Material Safety Data Sheet - OSHA 174 H.M.I.S. RATING
Health 1
Materials Safety Data Sheet US Department of Labor
May be used to comply with OSHA's Hazard Communication Occupational Safety and Health Administration
Flammability 0
Standard, 29 CFR 1910.1200. Standard must be consulted (Non-Mandatory Form) Form Approved OMB No.
for specific requirements. 1218-0072
Reactivity
Protective Equip. E
HE558 - ALUMINUM ROOF COATING Last Rev Date:
Section I
Manufacturer's Name Emergency Telephone Telephone
HENRY COMPANY 800-486-1278 800-486-1278
Address Primary Contact Email
Technical Services techservices@henry.com
HENRY COMPANY
909 NORTH SEPULVEDA BLVD. NFPA Preparer's Signature
EL SEGUNDO, CA 90245 704
Section II Hazardous Ingredients / Identity Information
Hazardous Component CAS# OSHA_PEL AGGIH_TL Other Limits Percent
Kaolin 1332.58.7 15 mg/m3 2.0 mg/m3 F1,F2,F3
Notes: F1: Contains quartz which is a carcinogen (OSHA, IARC, and NTP). Risk of cancer depends on duration and level of exposure.
F:2 OSHA PEL Quartz (total dust) = 30 divided by (% quartz +2) in mgm3; F3:ACGIH TLV Quartz = 0.025 mg/m3
Talc (paint) 14807.96.6 20 mppcf 2.0mg/m3
Biocide 56709.13.8 N/A N/A
Aluminum Metal 7429.90.5 10 mg/m3 F1
Notes: F1: A toxic chemical subject to the reporting requirements of S.A.R.A. Section 313 of the Emergency Planning and Community Right-
To-Know act of 1986 and of 40 CFR 372.
Water 7732.18.5 N/A N/A
Asphalt 8052.42.4 0.5 mg/m3
Comments:There are no S.A.R.A. 313 ingredients in this material in excess of Deminimus amounts. "Asphalt may contain detectable amounts of chemicals
known to the State of California to cause cancer or reproductive harm."
Section III Physical / Chemical Characteristics
Boiling Point (潞F) Melting Point Max VOC (g/l)
212 F N/A 100
Vapor Pressure (mm Hg) Evaporation Rate (Butyl Acetate=1) Max VOS (lbs/gal)
N/A <1 0.84
Vapor Density (Air=1) Weight Per Gallon (lbs) % Water (Volume)
>1 9.4 74.2
Color Solubility in Water % Water (Weight)
Gray Dispersible 65.8
Odor Appearance % Volatile (Weight)
Mild petroleum solvent Fluid 67.8
Specific Gravity PH
1.13 N/A
Henry Company - 909 NORTH SEPULVEDA BLVD., EL SEGUNDO, CA 90245
MSDS HE558
Technical Services - 800-486-1278 Email: techservices@henry.com
www.henry.com
Section IV Fire and Explosion Hazard Data
Flash Point Method Flash Point Temperature LEL Flammable Limit UEL Flammable Limit
N/A
N/A >212掳F N/A
Extinguishing Media
CO2, Dry Chemical, Foam
Fire Fighting Procedures
Dried residue-use self-contained breathing apparatus.
Addtional Procedures
None
Unusual Fire and Explosion Hazards
Closed containers could burst due to steam generation
Section V Reactivity Data
Stability Conditions to Avoid
Material is Unstable Avoid freezing
Incompatibility (Materials to Avoid) Hazardous Decompositions or Byproducts
Acids, Carbon Tetrachloride, Chlorinated Solvents, Carbon Monoxide if combustion is incomplete, CO2, Fumes, Smoke
Halogenated Extinguishers, Strong Oxidants
Hazardous Polymerization Conditions to Avoid
May Not Occur Contact with moisture
Section VI Health Hazard Data
Routes of Entry:
If in Eyes
Symptoms Emergency and First Aid Procedures
-- Tearing, redness, or swelling. -- Flush gently with clean cool water and move individual away from
exposure and into fresh air, consult physican.
-- Burning of eyes.
-- Eye irritation.
If Ingested
Symptoms Emergency and First Aid Procedures
-- Gastrointestinal irritation. -- Get prompt medical attention.
-- May be a health hazard if ingested in large quantities.
If Inhaled
Symptoms Emergency and First Aid Procedures
-- Dizziness, headaches, even unconsciousness or death. -- If overcome, call physician.
-- Remove from vapor immediately and if breathing is difficult,
administer oxygen.
-- If breathing has stopped or is irregular, start resuscitation or
administer oxygen, as needed.
