Material Safety Data Sheet
Section 1 - Manufacturer and Product Information
Manufacturer: EPOPLEX, A DIVISION OF STONCOR GROUP, INC.
Mailing Address: 1000 EAST PARK AVENUE
MAPLE SHADE, NJ 08052
Customer Information: (856) 779-7500
24 Hour Emergency Phone: CHEMTREC 1-800-424-9300
Outside US (703) 527-3887
Product Name: EPOPLEX MA50 PART A Revision Date: 06/26/2009
Product Code: 490B Supercedes : 04/02/2009
Preparer: Bowers, Lee
Section 2 - Composition / Information On Ingredients
CAS # OR NJ TRADE CHEMICAL NAME WEIGHT % RANGE
SECRET #
25068-38-6 Reaction product: bisphenol-A-(epichlorhydrin) epoxy resin (number average molec 60-100
14807-96-6 TALC 7-13
546-93-0 Magnesium Carbonate 5-10
Chemical Exposure Guidelines
CAS# OR NJ TRADE SECRET # OSHA PEL ACGIH TLV
25068-38-6
14807-96-6 2.0 mg/m3 2.0 MG/M3
546-93-0 5 mg/m3
Section 3 - Hazards Identification
Emergency Overview: Irritating to skin. May cause sensitization by skin contact. Harmful to aquatic organisms. Prolonged or
repeated exposure increases the risk.
Ingestion: SINGLE DOSE ORAL TOXICITY IS EXTREMELY LOW. NO HAZARDS ANTICIPATED FROM SWALLOWING SMALL
AMOUNTS DURING HANDLING.
Inhalation: VAPORS ARE UNLIKELY DUE TO PHYSICAL PROPERTIES.
Systemic: EXCEPT FOR SKIN SENSITIZATION, REPEATED EXPOSURES ARE NOT ANTICIPATED TO CAUSE ANY
SIGNIFICANT ADVERSE EFFECTS.
* This product contains the following chemicals classified by the International Agency for Research on Cancer (IARC) as 1, 2A, or 2B
carcinogens:
None
Section 4 - First Aid Measures
Eyes: Remove contact lenses. Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. If eye irritation
persists, consult a specialist.
Skin: Use a mild soap if available. If skin irritation persists, call a physician. Wash off immediately with soap and plenty of water
while removing all contaminated clothes and shoes.
Ingestion: Move to fresh air. Consult a physician after significant exposure.
Inhalation: Do NOT induce vomiting. Give small amounts of water to drink. Gently wipe or rinse the inside of the mouth with water.
Never give anything by mouth to an unconscious person.
Section 5 - Fire Fighting Measures
Page 1 of 4
Flash Point: >485F / >251C Lower Explosive Limit, %: N/A
(CC ESTIMATE) Upper Explosive Limit, %: N/A
Extinguishing Media: Carbon Dioxide, Dry Chemical, Foam
Haz. Combustion Products: No Information.
Fire Fighting Instruction: Keep containers and surroundings cool with water spray. Collect contaminated fire extinguishing water
separately. This must not be discharged into drains.
Fire Fighting Equipment: Contains epoxy constituents. See information supplied by the manufacturer. High volume water jet Use
water spray, alcohol-resistant foam, dry chemical or carbon dioxide. In the event of fire, wear self-contained breathing apparatus.
Other Information: No Information.
Section 6 ?Accidental Release Measures
Steps To Be Taken If Material Is Released Or Spilled: Prevent product from entering drains. Do not allow material to contaminate
ground water system. Ensure adequate ventilation. Use personal protective equipment. Prevent further leakage or spillage if safe to
do so. Contain spillage, soak up with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and
transfer to a container for disposal according to local / national regulations (see section 13).
Section 7 - Handling And Storage
Handling: Wear personal protective equipment. Use only in area provided with appropriate exhaust ventilation.
Storage: Store between 5 and 25 ?in a dry, well ventilated place away from sources of heat, ignition and direct sunlight. Keep
C
locked up or in an area accessible only to qualified or authorised persons. Store in original container.
Section 8 - Exposure Controls / Personal Protection
Engineering Controls: Avoid contact with skin, eyes and clothing. Ensure adequate ventilation, especially in confined areas.
Respiratory Protection: No personal respiratory protective equipment normally required.
Skin Protection: Rubber or plastic gloves Rubber or plastic apron Remove and wash contaminated clothing before re-use. Take
note of the information given by the producer concerning permeability and break through times, and of special workplace conditions
(mechanical strain, duration of contact). Long sleeved clothing
Eye Protection: Safety glasses
Other Protective Equipment: No Information.
