Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: +01-813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: BULLSEYE WINDSHIELD REPAIR KIT .17OZ SYR
Item No: 16067
Product Type: UV Adhesive
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL
2-HYDROXYETHYL 30-50 Not listed Not listed
METHACRYLATE
868-77-9
POLYURETHANE OLIGIMER 20-40 Not listed Not listed
*
ISOBORNYL METHACRYLATE <10 Not listed Not listed
7534-94-3
10 ppm; 30 mg/m3
ACRYLIC ACID <5 2 ppm
79-10-7
PHOTO INITIATOR <5 Not listed Not listed
947-19-3
TRIETHYLENE GLYCOL <2 Not listed Not listed
DIMETHACRYLATE
109-16-0
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation. Excessive inhalation causes headache, dizziness, nausea,
Toxicity:
and incoordination.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. May cause redness to eyes and irritation to nasal
Signs and Symptoms of Exposure:
passages. May cause skin irritation.
Component Weight% NTP ACGIH Carcinogens IARC
ACRYLIC ACID <5 A4 - Not Classifiable Group 3 Monograph 71, 1999;
79-10-7 as a Human Supplement 7, 1987;
Carcinogen Monograph 19, 1979
Acrylic acid: Upper respiratory and lung diseases, dermatitis.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes. If skin
Skin Contact:
irritation persists, call a physician.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200?F PMCC
Flash Point 癋(C?:
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Oxides of carbon
Hazardous Products of Combustion:
None.
Unusual Fire/Explosion Hazards:
1 of 3
Product Name: BULLSEYE WINDSHIELD REPAIR KIT Item No: 16067
.17OZ SYR
5. FIRE FIGHTING MEASURES
2.0% Acrylic acid
Lower Explosive Limit:
8.0% Acrylic acid
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until disposal.
Spill Procedures:
7. HANDLING AND STORAGE
Store below 100癋.
Storage:
Do not inhale vapors. Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this product.
An approved organic vapor respirator should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Amber liquid
Appearance:
Mild
Odor:
Not determined
Boiling Point:
Does not apply
pH:
Slight
Solubility in Water:
1.05
Specific Gravity:
<3%
VOC(Wt.%):
6 mm Hg @ 30癈
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur.
Hazardous Polymerization:
Strong oxidizers, Amines, Acids, Peroxides
Incompatabilities:
Heat.
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations..
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Ground Transport (DOT)
Not Regulated
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
2 of 3
Product Name: BULLSEYE WINDSHIELD REPAIR KIT Item No: 16067
.17OZ SYR
IMDG
Not regulated
Proper Shipping:
None
Hazard Class:
None
UN Number:
None
Marine Pollutant:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
ACRYLIC ACID
California Proposition 65: No California Prop 65 chemicals are known to be present.
TSCA Inventory Status: All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILILTY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: August 14, 2009
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 4
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|