Material Safety Data Sheet Product: Dyna Flo Liquid Fertilizers
May be used to comply with OSHA's Hazard Communication Standard QUICK IDENTIFIER
29CFR 1910. Standard must be consulted for specific requirements. Common Name: All Dyna Flo Liquid Fertilizers
all fertilizer N-P-K liquid blends
SECTION 1 - COMPANY INFORMATION
Manufacturer's Name: Chemical Dynamics, Inc. Emergency Telephone Number: 1-800-424-9300
Address: 4206 Business Lane Other Information Call: 1-813-752-4950
City, State, and Zip Plant City, Florida 33566 Date Prepared: 3/12/04
SECTION 2 - HAZARDOUS INGREDIENTS/IDENTITY
OSHA PEL ACGIH TLV EXPOSURE LIMITS CAS NO.
Hazardous Component(s) (chemical & common name(s)
Ammonium Calcium Nitrate CaNO3 N/A N/A 15245-12-2
Phosphoric Acid H2PO4 N/A N/A 7664-38-2
Potassium Nitrate KNO3 N/A N/A 7757-79-1
Urea Ammonium Nitrate U-32 N/A N/A 6484-52-2 and 57-13-6
May contain 0-50% Nitrates, which are classified as Oxidizers when pure.
Mixed Fertilizer solutions are generally considered to be non-hazardous.
SECTION 3- PHYSICAL & CHEMICAL CHARACTERISTICS
Boiling Point: >212 F Specific Gravity: 1.23-1.45 Vapor Pressure: N/A
Vapor Pressure: N/A Reactivity in Water: Soluble Melting Point: N/A
Appearance and Odor: Clear to honey colored solutions
SECTION 4- FIRE & EXPLOSION DATA
N/A oF
Flash Point: Method Used: N/A
Flammable Limits in Air: N/A LEL Lower: UEL Upper:
Auto-Ignition Temp: N/A Extinguisher Media: Non flammable if involved in fire, can extinguish with
dry chemical; CO2, water spray or foam.
Special Fire Fighting This product is non-flammable, and does not support combustion. If heated to
Procedures: decomposition the nitrate ion will support combustion and could explode. Use
of self contained breathing apparatus is recommend.
Fire run-off water should be contained to prevent environmental contamination.
Unusual Fire and
Explosion Hazards: If this product is heated to an anhydrous state it will emit nitrates which are
oxidizing agents. Exposure to high heat can emit toxic vapors.
SECTION 5- PHYSICAL HAZARDS (REACTIVITY DATA)
Stability: Stable Unstable Conditions to Avoid: Excessive heat
Incompatibility
Materials to Avoid!: Organic or easily oxidizable matter. Alkalis or caustic liquids.
Do not mix in concentrated form with bases or bleaches.
Page 2- Dyna Flo Liquid Fertilizers
SECTION 5- PHYSICAL HAZARDS (REACTIVITY DATA)..Continued
Hazardous Decomposition Products: Under extreme heat or fire, may liberate hazardous gasses of
oxides of nitrogen and ammonia
Hazardous Polymerization: May Occur: Will Not Occur:
Conditions to Avoid: Extreme Heat.
SECTION 6- HEALTH HAZARDS
ACUTE: Mild skin irritant, conjunctivitis, upset stomach and/or gastrointestinal symptoms
are temporary. Irratation to open cuts or wounds.
CHRONIC: Prolonged skin contact may result in dermatitis (drying) or eczema (itching)
May cause skin irritation and tissue damage.
CARCINOGEN NTP OSHA
LISTED IN: IARC MONOGRAPH X NOT LISTED
ROUTES OF ENTRY AND EMERGENCY FIRST AID PROCEDURES
1. Inhalation: No hazard under normal conditions. If necessary move victim to fresh air.
If symptoms persist, call a physician. Administer CPR if necessary.
2. Eyes: Flush eyes with running water for 15 minutes. If redness persists,
seek medical attention
3. Skin: Remove contaminated clothing, wash with clean water and soap.
Put on clean clothes.
4. Ingestion: Give large amounts of water. DO NOT INDUCE VOMITING.
Call physician immediately.
SECTION 7- SPECIAL PRECAUTIONS AND SPILL/LEAK PROCEDURES
Precautions to be Taken
Handling and Storage: Store in cool ventilated place away from fire hazards, excessive heat, flammable
or easily oxidizable materials. Do not allow product to dry out.
Corrosive to many metals such as mild steel or other galvanized products.
Other Precautions: Do not allow product to go below 35 degrees. Apply product in open areas.
Keep away from children and pets. Do not contaminate feed, seed or
any water sources.
Steps to be taken in
case of Release or Spill: Dike area and maximize recovery. Pump into a tank or absorb with diatomaceous
earth or sand. Sweep up and place into containers for land application at
recommended rates. Prevent entry into sewer or waterways.
Environmental
Precautions: Relatively low toxicity to fish and aquatic organisms. Do not contaminate any
waterway, lake, stream or estuary by direct application of cleaning of equipment
or disposal. Triple rinse containers and offer for recycling or dispose of in an
approved landfill. Consult Federal, state and local regulations for proper disposal.
Page 3- Dyna Flo Liquid Fertilizers
SECTION 8- CONTROL AND PROTECTIVE MEASURES
Respiratory Protection: None required if used in open under normal conditions.
Respiratory protection may be required in the event of a spill in an enclosed area.
Use SCBA when fighting fires.
Protective Gloves: Impervious gloves from rubber or nitrile.
Eye Protection: Side-shielded safety glasses or chemical splash-proof goggles.
Other Protective
Clothing or equipment: Eye wash station with safety shower. Use of a chemically resistant apron may be
required for some activities.
Hygienic Work Practice Bathe and change clothes daily. Wash contaminated clothing separate
from other laundry.
SECTION 9- TRANSPORT AND REGULATORY INFORMATION
MATERIAL IS NOT HAZARDOUS AS DEFINED BY 49 CFR 172.101 BY THE U.S. DEPARTMENT OF TRANSPORTATION
Proper Shipping Name: None
Hazard Class Number: None
Description: None
UN Identification
Number: None
Packing Group: None
DOT Label(s) Required: None
NFPA CODE: Health = 1 Flammability = 0 Reactivity = 0
Toxicity: Oral rat Urea LD50 = 14300 mg/kg.
|