ND Vibra-Tite?Formula #3TM
PRODUCT:
MSDS ID: ND1030
8/05/94
ORIG. DATE:
4/14/04
REV. DATE:
6/27/07
REV. DATE:
ND INDUSTRIES , INC. (248) 288-0000 Fax: (248) 288-0022
24 hr. EMERGENCY CHEMTREC:
1893 BARRETT ROAD
Chemical Safety
PREPARED BY:
1-800-424-9300
TROY, MICHIGAN 48084
H: 2 F: 3 R: 0 PPE: C
SECTION I -Material Identification and Information
PERCENT OSHA OTHER LIMITS
ACGIH
CAS #
COMPONENTS PEL RECOMMENDED
TLV
%
Acrylic polymer (contains toluene) VTB-07-409 not assigned 20-25 n.a. n.a. Non-hazardous
Acrylic polymer VTB-07-08 not assigned 12-18 n.a. n.a. Non-hazardous
Methyl ethyl ketone 78-93-3 62-72 200 ppm 200 ppm
All ingredients are listed on the TSCA Inventory. n.a.= not applicable / n.e.=not established
SECTION II -Physical and Chemical Characteristics
BOILING POINT: approx. 80癈
VOC #/gal. : 5.838
VAPOR DENSITY: 2.49 air = 1
DENSITY OF COATING: 7.67
VAPOR PRESSURE: 83 mmHg at 75癋
MELTING POINT: n.a.
SPECIFIC GRAVITY: 0.92 water = 1
EVAPORATION RATE: 6.31 Butyl Acetate
WATER REACTIVE: n.a.
SOLUBILITY IN WATER: 16.32% @ 20癈
APPEARANCE AND ODOR: Pinkish orange, viscous liquid with non-residual, "solvent-like" odor.
SECTION III - Fire and Explosion Hazard Data
FLASH POINT: -4癈 TCC -2癈 TOC
AUTOIGNITION TEMPERATURE: approx. 860癋
UEL: 11.5 @77癋
FLAMMABILITY LIMITS % IN AIR: LEL: 1.8 @77癋
EXTINGUISHER MEDIA: Use water spray, carbon dioxide, dry chemicals and/or foam.
Wear a MSHA/NIOSH approved self-contained breathing apparatus with full face piece operated in
SPECIAL
pressure-demand or other positive pressure mode when fighting fires.
FIREFIGHTING
PROCEDURES:
UNUSUAL FIRE Vapors will creep along floors, stairs, etc... as well as by air currents. Any spark, open flame or strong heat source
HAZARDS AND will ignite vapors and source. Combustion yields oxides of carbon.
CONDITIONS TO
AVOID:
PRODUCT: ND Vibra-Tite?Formula #3TM
SECTION IV - Reactivity Hazard Data
STABILITY: stable: X unstable:
HAZARDOUS POLYMERIZATION: may occur: will not occur: X
CONDITIONS This material is considered stable. However, avoid all sources of ignition, fire, heat etc...
TO AVOID:
INCOMPATIBILITY: Avoid contact with the following: acids, amines, bases, oxidizing agents, halogens and molten sulfur.
HAZARDOUS Thermal decomposition may yield acrylic monomers.
DECOMPOSITION
PRODUCTS:
SECTION V - Health Hazard Data
X X
PRIMARY ROUTES OF ENTRY: X
INHALATION: INGESTION: SKIN ABSORPTION:
EYE CONTACT: Can cause severe eye irritation, if not removed promptly. May result in permanent eye damage.
FIRST AID: Flush eyes with generous amounts of water for 15 minutes lifting both upper and lower eyelids occasionally. Get
medical attention.
Prolonged contact may cause moderate skin irritation and dermatitis.
SKIN
CONTACT:
Thoroughly wash exposed area with soap and water. Remove contaminated clothing including shoes. Launder
before reuse. If irritation occurs, seek medical attention.
FIRST AID:
Vapor concentrations above exposure levels are irritating to the respiratory tract. May cause headaches,
INHALATION:
dizziness, and are an anesthetic and may have other central nervous system effects.
Remove individual to fresh air. If breathing has stopped, give artificial respiration.
FIRST AID:
Get medical attention.
