MATERIAL SAFETY DATA SHEET
GM FOAM WATER BASE PRIMER
SECTION I--Preparation/Product Information
MANUFACTURED FOR AND SUPPLIED BY: TELEPHONE NO: (818) 908-1087
GM Foam, Inc DATE PREPARED: July 6, 2001
14956 Delano St. PREPARED BY: GM Foam, Inc
Van Nuys, CA 91411 DATE PRINTED: July 6, 2001
EMERGENCY CONTACT: (818) 908-1087
SECTION II ?Ingredients/Identity Information
COMPONENTS EXPOSURE LIMITS TOXICITY
CHEMICAL IDENTITY CAS#/UN# PEL / TLV / OTHER LD50 / LC50
Triethylamine 121-44-8 25 PPM
Toluene 108-88-3 200 PPM
N-Methyl ?2 ?Pyrolidone 872-50-4 PEL Not Established
Water 7732-18-5
Ingredients not precisely identified are proprietary or non-hazardous.
HAZARD STATEMENT: this material safety data sheet has been prepared in compliance with the federal osha hazard
communication standard 29 cfr 1910.1200. This product is not considered to be a hazardous
chemical under that standard.
SECTION III ?Physical / Chemical Characteristics
BOILING POINT: 100篊 SPECIFIC GRAVITY (H2O = 1): 1.035 (calc.)
FREEZING POINT: 0篊 pH: Not Applicable
VAPOR PRESSURE (mm Hg): Not Applicable ODOR THRESHOLD (ppm): Not Determined
VAPOR DENSITY (AIR = 1): Not Applicable COEF. WATER/OIL DIST.: Not Applicable
SOLUBILITY IN WATER: Miscible EVAPORATION RATE: Not Applicable
APPEARANCE (PHYSICAL STATE) AND ODOR: White Translucent Liquid; Charactersistic odor
SECTION IV ?Fire and Explosion Hazard Data
FLASH POINT (Method): None
EXTINGUISHING MEDIA: Water is permissible for dry film of primer
GM FOAM WATER BASE PRIMER ?PAGE 1
SPECIAL FIRE FIGHTING PROCEDURES: None
UNUSUAL FIRE AND EXPLOSION HAZARDS: use water on fire exposed containers to cool to reduce pressure.
HMIS RATING: 0
FLAMABLE LIMITS LEL: Not Applicable
UEL: Not Applicable
AUTOIGNITION TEMPURATURE: Not Applicable
SENS. TO MECHANICAL IMPACT: Not Applicable
SENS. TO STATIC DISCHARGE: Not Applicable
HAZARDOUS COMBUSTION PRODUCTS: None known
SECTION V ?Reactivity Data
SABILITY:
Stable X
Unstable
CONDITIONS TO AVOID (Condition of Reactivity): Strong oxidizing agents
INCOMPATIBILITY (Materials to Avoid): None known
HAZARDOUS DECOMPOSITION OF BYPRODUCTS: Carbon Monoxide, Carbon Dioxide, possibly oxides of nitrogen.
HAZARDOUS POLYMERIZATION:
May Occur:
Will Not Occur: X
CONDITIONS TO AVOID: None Known
SECTION VI ?Health Hazard Data
PRI MARY ROUTE OF EXPOSURE:
Inhalation: Skin Contact: X
Skin Absorbtion: Ingestion:
Eye Contact:
HEALTH HAZARDS (acute and chronic):
No special hazard except eye contact causes irritation. Prolonged or repeated skin contact may cause mild, transient irritation.
CARCINOGEN:
NTP: No IARC: No OSHA: No
SIGNS AND SYMPTOMS OF EXPOSURE: See health hazards above.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: None Known
GM FOAM WATER BASE PRIMER ?PAGE 2
WHMIS CLASSIFICATION: Not Determined
HMIS RATING: 1
EMERGENCY AND FIRST-AID PROCEDURES, EYES:
Rinse with running water for at least 15 minutes with eyelids held open
EMERGENCY AND FIRST-AID PROCEDURES, SKIN:
Remove with water or water-dampened towel.
SECTION VII--Spill Or Leak Procedures
SPILL PROCEDURES:
Not normally a fire hazard. Water content of product prevents ignition. Can support combustion if water is evaporated. Large
spills may be scooped up, small spills can be taken up by absorbent. Absorb onto sand or other absorbent material. Shovel
into closable container for disposal. Wear protective equipment specified below. Thoroughly flush residue with water.
WASTE DISPOSAL METHODS:
Place in closed containers. Carefully incinerate after opening containers or use secure landfill in accordance with federal,
state, and local regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
Store away from high temperatures and flames. Avoid prolonged skin contact. Do not breath spray mist.
OTHER PRECAUTIONS:
Do not cut, puncture or weld on or near empty containers.
SECTION VIII--Special Protection Information
RESPIRATORY PROTECTION:
Not normally needed. If heated, follow OSHA regulation 29CRF1910.134.
VENTILATION:
Local exhaust: Useful to dry applied product
Mechanical: Normal shop ventilation adequate
Special: None
Other: None
PROTECTIVE GLOVES:
Neoprene rubber gloves.
EYE PROTECTION:
Goggles or side shield spectacles
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
Eye wash station and safety showers should be available.
WORK/HYGIENIC PRACTICES:
Usual shop practice.
GM FOAM WATER BASE PRIMER ?PAGE 3
SECTION IX--Regulatory Information
DOT CLASS:
Not regulated
DOT NUMBER:
Not applicable
SARA/TITLE III-TOXIC CHEMICALS LIST:
This product does not contain a toxic chemical for routine annual "toxic chemical release reporting" under sec. 313 (40 cfr 372)
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA THAT IS ACCURATE AND
RELIABLE TO THE BEST OF GM FOAM'S KNOWLEDGE AND BELIEF. WITH RESPECT TO THE INFORMATION AND
RECOMMENDATIONS, GM FOAM MAKES NO REPRESENTATIONS OR WARRANTIES OF ANY KIND OR NATURE, EXPRESS
OR IMPLIED.
This Adobe Portable Document Format file was created from GM Foam, Inc's original Material Safety
Data Sheet word document files by Cybergraphic Designs, Inc. for use on the Cybergraphic Designs, Inc.
Makeup Effects & Supply website. Please visit us on the web to download other useful MSDS PDF files.
http://www.getspfx.com
GM FOAM WATER BASE PRIMER ?PAGE 4
|