astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
1 OF 2
Section I: IDENTIFICATION
Date Prepared: 07/16/03
Product Name: Acid Fast, ZN Carbol Fuchsin Item Number: 6509, 6510
Emergency Phone: 800-424-9300
Section II: HAZARDOUS INGREDIENTS
Hazardous Component(s): CAS# OHSA PEL, ACGIH TLV/STEL NFPA
Phenol < 9% 108-95-2 5 5/250 ppm Health 1
Methanol < 1% 67-56-1 200 200/250 ppm Flammability 1
Ethanol <17% 64-17-5 1000 1000/NR ppm Reactivity 0
Basic Fuchsin < 1% 632-99-5 NR
Section III: PHYSICAL DATA
Boiling Point: ~210癋 Specific Gravity (H2O = 1): ~1
Vapor Pressure mm Hg/20癈: 79 Percent Volatile by Vol: 10%
Vapor Density (Air 1:1): >1 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Reddish liquid, phenolic odor
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: 62篎 Flammable Limits: LEL, NA UEL, NA
Extinguishing Media: Water spray, dry chemical, CO2 and foam for alcohol
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: Toxic fumes may be emitted upon combustion.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers, chromic anhydride, perchloric acids etc.
Hazardous Decomposition or Byproducts: Oxides of carbon
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion, Poison
Acute: Vapors may cause eyes, skin and respiratory irritation, drowsiness, nausea, headache and vomiting.
Chronic: May cause liver, heart and kidney damage. May cause gastrointestinal disturbances and convulsions.
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Vision blurring, drowsiness and headache.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
ZN, CF 2 OF 2
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persists.
Ingestion: Rinse mouth thoroughly with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Eliminate source of ignition in the vicinity of the spill or released vapor. Isolate the
spill area with sand, or other absorbent material. Place all contaminated material in closed container for
disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Use precaut ions for combustible liquids. Avoid excessive heat and
sources of ignition. Use in ventilated area.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required. If used in a poorly ventilated area use under an approved fume
hood or NIOSH approved respirator.
Ventilation: Mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astraldiagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
1 OF 2
Section I: IDENTIFICATION
Date Prepared: 07/16/03
Product Name: Acid Fast, ZN Decolorizer Item Number(s): 6509, 6520
Emergency Phone: 800-424-9300
Section II: COMPOSITION
Hazardous Component(s): CAS Number OHSA PEL, ACGIH TLV/STEL(PPM) NFPA
Methanol ~ 92% 67-56-1 200 200/250 Health 1
Hydrochloric Acid ~ 3% 7647-01-0 1 3/NA Flammability 3
Reactivity 0
Section III: PHYSICAL DATA
Boiling Point: 83癋 Specific Gravity (H2O = 1): ~0.9
Vapor Pressure mm Hg/20癈: 40 Percent Volatile by Vol: 91%
Vapor Density (Air 1:1): 1.6 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Colorless liquid/alcohol odor
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: 55癋 TCC Flammable Limits: LEL 3.3 UEL 1.9
Extinguishing Media: Water spray, dry chemical, CO2 and foam for alcohol
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: May emit toxic fumes under fire conditions. Burns with invisible flame.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers, chromic anhydride, perchloric acids etc.
Hazardous Decomposition or Byproducts: Oxides of carbon and chlorine gas
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat, sparks or flames
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion Target Organs: Kidneys, nervous system, liver and eyes
Acute: Vapors may cause eyes, skin and respiratory irritation, drowsiness, nausea, headache and vomiting.
Chronic: May cause liver, heart and kidney damage. May cause gastrointestinal disturbances and convulsions.
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Slightly hazardous to skin in the concentration provided. Protect eyes and
respiratory system from mist. Vision blurring, burning sensation, drowsiness and headache.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
ZN, Decolorizer 2 OF 2
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persists.
Ingestion: Rinse mouth thoroughly with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Eliminate source of ignition in the vicinity of the spill or released vapor. Isolate the
spill area with sand, or other absorbent material. Place all contaminated material in closed container for
disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Use precautions for flammable liquids. Avoid excessive heat and
sources of ignition. For large quantities, store in flammable safety cabinet. Use in well- ventilated area.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required. If used in a poorly ventilated area use under an approved fume
hood or NIOSH approved respirator.
Ventilation: Special flammable exhaust hood if vapor concentration is high. In well- ventilated areas,
mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astraldiagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
1 OF 2
Section I: IDENTIFICATION
Date Prepared: 07/16/03
Product Name: Acid Fast, ZN Methylene Blue Item Number: 6509, 6530
Emergency Phone: 800-424-9300
Section II: HAZARDOUS INGREDIENTS
Hazardous Component(s): CAS# OHSA PEL, ACGIH TLV/STEL(PPM) NFPA
Methylene Blue <1% 7220-79-3 NE Health 1
Flammability 0
*Product is not expected to present a health concern in the concentration offered. Reactivity 0
Section III: PHYSICAL DATA
Boiling Point: ~212癋 Specific Gravity (H2O = 1): ~1
Vapor Pressure mm Hg/20癈: 79 Percent Volatile by Vol: 10%
Vapor Density (Air 1:1): >1 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Blue liquid, odorless
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: NA Flammable Limits: NA UEL, NA
Extinguishing Media: Water spray, dry chemical, CO2 and foam
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: May emit toxic fumes under fire conditions.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers, chromic anhydride, perchloric acids etc.
Hazardous Decomposition or Byproducts: Oxides of carbon and nitrogen and chlorine fumes
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion. Very hazardous in case of ingestion.
Acute: Vapors may cause eyes, skin and respiratory irritation.
Chronic: May cause gastrointestinal disturbances.
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Eye irritation.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
ZN Methylene Blue, 2 OF 2
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persists.
Ingestion: Rinse mouth with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Isolate the spill area with sand, or other absorbent material. Place all contaminated
material in a closed container for disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Normal laboratory precautions. Avoid excessive heat.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required.
Ventilation: Mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel as suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astral Diagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Fo rest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
|