#149
MATERIAL SAFETY DATA SHEET
2 Flammability = 0 Reactivity = 0
NFPA RATING: Health =
2 Flammability = 0 Reactivity = 0
HMIS RATING: Health =
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (1124A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: ASSAULT
Address: 302 North Fourth Street Date Prepared: January 31, 2007
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire, exposure or
accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: OTHER LIMITS
Common Name(s) CAS# OSHA PEL ACGIH TLV RECOMMENDED %
Ethanolamine (1) 141-43-5 3ppm 3ppm N/A 3-5
2 mg/M3
Sodium metasilicate (2) 6834-92-0 not established not established 1-3
Water 7732-18-5 none none N/A ---
Sodium xylene sulfonate 1300-72-7 not established not established N/A ---
Ethylene glycol monophenyl ether 122-99-6 not established not established N/A ---
1-Butoxy-2-propanol 5131-66-8 not established not established N/A ---
(1) Regulated by OSHA and the following states: CT, FL, IL, LA, MA, NJ, PA, RI.
(2) Exposure may be elevated as ceiling for Sodium hydroxide per OSHA: PEL = 2 mg/M3 or TLV = 2 mg/M3.
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
Specific Gravity (H2O = 1): 25篊 = 1.02 & 39篊 = 1.02
Boiling Point: 208癋
Vapor Pressure (mm Hg.): 17.0 95%
Percent Volatile by Volume (%):
1.0 Evaporation Rate (ethyl ether = 1): slower than 1
Vapor Density (AIR = 1):
complete Clear, light amber liquid; mild solvent odor
Solubility in Water : Appearance and Odor:
pH (concentrate) = 12-13
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
N/A UEL = N/A
Flash point: Flammable Limits: LEL =
None to 200癋
Extinguishing Media: Water, carbon dioxide, dry chemical or foam
Special Fire Fighting Procedures: Normal fire fighting procedures may be used. Cool and cautiously approach or handle
fire-exposed containers.
Unusual Fire and Explosion Hazards: N/A
SECTION V -- PHYSICAL HAZARDS
Stable N/A
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Oxidizing materials and strong acids
Hazardous Decomposition Products or Byproducts: When exposed to fire, produces normal products of combustion.
Will not occur None known to Hillyard
Hazardous Polymerization: Conditions to Avoid:
SECTION VI -- HEALTH HAZARD DATA
Yes Skin? Yes Ingestion? Yes
Routes of entry: Inhalation?
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. Direct contact with concentrate in eyes can cause severe irritation and damage.
2. Prolonged and repeated exposure to the skin may produce irritation.
Chemical listed as Carcinogen or Potential Carcinogen:
National Toxicology Program = No I.A.R.C. Monographs = No OSHA = No
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
page 2 of #149 Assault
SECTION VI -- HEALTH HAZARD DATA cont.
Signs and Symptoms of Exposure: Concentrated product may produce eye burns or moderate skin irritation. Ingestion may produce
burns of the mouth, throat, esophagus and stomach.
Medical Conditions Generally Aggravated by Exposure: Skin problems such as industrial dermatitis
Emergency and First Aid Procedures: In case of contact immediately flush eyes or skin with plenty of water for at least 15 minutes
while removing contaminated clothing and shoes. Get medical attention. Wash clothing before reuse. If swallowed, do not induce
vomiting; immediately give large amounts of water and CALL A PHYSICIAN, hospital emergency room or poison control center.
Inhalation - Remove victim to fresh air; if respiratory tract remains irritated, CALL A PHYSICIAN.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Absorb with floor dry or similar inert material. Sweep or scrape up
and put in appropriate container. Rinse spill area thoroughly with water. Use appropriate protective equipment.
Waste Disposal Method: Disposal of concentrate regulated by Federal Resource Conservation and Recovery Act as a corrosive
waste (40 CFR 261.22). Disposal or regulated quantities should be neutralized at a permitted facility in accordance with
federal/state/local regulations (corrosive waste-pH concentrate = 12-13). Waste from normal product use may be sewered to public-
owned treatment works in compliance with applicable federal, state and local pretreatment requirements.
Precautions To Be Taken In Handling And Storing: Keep container closed when not in use. Container disposal: Triple rinse (or
equivalent), then offer clean, dry container for recycling or reconditioning.
Other Precautions: Do not use with fog mist or fine droplet sprayer without respiratory protection. This product contains no
reportable quantities of toxic chemicals subject to reporting requirements of Section 313 of SARA Title III Emergency Planning and
Community Right to Know Act of 1986 and 40 CFR Part 372.
SECTION VIII -- CONTROL MEASURES
Respiratory Protection (Specify Type): Ventilate to keep air concentration below TLV on monoethanolamine and sodium
metasilicate.
Ventilation:
Recommended Mechanical (General) = Recommended N/A N/A
Local Exhaust = Special Other =
=
Protective Gloves: Impervious gloves when working with Chemical safety goggles when working
Eye Protection:
concentrate with concentrate
Other Protective Clothing or Equipment: Impervious to water and alkaline liquid where concentrate is a concern.
Work / Hygienic Practices: Wash thoroughly after handling.
SECTION IX - TRANSPORTATION INFORMATION
Applicable regulations: DOT = No; IMCO = No; IATA = No
Proper shipping name: Cleaning compound
UN No.: not applicable Limited Qty.: not applicable Hazard Class: not applicable
Labels required: not required DOT Exception: not applicable
EPA Hazardous waste/number code: not listed
Hazardous waste characteristics:
Ignitability = not applicable; Corrosivity = yes; Reactivity = not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR
INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR
1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein is
presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS
PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL
REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.