#174
MATERIAL SAFETY DATA SHEET
2 Flammability = 0 Reactivity = 0
NFPA RATING: Health =
2 Flammability = 0 Reactivity = 0
HMIS RATING: Health =
SECTION I ?IDENTITY AND MANUFACTURER'S INFORMATION (502N-48E)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: SHOWER FOAM
Address: 302 North Fourth Street Date Prepared: March 5, 2001
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire,
exposure or accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II ?INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: OTHER LIMITS
Common Name(s) CAS# OSHA PEL ACGIH TLV RECOMMENDED %
1 mg/M3 1 mg/M3
Phosphoric acid * (1) 7664-38-2 N/A 13-17
Water 7732-18-5 none none N/A ---
Lauryl dimethyl amine oxide 1643-20-5 not est. not est. N/A ---
Coco amino propyl dimethyl betaine 61789-40-0 not est. not est. N/A ---
*This product contains the following chemicals subject to the reporting requirements of SARA Title III, Sec. 313, and
40 CFR Part 372: Phosphoric acid.
(1) Regulated by OSHA and the following states: FL, IL, LA, MA, NJ, NY, PA, RI
SECTION III ?PHYSICAL / CHEMICAL CHARACTERISTICS
corr. 208篎 Specific Gravity (H2O = 1): 25篊 = 1.08 & 39篊 = 1.07
Boiling Point:
Vapor Pressure (mm Hg.): 17.5 73
Percent Volatile by Volume (%):
0.6 Evaporation Rate (ethyl ether = 1): slower than 1
Vapor Density (AIR = 1):
appreciable Appearance and Odor: blue-green liquid; wintergreen odor
Solubility in Water:
1.52
pH (conc.)
SECTION IV ?FIRE AND EXPLOSION HAZARD DATA
Flash point: none (Tag Closed Cup) Flammable Limits: LEL = N/A UEL = N/A
Extinguishing Media: Water, foam or dry chemical; carbon dioxide
Special Fire Fighting Procedures: Hot phosphoric acid is corrosive. Wear protective clothing to avoid
contact with skin or eyes.
Unusual Fire and Explosion Hazards: May generate hydrogen gas in contact with some metals.
SECTION V ?PHYSICAL HAZARDS
Stability: Stable Conditions to Avoid: None known to Hillyard
Incompatibility (Materials to Avoid): Strong oxidizing agents, ammonia or bleaches; strong alkalis and
cyanides, and some metals.
Hazardous Decomposition Products or Byproducts: Hydrogen gas from contact with some metals
Hazardous Polymerization: Will not occur Conditions to Avoid: N/A
SECTION VI ?HEALTH HAZARD DATA
Inhalation? Yes Skin? Yes Ingestion? Yes
Routes of entry:
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. Concentrate was not a primary skin irritant when tested per Federal Hazardous Substance Act. Concentrate
was a primary eye irritant per the Federal Hazardous Substance Act; all test subjects showed moderate to severe
discharge with moistening of the lids and hairs in a considerable area around the eye. At a dose of 5 g./Kg. No
deaths were observed. Also was not acutely toxic following a 1-hour exposure at nominal concentration of
55.74 mg./L. (actual concentration of 15.21 mg./L. Spray mist of concentrate may irritate nose and throat. 2.
None known to Hillyard.
page 2 of - #174 Shower Foam
SECTION VI ?HEALTH HAZARD DATA continued
Chemical listed as Carcinogen or Potential Carcinogen:
National Toxicology Program = No No No
I.A.R.C. Monographs = OSHA =
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
Signs and Symptoms of Exposure: Concentrate can cause severe eye irritation. Harmful if swallowed. Concentrate
burns mouth and lips after ingestion; sour taste of acid, severe gastrointestinal irritation.
Medical Conditions Generally Aggravated by Exposure: N/A
Emergency and First Aid Procedures: If swallowed, immediately give large amounts of water and call a physician,
hospital emergency room or poison control center. If excess inhaled, remove to fresh air. In case of contact,
immediately flush eyes or skin with plenty of water for 15 minutes; remove contact lenses and flush eyes again with
water. For eyes, CALL A PHYSICIAN. If skin irritation persists, get medical attention. Remove and wash all
contaminated clothing before reuse.
SECTION VII ?PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Small spills: Pick up with noncombustible absorbent.
Large spills: Dike far ahead of liquid spill. Avoid contact with skin and eyes. Rinse affected area thoroughly with
water.
Waste Disposal Method: Disposal of concentrated product is regulated under RCRA as corrosive waste (pH less than
2). Disposal of regulated quantities should be neutralized at a permitted facility in accordance with federal, state and
local regulations. Waste from normal product use may be sewered to a public-owned treatment works in compliance
with pretreatment requirements.
Precautions To Be Taken In Handling And Storing: Keep container closed when not in sue. Avoid excessive
temperature; i.e., welding, flame cutting and brazing.
Other Precautions: Contact lenses should not be worn when working with this material.
SECTION VIII -- CONTROL MEASURES
Respiratory Protection (Specify Type): Self-contained breathing apparatus in areas where high mist vapor
concentration cannot be controlled by ventilation.
Ventilation:
If required to maintain TLV Mechanical (General) = Normal ventilation sufficient
Local Exhaust =
Special = N/A Other = N/A
Acid-resistant rubber
Protective Gloves:
Other Protective Clothing or Equipment: Protective clothing or rubber apron where contact with conc. is a concern.
Work / Hygienic Practices: Corrosive - do not get in eyes, on skin or clothing. Avoid prolonged breathing of vapors.
SECTION IX - TRANSPORTATION INFORMATION
Applicable regulations: DOT = No; IMCO = No; IATA = No
Proper shipping name: Cleaning compound
UN No.: not applicable Limited Qty.: not applicable Hazard Class: not applicable
Labels required: not required DOT Exception: not applicable
EPA Hazardous waste/number code: not listed
Hazardous waste characteristics:
Ignitability = not applicable; Corrosivity = yes; Reactivity = not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR
INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR
1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein
is presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS
PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL
REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|