Webril Pre-Moistened Hand Cleaning Wipes
Issue Date: 07/06/07
Material Safety Data Sheet
Section 1 - Chemical Product and Company Identification
Product: Webril Pre-Moistened Hand Cleaning Wipes
Chemical Family: Polyester / Rayon Fabric Impregneated with a Hand Cleaning
Solution
Manufacturer Information: Fiberweb, Inc
70 Old Hickory Blvd.
Old Hickory, TN 37138
Company Contact: David Midget
Telephone Number: 1-800-284-2780 (8am-5pm M-F Central Time)
Emergency Phone Contact: Chemtrec (24 Hours)
Emergency Phone Number: 1-800-424-9300
Section 2 ?Hazards Identification
Emergency Overview
None of the components in this material are considered hazardous.
Route of Exposure-Skin
Possible mechanical irritation.
Route of Exposure-Eye
Not expected to be a problem being that this product is an inert solid. However, the solvent
component may be an irritant.
Route of Exposure -Ingestion
Not Applicable
Route of Exposure-Inhalation
Not expected to be a problem being that this product is an inert solid.
HMIS Ratings
Health: 0 Fire: 1 Reactivity: 0 Personal Protection: A
Hazard Scale: 0=Minimal 1=Slight 2=Moderate 3=Serious 4=Severe *=Chronic Hazard
Section 3 - Composition
Wipe Material
CAS # Component Percent
25038-59-9 Polyester 25%-75%
61788-77-0 Rayon 25%-75%
Solvent Component
CAS # Component Percent
Mixture Hand Cleaning Solution* 100%
*Aqua, PEG-40 Hydrogenated Castor Oil, Dimethyl Glutarate, Laureth-11, Limonene, Dimethyl
Succinate, Phenoxyethanol, Parfum, Dimethyl Adipate, Lauramine oxide, 2-phenoxyethanol (CAS #
122-99-6): <1%, D-Limonene (CAS # 5989-27-5): <0.1%
Page 1 of 6
Webril Pre-Moistened Hand Cleaning Wipes
Issue Date: 07/06/07
Component Information: This product is not hazardous according to the criteria specified in 29CFR
1910.1200 (Hazard Communication Standard). This product is considered an article and does not
require an MSDS.
Section 4 - First Aid Measures
First Aid-Skin
Wash affected area with soap and water.
First Aid-Eye
Rinse eyes with water for at least 15 minutes. If irritation persists, contact a physician.
First Aid-Ingestion
Not Applicable
First Aid-Inhalation
Not Applicable
First Aid-Notes to Physician
No health conditions aggravated by exposure are identified. Contact the poison control center if any
problem occurs.
Section 5 - Fire Fighting Measures
*Flash Point: >59oC Method Used: Not Applicable
Auto Ignition: Not Applicable Flammability Classification: Not Applicable
Lower Explosive Limit (%): Not Applicable Upper Explosive Limit (%): Not Applicable
General Fire Hazards
Solid material may burn upon extended exposure to open flames.
Hazardous Combustion Products
Upon decomposition this product may emit carbon dioxide, carbon monoxide and/or low molecular
weight hydrocarbons.
Extinguishing Media
Water spray, foam, carbon dioxide, or dry chemical.
Fire Fighting Equipment/Instructions
As in any fire, wear a self-contained breathing apparatus and full protective gear.
NFPA Ratings
Health: 0 Fire: 1 Reactivity: 0
Hazard Scale: 0=Minimal 1=Slight 2=Moderate 3=Serious 4=Severe
*Hand Cleaning Solution
Section 6 - Accidental Release Measures
Containment Procedures
Sweep waste fabric into a pile.
Clean -Up Procedures
Sweep waste fabric into a waste container and recycle, incinerate or landfill in conformity with local
disposal regulations.
Evacuation Procedures
Not Applicable
Special Procedures
None
Page 2 of 6
Webril Pre-Moistened Hand Cleaning Wipes
Issue Date: 07/06/07
Section 7 - Handling and Storage
Handling Procedures
Avoid exposure to heat, sparks or open flames.
Storage Procedures
Store material in cool (below 140oF) warehouse that is equipped with a sprinkler system.
Ensure product is not stacked too high.
Store product off the floor to prevent water damage.
Section 8 - Exposure Controls/Personal Protection
Component Exposure Limits
Product is not considered to present an inhalation health hazard under reasonably anticipated
conditions of use.
Engineering Controls
Normal room ventilation is usually adequate.
Personal Protective Equipment
Personal Protective Equipment-Eyes/Face
None usually required
Personal Protective Equipment-Skin
None usually required
Personal Protective Equipment-Respiratory
None usually required
Personal Protective Equipment-General
Follow individual plant safety rules.
