be by neutralization at a permitted
facility in accordance with all Federal/State/Local regulations and ordinances regarding disposal of corrosive
waters. Waste from normal product use may be sewered to a public-owned treatment works in compliance with
applicable Federal, State and Local pretreatment requirements.
SECTION 14: TRANSPORT INFORMATION
DOT EMERGENCY 24-HR: (800) 424-9300
DOT Class: Corrosive Liquids, acidic, inorganic, n.o.s. (Phosphoric Acid) 8, UN3264, PGII (ERG #154).
SECTION 15: REGULATORY INFORMATION
SARA Title III Section 313 and 40 CFR Part 372 Notification: See Section 2.
No ingredients in this product are currently listed as carcinogens by NTP, IARC or OSHA. All components of
this product are listed or are excluded from listing on the U.S. Toxic Substances Control Act (TSCA) List.
SECTION 16: OTHER INFORMATION
Keep out of reach of children. Do not get in eyes, on skin or clothing. Harmful if swallowed. Avoid
contamination of food. Avoid inhalation of spray mist. Always follow label directions carefully when using this or
any chemical product. Keep MSDSs filed and organized in an area accessible to workers according to Hazard
Communication Standards. If information about this product is required, please contact COASTWIDE
Laboratories at 503-416-5300.
All information appearing herein is given in good faith. No warranty is made, expressed or implied including
merchantability or fitness for a particular purpose. All conditions of use are beyond the control of COASTWIDE
Laboratories. Therefore, users are responsible for verifying the data under their own operating conditions to
determine whether the product is suitable for their particular purposes. The data contained herein is
confidential and intended solely for the user's internal use.
|