II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
Solvent naphtha (petroleum), light 50.0-55.0 N/E N/E N N N 64742-95-6
aromatic
1,2,4-Trimethylbenzene 20.0-30.0 25 ppm 25 ppm N N Y 95-63-6
2-Ethylhexylnitrate 10.0-20.0 N/E N/E N N N 27247-96-7
Xylene 1.00-5.00 100 ppm 100 ppm Y N Y 1330-20-7
Heavy aromatic naphtha 1.00-5.00 N/E N/E Y N N 64742-94-5
Cumene < 2.00 50 ppm (skin) 50 ppm (skin) Y N Y 98-82-8
Amine substituted resin < 2.00 N/E N/E N N N Trade secret
Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (癋): N/D SPECIFIC GRAVITY (WATER = 1): .882
VAPOR PRESSURE (mm Hg): N/D VOC CONTENT (% by weight): N/D
VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): > 1.00
SOLUBILITY IN WATER: Insoluble pH: N/A
APPEARANCE AND ODOR: Clear, gold liquid; solvent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (癋): 108 (TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/D LOWER: N/D
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Solvent vapors may cause flashback.
PRODUCT NAME: Diesel Clean PRODUCT CODE: 0657
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers and acids.
CONDITIONS TO AVOID: Excess heat and open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Irritation and redness. Material is corrosive to eyes and may cause permanent injury.
IF ON SKIN: Redness, irritation, dermatitis. May aggravate existing dermatitis condition.
IF SWALLOWED: May be harmful or fatal if swallowed. Gastrointestinal irritation, nausea, cramps, vomiting. Small amounts of this
product may be aspirated into the respiratory system during ingestion or vomiting and may cause mild to severe pulmonary injury,
possibly progressing to death.
IF INHALED: Irritation to upper respiratory tract, dizziness, light-headedness, drowsiness, and CNS effects.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention.
IF ON SKIN: Remove contaminated clothing and launder separately before reuse. Wash with soap and water. If irritation persists,
obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Do not induce vomiting unless told to do so by a physician
or poison control center.
IF INHALED: Remove person to fresh air. Administer artificial respiration if not breathing. Obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all sources of ignition. Contain spill.
Soak up spilled material with inert absorbent material and place in a properly marked closed container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits are
exceeded wear a NIOSH approved respirator, following manufacturer's recommendations.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses and/or face shield.
OTHER PROTECTIVE EQUIPMENT: Eye wash station, protective clothing.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Keep
container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None DOT ID NUMBER: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is
further intended, different shipping names and labeling may apply.
REVISION DATE: November 11, 2004 Prepared by: PMR DATE OF ISSUE: December 29, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material such vendees or users assume all risks associated with the use of this material.