Section 9 - Physical & Chemical Properties
Appearance: Odor:
White Fabric Impregnated with Mandarin Scented
Hand Cleaning Solution Solution
Physical State: *pH:
Solid 5.5 ?6.5
Vapor Pressure: Vapor Density:
NIL Not Applicable
95.2 oC >240oC
*Boiling Point: Melting Point of
Polyester:
*Solubility (H2O): Soluble in water Specific Gravity: 1.3-1.6
Packing Density: Percent Volatiles:
Not Applicable NIL
>150oC
Decomposition of Evaporation Rate: Not Applicable
Rayon:
*Hand Cleaning Solution
Section 10 - Chemical Stability & Reactivity Information
Chemical Stability
Stable under ordinary conditions of use and storage.
Page 3 of 6
Webril Pre-Moistened Hand Cleaning Wipes
Issue Date: 07/06/07
Conditions to Avoid
Combustible when exposed to open flames. Avoid chlorine, fluorine, and other strong oxidizers.
Incompatibility
Incompatible with strong acids, bases, and oxidizing materials.
Hazardous Decomposition
Carbon monoxide, carbon dioxide and/or low molecular weight hydrocarbon may be emitted upon
decomposition.
Hazardous Polymerization
Will not occur.
Section 11 - Toxicological Information
Acute and Chronic Toxicity
General Product Information
No components of this product are known to be hazardous according to the criteria specified in
29CFR1910.1200 (Hazard Communication Standard).
Carcinogenicity
General Product Information
Product is considered non-hazardous.
Epidemiology
No information available.
Neurotoxicity
No information available.
Mutagenicity
No information available.
Teratogenicity
No information available.
Other Toxicological Information
Specific toxicity testing has not been performed on this product. Hazard evaluation is based on
information from similar products, raw material data, and technical literature.
Section 12 - Ecological Information
Ecotoxicity
General product Information
Fibers are not associated with any ecological problems.
Environmental Fate
Fibers are not biodegradable.
Section 13 - Disposal Considerations
US EPA Waste Number & Descriptions
General Product Information
None identified.
Page 4 of 6
Webril Pre-Moistened Hand Cleaning Wipes
Issue Date: 07/06/07
Component Waste Numbers
No EPA Waste Numbers are applicable for this product's components
Disposal Instructions
Dispose of container and unused contents in accordance with federal, state and local requirements.
Processing, use or contamination of this product may change the waste management options.
Section 14 - Transportation Information
Transportation Regulations
Product is not regulated for transportation.
Section 15 - Regulatory Information
US Federal Regulations
General Product Information
No additional information.
Component Analysis-Federal
Component CAS # SARA 302 SARA 313 CERCLA
(40CFR355 Appx A) (40CFR372.65) (40CFR302.4)
Polyester 25038-59-9 No No No
Rayon 61788-77-0 No No No
Hand Cleaning Solution* Mixture No No No
*Based on 2-phenoxyethanol (CAS # 122-99-6) and D-Limonene (CAS # 5989-27-5)
State Regulations
General Product Information
Other state regulations may apply. Check individual state requirements.
Component Analysis-State
The following components appear on one or more of the following state hazardous substances list:
Component CAS CA FL MA MN NJ PA
Polyester 25038-59-9 No No No No No No
Rayon 61788-77-0 No No No No No No
Hand Cleaning Solution* Mixture No No UK No No No
*Based on 2-phenoxyethanol (CAS # 122-99-6) and D-Limonene (CAS # 5989-27-5)
Component Analysis-WHMIS IDL
No components are knowingly identified under the Canadian Hazardous Products Act Ingredient
Disclosure List.
Additional Regulatory Information
Component Analysis-Inventory
Component CAS TSCA DSL/NDSL EINECS
Polyester 25038-59-9 Yes Yes Yes
Rayon 61788-77-0 Yes Yes Yes
Hand Cleaning Solution* Mixture Yes Yes Yes
*Based on 2-phenoxyethanol (CAS # 122-99-6) and D-Limonene (CAS # 5989-27-5)
Page 5 of 6
Webril Pre-Moistened Hand Cleaning Wipes
Issue Date: 07/06/07
Section 16 - Other Information
Other Information
Material for this MSDS was taken from MSDS's for raw materials
MSDS History
Updated formatting 7/06/07
DISCLAIMER OF EXPRESSED AND IMPLIED WARRANTIES
The information in this document is believed to be correct as of the date issued.
HOWEVER, NO WARRANTY OF MERCHANTABILITY, FITNESS FOR ANY USE, OR ANY
OTHER WARRANTY IS EXPERSSED OR IS TO BE IMPLIED REGARDING THE ACCURACY
OR COMPLETENESS OF THIS INFORMATION, THE RESULTS TO BE OBTAINED FROM
USE OF THIS INFORMATION OR THE PRODUCT, THE SAFETY OF THIS PRODUCT, OR
THE HAZARDS RELATED TO ITS USE.
This information and the product are furnished on the condition that the person receiving them shall
make his or her own determination as to the suitability of the product for his particular purpose and on
the condition that they assume the risk of his use thereof.
THIS PRODUCT IS CONSIDERED AN ARTICLE AND DOES NOT REQUIRE A MATERIAL
SAFETY DATA SHEET (MSDS).
APPROVED BY: MICHAEL THOMASON
Page 6 of 6
|