Material Safety Data Sheet
HMIS Ratings: HEALTH: 1
FLAMMABILITY: 0
DATE OF PREPARATION: 3/31/2009 REACTIVITY: 0
PROTECTION: B
SECTION I - PRODUCT IDENTIFICATION
PRODUCT NAME: DOUBLE OVERTIME
ITEM NUMBER: 32002
SIZE: Pail
PRODUCT DESCRIPTION: LOW ODOR SPORTS FLOOR FINISH
SECTION II - HAZARDOUS INGREDIENTS
Occupational
Exposure Limits VAPOR
PRESSURE-
INGREDIENT CAS # % WEIGHT ACGIH-TLV OSHA-PEL mm Hg
DIPROPYLENE GLYCOL MONOMETHYL ETHER 34590-94-8 2.5-10% 100 PPM 100 PPM 0.55 @ 25C
DIPROPYLENE GLYCOL N-BUTYL ETHER 29911-28-2 2.5-10% N/E N/E 0.06 @ 20C
N-METHYL-2-PYRROLIDONE 872-50-4 2.5-10% N/E N/E 1.00 @ 25C
SECTION III - PHYSICAL DATA
BOILING RANGE: >212F (100C) EVAPORATION RATE: Slower than n-Butyl Acetate
% VOLATILE - WT: 72 DENSITY: 8.52 LBS/GAL (1.02KG/L)
VAPOR DENSITY: Heavier than air SOLUBILITY IN WATER: Miscible
PRODUCT CHARACTERISTICS: White, milky liquid with sweet acrylic odor
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY CLASSIFICATION: Non-Flammable
FLASH POINT: None.
% OF VOL. OF FLAMMABLE LIMITS (Upper): N/A (Lower): N/A
EXTINGUISHING MEDIA: Water Spray, Foam, Carbon Dioxide, Dry Chemical
Closed containers may explode (due to the build-up of steam pressure) when exposed to extreme heat.
UNUSUAL FIRE &
EXPLOSION
HAZARDS:
Water may be used to cool closed containers to prevent pressure build-up.
SPECIAL
FIREFIGHTING
PROCEDURES:
SECTION V - HEALTH HAZARD DATA AND FIRST AID PROCEDURES
EYE CONTACT: May cause irritation, redness and tearing. In case of contact, flush immediately with large amounts
of water and obtain medical attention.
SKIN CONTACT: Prolonged or repeated contact may cause drying of skin. In case of contact, remove contaminated
clothing. Wash area with soap and water.
INHALATION: Excessive inhalation of vapors may cause dizziness and possible headache. If affected by inhalation,
remove to fresh air.
INGESTION: May cause gastrointestinal irritation and nausea. If swallowed, drink 1 or 2 glasses of water to
dilute. Get medical attention.
PRIMARY ROUTES OF ENTRY: Inhalation and Dermal
Manufactured for Triple S 2 Executive Park Drive, Billerica, MA 1 of 3
Product Information: 1-800-323-2251
Emergency Telephone: 1-888-779-1339
Section 313 supplier notification: This product contains the following chemical(s) subject to the
REGULATORY
reporting requirements of Section 313 of Title III of the Superfund Amendment and Reauthorization
DATA:
Act of 1986 and 40CFR 372: N-Methyl-2-pyrrolidone. This product contains the following
chemical(s) which are known to the state of California to cause birth defects or other reproductive
harm: N-Methyl-2-pyrrolidone.
N/E
TOXICITY INFO:
SECTION VI - REACTIVITY DATA
Stable REACTIVITY WITH WATER: Will Not Occur
STABILITY:
Usual products of combustion, e.g. Carbon Monoxide, Carbon Dioxide, Nitrogen Oxides
HAZARDOUS DECOMPOSITION
PRODUCTS:
Will Not Occur
HAZARDOUS POLYMERIZATION:
Strong Oxidizers
INCOMPATIBILITY
(MATERIALS TO AVOID):
SECTION VII - SPILL OR LEAK PROCEDURES
Ventilate area. Remove with inert absorbent.
IN CASE MATERIAL IS
RELEASED OR SPILLED:
Dispose of contaminated absorbent, container and unused contents in accordance with local,
WASTE DISPOSAL:
state/provincial and federal regulations.
Not regulated as a DOT hazardous material
SHIPPING INFORMATION:
SECTION VIII - SAFE HANDLING AND USE INFORMATION
No protection required when ventilation recommendations (below) are followed
RESPIRATORY PROTECTION:
Use with adequate general and/or local ventilation to maintain exposure level below TLV.
VENTILATION:
Wear chemical-resistant gloves such as nitrile rubber.
PROTECTIVE GLOVES:
Use chemical splash goggles or OSHA-permitted safety glasses. Have an eyewash station
EYE PROTECTION:
available.
Wear impervious clothing to avoid repeated or prolonged skin contact.
OTHER PROTECTIVE
EQUIPMENT:
Wash hands with soap and water before eating or using rest rooms.
HYGIENIC PRACTICES:
SECTION IX - MISCELLANEOUS
Do not transfer contents to bottles or other unlabeled containers. Do not store in high temperature (above 100F or 38C)
environment. Keep from freezing.
Manufactured for Triple S 2 Executive Park Drive, Billerica, MA 2 of 3
Product Information: 1-800-323-2251
Emergency Telephone: 1-888-779-1339
***KEEP OUT OF THE REACH OF CHILDREN***
KEY CODE
HMIS = Hazardous Materials Information System
0 = Minimal Hazard A = Glasses F = Glasses + Gloves + Apron + Dust Mask
1 = Slight Hazard B = Glasses + Gloves G = Glasses + Gloves + Vapor Respirator
2 = Moderate Hazard C = Glasses + Gloves + Apron J = Goggles + Gloves + Vapor Respirator + Apron
3 = Serious Hazard D = Glasses + Faceshield + Gloves + Apron
4 = Severe Hazard E = Glasses + Gloves + Dust Respirator
N/A = Not Applicable
N/E = Not Established
ACGIH = American Conference of Governmental Industrial Hygienists
OEL= Occupational Exposure Limits
PEL = Permissible Exposure Limit = exposure limit to an airborne contaminant in a workday set by OSHA
TLV = Threshold Limit Value = Time-weighted average concentration for a normal 8-hour workday without adverse effect.
IARC = International Agency for Research on Cancer
NTP = National Toxicology Program
OSHA = Occupational Safety and Health Administration
The identities of ingredients are withheld as proprietary information. The information on this data sheet represents our best opinion as to the proper
use and handling of this product under normal conditions, based upon information compiled from sources considered to be dependable. It is accurate
and reliable to the best of our knowledge and belief, but is not guaranteed to be so. It is the user's responsibility to determine the suitability of this
product for a specific purpose and to adopt such safety precautions as may be necessary. Any use of the product which is not in conformance with
this data sheet or which involves using the product in combination with any other product or any other process is the responsibility of the user.
BEFORE USING ANY PRODUCT, READ THE LABEL.
Manufactured for Triple S 2 Executive Park Drive, Billerica, MA 3 of 3
Product Information: 1-800-323-2251
Emergency Telephone: 1-888-779-1339
|