Material Safety Data Sheet DynaZone 15-0-10 6S
Product:
May be used to comply with OSHA's Hazard Communication Standard QUICK IDENTIFIER
29CFR 1910. Standard must be consulted for specific requirements. Common Name: Controlled release nitrogen and potassium fertilizer
SECTION 1 - COMPANY INFORMATION
Manufacturer's Name: Chemical Dynamics, Inc. Emergency Telephone Number: 1-800-424-9300
Address: 4206 Business Lane Other Information Call: 1-813-752-4950
City, State, and Zip Plant City, Florida 33566 Date Prepared: 11/5/04
SECTION 2 - HAZARDOUS INGREDIENTS/IDENTITY
OSHA PEL ACGIH TLV EXPOSURE LIMITS CAS NO.
Hazardous Component(s) (chemical & common name(s)
s-Tetrahydrotriazone N/A N/A 7098-14-8
Urea 5 mg/M3 10 mg/M3 57-13-6
Potassium Thiosulfate N/A N/A 10294-66-3
SECTION 3- PHYSICAL & CHEMICAL CHARACTERISTICS
o
Boiling Point: N/A F Specific Gravity: 1.318 Vapor Pressure: N/A
Vapor Pressure: N/A Reactivity in Water: Soluble Melting Point: N/A
Appearance and Odor: Clear liquid with slight bluish tint, may have an amine odor
SECTION 4- FIRE & EXPLOSION DATA
N/A oF
Flash Point: Method Used: N/A
Flammable Limits in Air: N/A LEL Lower: UEL Upper:
Auto-Ignition Temp: N/A Extinguisher Media: Non flammable if involved in fire, can extinguish with dry
chemical; CO2, water spray or foam.
Special Fire Fighting This product is non-flammable, and does not support combustion. If heated to
Procedures: decomposition ammonia and sulfur may be released. Use of SCBA is recommended.
Fire run-off water should be contained to prevent environmental contamination.
Unusual Fire and
Explosion Hazards: If this product is heated to an anhydrous state it could emit ammonia and sulfur
compounds, which are hazardous if inhaled. Exposure to high heat can emit toxic vapors.
SECTION 5- PHYSICAL HAZARDS (REACTIVITY DATA)
Stability: Stable Unstable Conditions to Avoid: Excessive heat
Incompatibility
Materials to Avoid!: Avoid strong acids. Sulfur dioxide can be released when this material comes in
contact with acidic materials. Do not mix with heavy metals such as lead or mercury.
Do not use copper, zinc or bronze in piping, handling, or storage containers.
Avoid strong oxidizers such as nitrates, which can cause explosive mixtures if
allowed to dry out.
Page 2- DynaZone 15-0-10 6S
SECTION 5- PHYSICAL HAZARDS (REACTIVITY DATA)..Continued
Hazardous Decomposition Products: Heating this product will evolve ammonia and quite possibly
sulfur dioxide and carbon dioxide.
Hazardous Polymerization: May Occur: Will Not Occur:
Conditions to Avoid: Extreme Heat.
SECTION 6- HEALTH HAZARDS
ACUTE: Mild skin irritant, conjunctivitis, upset stomach and/or gastrointestinal symptoms are
temporary.
CHRONIC: Prolonged skin contact may result in dermatitis (drying) or eczema (itching)
CARCINOGEN NTP OSHA
LISTED IN: IARC MONOGRAPH X NOT LISTED
ROUTES OF ENTRY AND EMERGENCY FIRST AID PROCEDURES
1. Inhalation: No hazard under normal conditions. If necessary move victim to fresh air. If symptoms
persist call a physician. Administer CPR if necessary.
2. Eyes: Flush eyes with running water for 15 minutes. If redness persists, seek
medical attention.
3. Skin: Remove contaminated clothing, wash with clean water and soap. Put on clean clothes.
4. Ingestion: Give large amounts of water. DO NOT INDUCE VOMITING. Call physician immediately.
SECTION 7- SPECIAL PRECAUTIONS AND SPILL/LEAK PROCEDURES
Precautions to be Taken
Handling and Storage: Store in cool ventilated place away from fire hazards, excessive heat, flammable or
easily oxidizable materials. Do not allow product to dry out.
Other Precautions: Do not allow product to go below 35 degrees. Apply product in open areas. Keep
away from children and pets. Do not contaminate feed, seed or any water sources.
Steps to be taken in
case of Release or Spill: Dike area and maximize recovery. Pump into a tank or absorb with diatomaceous earth
or sand. Sweep up and place into containers for land application at recommended
rates. Prevent entry into sewers or waterways. Clean up at once; do not allow dry
product to come in contact with heat or ignition sources.
Environmental
Precautions: Relatively low toxicity to fish and aquatic organisms. Do not contaminate any waterway,
lakes, streams or estuary by direct application of cleaning of equipment or disposal.
Triple rinse empty containers and offer for recycling or dispose of in an approved landfill.
Consult federal, state and local rules and regulations for proper disposal.
Page 3- DynaZone 15-0-10 6S
SECTION 8- CONTROL AND PROTECTIVE MEASURES
Respiratory Protection: None required if used in open under normal conditions. Respiratory protection may be
required in the event of a spill in an enclosed area. Use SCBA when fighting fires.
Protective Gloves: Impervious gloves from rubber, neoprene or nitrile.
Eye Protection: Side-shielded safety glasses or chemical splash-proof goggles.
Other Protective
Clothing or equipment: Eye wash station with safety shower. Use of a chemically resistant apron may be
required for some activities.
Hygienic Work Practice Bathe and change clothes daily. Wash contaminated clothing separate from other
laundry.
SECTION 9- TRANSPORT AND REGULATORY INFORMATION
MATERIAL IS NOT HAZARDOUS AS DEFINED BY 49 CFR 172.101 BY THE U.S. DEPARTMENT OF TRANSPORTATION
Proper Shipping Name: None
Hazard Class Number: None
Description: None
UN Identification
Number: None
Packing Group: None
DOT Label(s) Required: None
NFPA CODE: Health = 1 Flammability = 0 Reactivity = 0
Toxicity:
Notes: This product is not regulated by EPCRA or any of the provisions of SARA Title III.
|