If on Skin
Symptoms Emergency and First Aid Procedures
-- Possible dermatitis or allergenic reaction on repeated contact. -- Flush with clean cool water.
-- Remove contaminated clothes and wash with a waterless hand
cleaner or soap and water.
Henry Company - 909 NORTH SEPULVEDA BLVD., EL SEGUNDO, CA 90245
MSDS HE558
Technical Services - 800-486-1278 Email: techservices@henry.com
www.henry.com
Section VII Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled:
Keep people away. Recover free liquid. Add absorbent sand, earth, sawdust, etc., to spill area. Avoid breathing vapors. Ventilate confined spaces. Open all
windows and doors. Keep products out of sewers and watercourses.
Waste Disposal Method:
Assure conformity with applicable disposal regulations.
Precautions for Handling and Storage:
KEEP FROM FREEZING. Keep containers closed when not in use. Do not handle or store near heat or strong oxidants. Adequate ventilation required.
Other Precautions:
Avoid breathing vapors. Avoid prolonged or repeated contact with skin. Remove contaminated clothing and launder before reuse. Remove contaminated
shoes and thoroughly dry before reuse. Wash skin thoroughly with soap and water after contact.
Section VIII Control Measures
Ventilation
Local Exhaust
Face velocity 60 fpm
Mechanical (General)
N/A
Special Ventilation
Use only with adequate ventilation.
Other
N/A
Protective Equipment Required
Respirator
None required when used with adequate ventilation.
Gloves
Chemical resistant gloves
Goggles
Splash goggles or face shield
Clothing
Chemical resistant apron
Work Hygienic Practices
Practice good work hygiene
Section IX Special Precautions for Safe Handling and Storage
Precautions for Handling and Storage
Do not mix or store with strong oxidants like liquid chlorine, oxygen, or water. Reignition may occur due to high localized heat or spontaneous heating. To
avoid reignition, the residual material must be immediately smothered.
Other Precautions
Water contamination in baked product may lead to generation of Hydrogen Gas. Application to hot surfaces requires special precautions.
Henry Company - 909 NORTH SEPULVEDA BLVD., EL SEGUNDO, CA 90245
MSDS HE558
Technical Services - 800-486-1278 Email: techservices@henry.com
www.henry.com
Section X Transportation Data
DOT
Non-Bulk Not Regulated (Water based material Non-bulk - PROTECT FROM FREEZING!)
Bulk Not Regulated (Water based material Bulk - PROTECT FROM FREEZING!)
Note N/A
IMDG
Not Regulated
IATA
Not Regulated
State Addendum
Ingredient CAS Number Notes
A Minnesota Hazardous Substance List material
Kaolin 1332.58.7
A Pennsylvania Hazardous Substance List material
Kaolin 1332.58.7
A Florida Toxic Substances List material
Talc (paint) 14807.96.6
A Massachusetts Hazardous Substance List material
Talc (paint) 14807.96.6
A Minnesota Hazardous Substance List material
Talc (paint) 14807.96.6
A Pennsylvania Hazardous Substance List material
Talc (paint) 14807.96.6
A Washington State Permissible Exposure for Air Contaminants material
Talc (paint) 14807.96.6
See current Material Safety Data Sheet.
Biocide 56709.13.8
A Florida Toxic Substances List material
Aluminum Metal 7429.90.5
A Massachusetts Hazardous Substance List material
Aluminum Metal 7429.90.5
A Minnesota Hazardous Substance List material
Aluminum Metal 7429.90.5
A New Jersey RTK Hazardous Substance List material
Aluminum Metal 7429.90.5
A Pennsylvania Hazardous Substance List material
Aluminum Metal 7429.90.5
A Washington State Permissible Exposure for Air Contaminants material
Aluminum Metal 7429.90.5
A Delaware Air Quality Management List material.
Aluminum Metal 7429.90.5
See current Material Safety Data Sheet.
Water 7732.18.5
A Florida Toxic Substances List material
Asphalt 8052.42.4
A Massachusetts Hazardous Substance List material
Asphalt 8052.42.4
A Minnesota Hazardous Substance List material
Asphalt 8052.42.4
A Pennsylvania Hazardous Substance List material
Asphalt 8052.42.4
A Washington State Permissible Exposure for Air Contaminants material
Asphalt 8052.42.4
Asphalt may contain detectable amounts of chemicals known to the State of California to cause cancer or
Asphalt 8052.42.4 reproductive harm.
Henry Company - 909 NORTH SEPULVEDA BLVD., EL SEGUNDO, CA 90245
MSDS HE558
Technical Services - 800-486-1278 Email: techservices@henry.com
www.henry.com
|