SECTION II: HAZARDOUS INGREDIENTS
(Listed when present at 1% or greater, carcinogens at 0.1% or greater) All component chemicals are listed or exempted from listing
on the "TSCA Inventory" of chemical substances maintained by the U.S. Environmental Protection Agency.
Table Z-1-A
CAS
NTP, IARC
TWA STEL CEILING
Registry
or OSHA
3 3 3
mg/m mg/m mg/m
Chemical Name(s) %Wt No.
Carcinogen
Triethanolamine 1-5 102-71-6 5 (ACGIH) Not Established Not Established No
Benzotriazole 1-5 95-14-7 15 (dust) Not Established Not Established No
Tolyltriazole 1-5 29385-43-1 Not Established Not Established Not Established No
Potassium hydroxide 1-5 1310-58-3 Not Established Not Established 2 (NIOSH) No
Polyoxyalkyleneamine 1-5 65605-36-9 Not Established Not Established Not Established No
Dodecanedioic acid 1-5 693-23-2 Not Established Not Established Not Established No
Undecanedioic acid 1-5 1852-04-6 Not Established Not Established Not Established No
SECTION III: PHYSICAL DATA
Boiling Point: > 212 癋 Vapor Pressure: Unknown
Vapor Density (AIR = 1): Unknown Solubility in Water: Complete
pH: 5%: 8.9 - 9.4 Specific Gravity (H O=1): 1.04
2
SECTION IV: FIRE & EXPLOSIVE HAZARD DATA
Flash Point: > 212癋 Method Used: NA
Flammable Limits: Not Established Flame Extension: N/A
Extinguishing Media: Product does not support combustion. Use extinguishing media appropriate for surrounding fire.
Special Fire Fighting Procedures: Wear NIOSH approved self-contained breathing apparatus and protective clothing. Cool fire-exposed
containers with water spray.
Unusual Fire & Explosive Hazards: Combustion products are toxic.
SECTION V: HEALTH HAZARD DATA
Threshold Limit Value: Not Established Primary Routes of Entry: Inhalation, Skin Contact, Eyes and
Oral
Effects of Overexposure- Causes eye and skin irritation : Symptoms may include pain, redness and tearing.
Conditions to Avoid: May be harmful if swallowed : Symptoms may include stomach or intestinal upset.
Inhalation of product mist may cause respiratory irritation: Symptoms may include irritation to nose,
throat and airways. Contains triethanolamine which may cause skin sensitization with repeated contact.
Repeated exposure to triethanolamine may cause liver and kidney damage.
Avoid contact with eyes , skin or clothing . Do not taste or swallow . Avoid breathing product mist . Wash
thoroughly after handling .
Conditions Aggravated by Use: Use of this product may aggravate preexisting skin; eye and respiratory disorders including asthma and
dermatitis.
Emergency & First Aid Procedures :
Eyes: Flush eyes with water for at least 15 minutes. remove contact lenses. Get medical attention if irritation
persists.
Skin: Remove contaminated clothing. Wash skin thoroughly with soap and water. Get medical attention if
irritation persists. Wash contaminated clothing before reuse.
Ingestion: Do not induce vomiting. Drink one or two glasses of water to dilute product. Get immediate medical
attention. Do not give anything by mouth to an unconscious person.
Inhalation: Move person to fresh air. Get medical attention if irritation persists.
SECTION VI: REACTIVITY DATA
Stability: Stable Incompatible Materials: Strong oxidizing agents
Hazardous Decomposition Products: CO, CO2, sulfur oxides if burned Hazardous Polymerization: Will Not Occur
SECTION VII: SPILL OR LEAK PROCEDURES
Steps to be Taken in Case
Material is Released or Spilled: Dike and contain spill with inert material (sand, earth, commercial absorbent, etc.) and transfer to
containers for disposal. Keep spill out of storm sewers and waterways.
Waste Disposal Method: Consult an expert on disposal of recovered material and ensure conformity with federal, state and local
regulations.
SECTION VIII: SPECIAL PROTECTION INFORMATION
Respiratory Protection: Not normally required when adequate ventilation is provided. However, if exposure limits are exceeded
(see Section II) or if respiratory irritation occurs, use of a NIOSH approved respirator appropriate for the
conditions of use and chemicals in Section II should be considered.
Ventilation: Local exhaust: Follow ACGIH Industrial ventilation recommendations. Mechanical (Recommended)-
Provide ventilation suitable for type of building structure and work area.
Protective Gloves(Specify Type): Rubber or other impervious gloves are recommended when handing undiluted product.
Eye Protection(Specify Type): Splash goggles are recommended to prevent eye contact.
Other Protective Equipment: For further guidance see 29 CFR 1910.132-138.
SECTION IX: SPECIAL PRECAUTIONS
Precautions; Handling & Storing: Store in a cool dry place away from strong oxidizers and extreme heat. Keep containers sealed and stored
upright when not in use.
Other Precautions: Keep out of reach of children.
?SCC 09/22/2008 Name: Title:
Ronald T. Cook Manager, Regulatory Affairs
Effective Date: 09/22/2008 Supercedes: 11/30/2005
THE CARBIDE GRINDER
Ref: 29 CFR 1910.1200 (OSHA) Changes: Review
This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty, express or implied, as
to the accuracy of the information contained herein. Actual conditions of use and handling are beyond sellers control. User is responsible to
evaluate all available information when using product for any particular use and to comply with all Federal, State and Local laws and regulations.