Section 9 - Physical And Chemical Properties
Physical State: LIQUID
Appearance: WHITE LIQUID
Odor: FAINT EPOXY ODOR
Vapor Pressure: NOT DETERMINED
Vapor Density: NOT DETERMINED
Boiling Range: N.D. - None
Solubility in H2O: NEGLIGIBLE
Specific Gravity: None
Viscosity: LOW
pH: NON-AQUEOUS
(See section 16 for abbreviation legend)
Section 10 - Stability And Reactivity
Stability: Stable under normal conditions. Stable No decomposition if stored and applied as directed.
Conditions To Avoid: Extremes of temperature and direct sunlight.
Incompatibility: Strong oxidizing agents Acids and bases
Hazardous Decomposition Products: Exothermic reaction Alcohols Carbon dioxide (CO2), carbon monoxide (CO), oxides of
nitrogen (NOx), dense black smoke. Thermal decomposition can lead to release of irritating gases and vapours.
Page 2 of 4
Hazardous Polymerization: Hazardous polymerisation does not occur.
Notes: Hazardous decomposition products formed under fire conditions.
Section 11 - Toxicological Information
Product LD50: Not Available.
Product LC50: Not Available.
CAS # OR NJ TRADE SECRET # CHEMICAL NAME LD50 LC50
25068-38-6 Reaction product: bisphenol-A- 11.4g/kg rat, oral >20 ml/kg skin, sensitizer
(epichlorhydrin) epoxy resin (number
average molec
14807-96-6 TALC
546-93-0 Magnesium Carbonate
Section 12 - Ecological Information
Movement & Partitioning: No Information.
Degradation & Transformation: No Information.
Ecotoxicology: No Information.
Section 13 - Disposal Information
Disposal Information: Dispose of wastes in an approved waste disposal facility. If recycling is not practicable, dispose of in
compliance with local regulations. Empty containers should be taken to an approved waste handling site for recycling or disposal.
Section 14 - Transportation Information
DOT Proper Shipping Name: None
DOT Technical Name: None
DOT Hazard Class: NONE
Hazard Subclass: NONE
DOT UN/NA Number: None
Packing Group: None
Resp. Guide Page: None
Section 15 - Regulatory Information
CERCLA ?SARA Hazard Category
This product has been reviewed according to the EPA `Hazard Categories' promulgated under Sections 311and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to meet the
following categories:
None
SARA Section 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the Superfund
Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
None
Toxic Substances Control Act:
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from the
United States:
None
Clean Air Act:
EPA Coating Category: NOT APPLICABLE
Page 3 of 4
EPA VOC Content Limit (g/l)*: None
Product VOC Content (g/l)*: None
Thinning Recommendations: None
Application Recommendations:
* Grams of VOC per liter of coating product as applied (mixture of Part A and Part B) per EPA Method 24.
U.S. State Regulations: As follows ?br>
New Jersey Right-to-Know:
The following materials are non-hazardous, but are among the top five components in this product.
CAS # OR NJ TRADE SECRET # CHEMICAL NAME
13463-67-7 TITANIUM DIOXIDE
Pennsylvania Right-to-Know:
The following non-hazardous ingredients are present in the product at greater than 3%.
CAS # OR J TRADE SECRET # CHEMICAL NAME
13463-67-7 TITANIUM DIOXIDE
California Proposition 65:
Warning: The following ingredients present in the product are known to the state of California to cause Cancer:
None
Warning: The following ingredients present in the product are known to the state of California to cause birth defects, or other
reproductive hazards.
None
International Regulations:
CANADIAN WHMIS:
This MSDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16 headings.
* CANADIAN DSL:
All chemical ingredients included on inventory
* European Economic Community (EEC) EINECS Master Inventory:
All chemical ingredients included on inventory
Section 16 - Other Information
When using, do not eat, drink or smoke. Wash hands before breaks and at the end of workday.
HMIS Ratings:
Health: 2 Flammability: 1 Reactivity: 1 Personal Protection: C
REASON FOR REVISION: None
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
Information presented herein has been compiled from sources considered to be dependable and is accurate and reliable to the best
of our knowledge and belief but is not guaranteed to be so. Nothing herein is to be construed as recommending any practice or any
product in violation of any patent or in violation of any law or regulation. It is the user's responsibility to determine for himself the
suitability of any material for a specific purpose and to adopt such safety precautions as may be necessary. We make no warranty as
to the results to be obtained in using any material and, since conditions of use are not under our control, we must necessarily
disclaim all liability with the respect to the use of any material supplied by us.
Page 4 of 4
|