HAZARD RATING
SUPPLIER
ELCO LABORATORIES, INC.
0
FIRE
4 = EXTREME
3 = HIGH
2 = MODERATE
1
2545 Palmer Avenue, University Park, Illinois 60466 TOXICITY
ADDRESS 1 = SLIGHT
0 = INSIGNIFICANT
TELEPHONE Medical Emergencies Poisindex Information
System
0
REACTIVITY
24 Hour Transportation Emergency
Response: 1 (800) 255-3924
Transportation Information and
0
SPECIAL
Product Information: 1 (708) 534-3000
MATERIAL SAFETY DATA SHEET
TRADE NAME FORMULA I.D.
COOKTOP CLEANING CREME #124-107A
(On Label NUMBER
PRODUCT CHEMICAL CHEMICAL NAME
Semi-liquid Ceramic
TYPE FORMULA Suspension OR SYNONYM N/A
Cleaner
The information contained herein is, to the best of our knowledge and belief, accurate. However, since the conditions of handling and
use are beyond our control, we make no guarantee of results, and assume no liability for damages incurred by use of this material.
It is the responsibility of the user to comply with all applicable federal, state and local laws and regulations.
SECTION I - COMPOSITION
COMPONENT CAS REG NO. APPROX. % WT. OSHA TLV ACGIH TLV
Isopropyl Alcohol 000067-63-0 4.0 400 ppm 400 ppm
#0.1 0.1mg/m3 0.1mg/m3
Silica (Quartz) 14808-60-7
1.0 mg/m3 1.0 mg/m3
Phosphoric Acid 7664-38-2 <2.0
SECTION II - PHYSICAL PROPERTIES
APPEARANCE pH VISCOSITY
Off-white to light tan paste, apple scented 2.6 - 3.6 3650-6650
- ODOR (Cps.)
FREEZING BOILING VAPOR PRESSURE VAPOR DENSITY
32 210 Unknown >
B B
POINT ( F) POINT ( F) (mm Hg) (AIR = 1)
SOLUBILITY VOLATILE SPECIFIC GRAVITY EVAP. RATE
Partially
IN WATER (% WT.) 60.0 - 64.0 (g/ml) 1.1686 - 1.1986 (Butyl Acetate =1) <
Soluble
SECTION III - FIRE AND EXPLOSION HAZARD
FLASH POINT (癋) AUTO IGNITION (癋) LOWER EXPLOSION LIMIT (%) UPPER EXPLOSION LIMIT (%)
Not Flammable N/A N/A N/A
EXTINGUISHING MEDIUM
9 FOAM 9 ALCOHOL 9 DRY CHEM. 9 WATER : OTHER
FOAM
SPECIAL FIRE FIGHTING PROCEDURES
This product is not flammable.
UNUSUAL FIRE AND EXPLOSION HAZARDS
N/A
SECTION IV - HEALTH HAZARD
THRESHOLD LIMIT VALUES
9 ACGIH 9 OSHA : NONE ESTABLISHED
PRIMARY ROUTES OF EXPOSURE
: EYE 9 SKIN 9 ORAL 9INHALATION
CARCINOGENS OR SUSPECTED
9 NIP 9 IARC 9 OSHA : NONE
CARCINOGENIC INGREDIENTS
EFFECTS OF OVEREXPOSURE
None known other than eye irritant.
M:\ALL-FORMULAS\ACTIVE\017 (124-107A) Cooktop Nov. 05\124-107A(17) MSDS.wpd Page 1.
SECTION IV - HEALTH HAZARD CONTINUED
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: If in contact with eyes, flush with water for 15 minutes. Get medical attention.
IF ON SKIN: Non-irritant when tested on normal skin of laboratory animals.
IF Do not take internally. If swallowed accidentally, get medical attention.
SWALLOWED:
SECTION V - REACTIVITY
STABILITY CONDITIONS TO AVOID
: STABLE 9 UNSTABLE Avoid contact with soft metals.
HAZARDOUS DECOMPOSITION PRODUCTS
Pyrolytic decomposition may result in the formation of CO2 and other unidentified compounds.
HAZARDOUS POLYMERIZATION CONDITIONS TO AVOID
: WILL NOT
9 MAY OCCUR N/A
OCCUR
INCOMPATIBILITY MATERIALS TO AVOID
9 WATER : OTHER Alkaline chemicals and soft metals.
SECTION VI - SPILL OR LEAK PROCEDURE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
For small spills: Flush with water.
For large spills: Identify and shut off the source. Recover free product, add sand, earth, or other absorbing materials
to spill area. Remove absorbed product and wash area with water. Minimize skin contact.
WASTE DISPOSAL METHODS
If intended to be disposed as is, deposit in landfill in accordance with Federal, State, and Local regulations.
SECTION VII - SPECIAL PROTECTION
VENTILATION TYPE
General mechanical ventilation suffice to keep the concentration of vapors low.
RESPIRATORY PROTECTION
Respiratory protection is not required for normal use of this product.
PROTECTIVE GLOVES EYE PROTECTION
For sensitive skin, use rubber gloves. If eye contact is reasonably expected to occur, use splash
goggles.
OTHER PROTECTIVE EQUIPMENT
None
SECTION VIII - STORAGE AND HANDLING
The container might rupture if this product is stored in temperature below freezing.
SECTION IX - SHIPPING
PROPER SHIPPING NAME:
CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S. (Phosphoric Acid)
IMO HAZARD CLASS:
8
IMO I.D. No.:
UN3264, PGIII
LABEL REQUIREMENTS:
UNDETERMINED
SECTION X - MISCELLANEOUS
None
ABBREVIATIONS: N/A : NOT APPLICABLE UNK : UNKNOWN
N/D : NOT DETERMINED < : LESS THAN
N/E : NOT ESTABLISHED > : GREATER THAN
PREPARED BY DATE SUPERSEDES
Bhupen Trivedi November 19, 2005 December 3, 2004
M:\ALL-FORMULAS\ACTIVE\017 (124-107A) Cooktop Nov. 05\124-107A(17) MSDS.wpd Page 2.
|