INGESTION: Small amounts of this material aspirated into the respiratory system during ingestion, or from vomiting, may cause
bronchiopneumonia or pulmonary edema.
FIRST AID: Do NOT induce vomiting. Immediately drink two glasses of water and get medical
attention.
Long term exposure at high concentrations may lead to CNS Depression.
CHRONIC
EFFECTS:
Carcinogenic: This products components contain xylene, ethylbenzene, and trace amounts of benzene which are listed as OSHA
regulated carcinogens.
PRODUCT: ND Vibra-Tite?Formula #3TM
Component Oral LD50 Dermal LD50 Inhalation LC50
not determined
>3000 mg/Kg (rabbit)
Acrylic polymer >5000 mg/Kg (rat)
not determined
not determined
Acrylic polymer not determined
> 5000 ppm (rat)
> 5g/kg (rabbit)
Methyl ethyl ketone 2.9 g/kg (rat)
SECTION VI - Control and Protective Measures
RESPIRATORY Work in a well ventilated area. For high concentrations use a NIOSH/MSHA approved respirator to prevent
PROTECTION: overexposure.
PROTECTIVE Use latex gloves for minor contact. For excessive or prolonged contact use rubber or neoprene.
GLOVES:
EYE PROTECTION: Wear NIOSH approved safety glasses with sideshields or chemical splash goggles if contact is likely.
VENTILATION LOCAL EXHAUST: X MECHANICAL: SPECIFIC:
TO BE USED: OTHER (specify): Use explosion proof ventilation.
PROTECTIVE CLOTHING Wear impervious clothing to prevent repeated, prolonged skin contact.
AND EQUIPMENT:
Practice careful chemical handling and good personal hygiene when working with our product. Wash
HYGIENIC WORK
hands after using product.
PRACTICES:
SECTION VII - Precautions for Safe Handling and Spill/Leak Procedures
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
Immediately extinguish all sources of ignition until area is free of explosive hazard. Absorb material on inert filler and place in a sealed
container suitable for disposal. Prevent material from entering sewers, watercourses or low areas.
This material when determined to be a waste will be a hazardous waste by characteristic of ignitability
WASTE DISPOSAL
(D001) and/or characteristic of toxicity (D035) according to CFR40, 261 Subpart C.
METHODS:
Avoid breathing product vapors. Keep product away from all sources of ignition, heat or flame. Keep
SAFE HANDLING
container closed when not in use. Store material in a cool, dry place.
AND STORAGE:
OTHER PRECAUTIONS AND SPECIAL HAZARDOUS INFORMATION:
Containers of this product may be hazardous when emptied, since they contain product residue, observe all precautions.
RECOMMENDED 2 3 0 C
HEALTH FLAMMABILITY REACTIVITY PERSONAL
NFPA/HMIS PROTECTION
note: ratings may differ according to application, environment, and physical state.
RATING
PRODUCT: ND Vibra-Tite?Formula #3TM
NOTES:
DOT Shipping Name:
Coating solution
3, UN1139, PGII
WHMIS Identification: Class B, Division 2
SECTION 313 SUPPLIER NOTIFICATION
Detaching this notification from the Material Safety Data Sheet is prohibited by law and any copying or
distribution of same requires this attachment be included.
This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 and 40 CFR 372:
CAS # CHEMICAL NAME % BY WEIGHT
78-93-3 Methyl ethyl ketone 62
This product contains the following materials that under California Proposition 65 of the Safe Drinking Water and Toxic
Enforcement Act of 1986 are recognized to cause cancer or reproductive toxicity.
Cancer Reproductive cancer Reproductive
Concentration &
Material CAS # agent Toxin
Agent Toxin
%
Toluene 108-88-3 13.5 X
Benzene 71-43-2 trace X
Acrylonitrile 107-13-1 trace X
ND Vibra-Tite?is a registered trademark of ND Industries? Inc. Formula 3TM is a trademark of ND
Industries? Inc.
The information contained herein is based on the data available to us and is believed to be correct. However, ND Industries?
Inc. makes no warranty, expressed or implied regarding the accuracy of these data or the results to be obtained from the use
thereof. Information is supplied upon the condition that the persons receiving same will make their own determination as to its
suitability for their properties prior to use. Since conditions of use are beyond our control, all risks are assumed by the user.
|