1
MC-1501
MATERIAL SAFETY DATA SHEET
I. IDENTIFICATION .
MANUFACTURED BY: Diamond Vogel Paint REVISED: 08/04/2009
711 South Third Avenue PRINTED: 08/11/2009
Marshalltown, IA 50158-8001
General Information:
24 Hour Emergency Telephone Mon-Fri 8 AM - 5 PM
CHEMTREC 1-800-424-9300 712-737-4993
PRODUCT LINE: V-Cote 200 Primer & Finish White
MC-0501 V-Cote 200 Primer/Finish Gray
MC-1501 V-Cote 200 Primer/Finish White
MC-1503 V-Cote 200 Primer/Finish Deep Base
MC-5500 V-Cote 200 Primer/Finish Red Oxide
II. HAZARDOUS INGREDIENTS .
CAS #107-21-1 Ethylene Glycol WT %: 1-5 Footnote: (1)
ACGIH TLV: 39.4 ppm TWA ACGIH STEL:
OSHA PEL: 50 ppm TWA OSHA CEILING: 50 ppm OSHA PEAK:
VAPOR PRESSURE: .12mmHg@25C LEL%:
CAS #14808-60-7 Crystalline Silica WT %: 0.240 Footnote: (2)
ACGIH TLV: 0.025 mg/m3 ACGIH STEL: NE
OSHA PEL: 10/(%SiO2+2) mg/m3 OSHA CEILING: NE OSHA PEAK: NE
VAPOR PRESSURE: NA LEL%: NA
WARNING MESSAGES:
(1) Reports have associated repeated and prolonged occupational overexposure to solvents
with permanent brain and nervous system damage. Intentional misuse by deliberately
concentrating and inhaling the contents may be harmful or fatal. Chronic exposure may
cause damage to the central nervous system, respiratory system, lung, eye, skin, liver,
gastrointestinal tract, spleen, kidneys, and blood.
(2) International Agency for Research on Cancer (IARC) Monograph Volume 68 (1997) concludes
that Crystalline Silica is "carcinogenic to humans (Group 1)" based on sufficient
evidence in humans and experimental animals.
(3) See Section IX for reportable Hazardous Air Pollutants.
III. PHYSICAL DATA .
BOILING RANGE: 212?F
EVAPORATION RATE: * slower than ether *
PERCENT VOLATILE BY VOLUME: 60.40-60.97% WEIGHT PER GALLON: 10.64-10.97 LBS
VAPOR DENSITY: * trace amounts of organic vapors will be heavier than air *
ACTUAL VOC (lb/gal): 0.32-0.33
EPA VOC (lb/gal): 0.75-0.77 EPA VOC (g/L): 89.88-92.28
IV. FIRE AND EXPLOSION HAZARD DATA .
FLASH POINT: 200+?F 93+?C LEL: Refer to Section II
2
MC-1501
FLAMMABILITY CLASSIFICATION: * Not Regulated *
HAZARD CLASSIFICATION: *Not Regulated*
EXTINGUISHING MEDIA: *carbon dioxide, dry chemical, or fire foam*
UNUSUAL FIRE AND EXPLOSION HAZARDS: Closed containers may explode when
exposed to extreme heat. (Due to buildup of steam
pressure.)
SPECIAL FIRE FIGHTING PROCEDURES: Use water to keep closed containers cool.
V. HEALTH HAZARD DATA .
THRESHOLD LIMIT VALUE: See Section II.
EFFECTS OF OVEREXPOSURE:
ACUTE - High vapor concentrations are irritating to the eyes and
the respiratory tract, and may cause headaches, dizziness,
anesthesia, drowsiness, unconsciousness, and other central
nervous system effects, including death. Product has a low
order of acute oral and dermal toxicity, but minute amounts
aspirated into the lungs during ingestion or vomiting may
cause mild to severe pulmonary injury and possibly death.
CHRONIC - This product contains crystalline silica which is
classified as carcinogenic to humans, Group 1, by the
International Agency for Research on Cancer (IARC), based on
sufficient evidence of carcinogenicity in humans. Crystalline
silica may also cause delayed respiratory disease (silicosis)
if inhaled over a prolonged period of time. Avoid breathing
dust. Use a NIOSH/MSHA approved respirator where TLV for
crystalline silica may be exceeded.
MEDICAL CONDITIONS PRONE TO AGGRAVATION BY EXPOSURE: consult physician
PRIMARY ROUTE(S) OF ENTRY: Skin and Inhalation
EMERGENCY AND FIRST AID PROCEDURES:
INHALATION: Remove to fresh air. Restore breathing. Treat
symptomatically. Consult a physician.
EYES: Flush immediately with large amounts of water for at least
15 minutes. Talk to a physician for medical treatment.
SKIN: Wipe off with towel. Wash with soap and water. Remove
contaminated clothing.
INGESTION: If swallowed, call a physician immediately. Remove
stomach contents by gastric suction or induce vomiting only
as directed by a medical personnel. Never give anything by
mouth to an unconscious person.
3
MC-1501
VI. REACTIVITY DATA .
STABILITY: *stable* HAZARDOUS POLYMERIZATION: *will not occur*
INCOMPATIBILITY: * unknown *
HAZARDOUS DECOMPOSITION PRODUCTS: Fire, burning and welding may generate
carbon monoxide.
CONDITIONS TO AVOID: Fire, burning, and welding.
VII. SPILL OR LEAK PROCEDURES .
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Remove all sources of ignition (flames, hot surfaces and
electrical, static or frictional sparks). Avoid breathing
vapors. Ventilate area. Use non-sparking tools. Remove with
inert absorbant.
WASTE DISPOSAL METHOD: Dispose of in accordance with local, state, and
federal regulations.
VIII. SPECIAL PROTECTION INFORMATION .
RESPIRATORY PROTECTION: In confined areas of poor ventilation, use chemical
cartridge respirator or self-contained breathing
apparatus.
VENTILATION: Provide general dilution or local exhaust ventilation in
volume and pattern to keep TLV and LEL of most hazardous
ingredient in Section II, below acceptable limit.
PROTECTIVE GLOVES: None required except for prolonged contact.
EYE PROTECTION:
Splash proof eye goggles. In emergency situations, use eye
goggles with a full face shield.
OTHER PROTECTIVE EQUIPMENT: *none*
HYGIENIC PRACTICES: See Section V
IX. SPECIAL PRECAUTIONS .
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
Do not store near heat, sparks, or flame.
OTHER PRECAUTIONS: * none *
LIST OF HAZARDOUS AIR POLLUTANTS SUBJECT TO THE PROVISIONS OF THE CLEAN AIR
ACT, TITLE I SECTION 112 'National Emission Standards for Hazardous Air
Pollutants':
4
MC-1501
Wt% of HAPS Pounds HAPS/
Ingredient CAS # in product Gal product
------------------------------ ------------ ----------- ----------
Ethylene Glycol 107-21-1 2.5 % 0.3
_____________________________________________________________________________
|