Rosin flux Remover (640-3324) Faxback Doc. # 2970
TECH SPRAY, INC. MATERIAL SAFETY DATA SHEET
P O BOX 949 RS 64-3324
88 NORTH HUGHES
AMARILLO TX 79105
(806) 372-8523
Radio Shack Flux Stripper
Hazardous Description: (For Shipping Purposes Only)
Compressed Gas N.O.S. Non-Flammable Gas UN1956
Hazard Rating Health: 3 Fire: 1 Reactivity: 1
0-Least 1-Slight 2-Moderate 3-High 4-Extreme
* * * * * * * I--HAZARDOUS COMPONENTS * * * * * * *
-------------------------------------------------------------------------
Ingredients | CAS No. | % | Hazard
-------------------------------------------------------------------------
Dichlorofluoroethane (141b) | 1717-00-6 | 50-70 | See Section IX.
Isopropyl Alcohol | 67-63-0 | 10-30 | OSHA PEL 400ppm
Ethanol (Ethyl Alcohol) | 64-17-5 | 5-10 | OSHA PEL 1000ppm
Acetone | 67-64-1 | 1-5 | OSHA PEL 1000ppm
| | |
Chlorodifluoromethane | 75-45-6 | 15-20 | ACGIH TLV 1000ppm
| | |
Carbon Dioxide | 124-38-9 | 2 | OSHA PEL 10,000ppm
| | | ACGIH TLV 5000ppm
| | |
| | |
| | |
| | |
| | |
| | |
* * * * * * * II--PHYSICAL DATA * * * * * * *
-------------------------------------------------------------------------
Boiling Point .......... 61 degrees C/ 142 degrees F pH ........ NIF
Density ................ 1.05 % Volatile ................ 100
Solubility in Water .... 33% % Solids .................. 0
Vapor Density (Air=1) .. >1 Evaporation Rate (H2O=1) .. NIF
Appearance: Clear, mobile liquid with mildly sweet odor.
* * * * * * * III--FIRE AND EXPLOSION HAZARD DATA * * * * * * *
-------------------------------------------------------------------------
Flash Point: Greater than boiling point Explosion Limits
LEL: NA UEL: NA
Extinguishing Media: Water, foam, dry chemical, carbon dioxide.
Special Firefighting Procedures:
Firefighters should wear self-contained, positive-pressure breathing
apparatus and avoid skin contact. Concentrated vapors can be ignited
by a high intensity ignition source.
Unusual Fire and Explosion Hazards:
Aerosol cans may erupt with force at temperatures above 120 degrees F.
Page 1 of 3
TECH SPRAY, INC. MATERIAL SAFETY DATA SHEET
P O BOX 949 RS 64-3324
88 NORTH HUGHES
AMARILLO TX 79105
(806) 372-8523
* * * * * * * IV--HEALTH HAZARD DATA * * * * * * *
-------------------------------------------------------------------------
Effects of Overexposure
INHALATION: Major route of exposure. Vapor is heavier than air and
can cause suffocation by reducing the available oxygen for
breathing. Inhalation of high concentrations can cause
light-headedness, giddiness, shortness of breath, and/or
confusion, and may lead to narcosis, cardiac
irregularities, unconsciousness, or even death.
EYES: There is a possibility of permanant eye damage due to corneal
burns from alcohol in product.
SKIN: Prolonged or repeated skin contact can cause irritation,
defatting of tissues, and dermatitis. Absorption through
intact skin is possible if contact with liquid is prolonged.
INGESTION: Ethanol is denatured with isopropanol and methyl-ethyl-
ketone. Alcohols affect the central nervous system.
Acute and chronic liver diseases and rhythm disorders of the heart can
be aggravated by overexposure to this product.
-------------------------------------------------------------------------
Emergency and First Aid Procedures
INHALATION: Remove to fresh air. If breathing has stopped, administer
artificial respiration. Seek medical attention.
EYES: Flush eyes for at least fifteen minutes with clear water. If
irritation persists, seek medical attention.
SKIN: Remove contaminated clothing and shoes. Wash exposed area with
soap and water. Wash contaminated clothing before reuse.
INGESTION: INDUCE VOMITING with tepid salt water or syrup of IPECAC.
Seek medical attention.
NOTE: Adrenalin and similar cardiac stimulants should NOT be used to
treat effects of overexposure to this product. See section I.
* * * * * * * V--REACTIVITY DATA * * * * * * *
-------------------------------------------------------------------------
Stability: STABLE Conditions to Avoid: Contact with open
flame, heat.
Incompatibility (materials to avoid):
Strong bases, oxidizers, reducing agents, aluminum, and other metals.
Hazardous Decomposition Products:
Hydrogen chloride, phosgene, chlorine, carbon dioxide, and carbon
monoxide.
Hazardous Polymerization: WILL NOT OCCUR
Conditions to Avoid: None
Page 2 of 3
TECH SPRAY, INC. MATERIAL SAFETY DATA SHEET
P O BOX 949 RS 64-3324
88 NORTH HUGHES
AMARILLO TX 79105
(806) 372-8523
* * * * * * * VI--SPILL OR LEAK PROCEDURES * * * * * * *
-------------------------------------------------------------------------
Evacuate area, ventilate, and avoid breathing vapors. Dike area to
contain spill. Clean up area by mopping or with s suitable absorbent
material and place in closed containers for disposal. Avoid
contamination of ground and surface waters. Do NOT flush to sewer.
If spill is indoors, shut off air conditioning and heating systems to
prevent contaminating of building.
* * * * * * * VII--WASTE DISPOSAL METHODS * * * * * * *
-------------------------------------------------------------------------
Material may be disposed of by a licensed reclaimer or incineration
facility. Consult local, state, and federal disposal authorities for
approved procedures.
Do not incinerate or destroy aerosol cans.
* * * * * * * VIII--EMPLOYEE PROTECTION * * * * * * *
-------------------------------------------------------------------------
Respiratory Protection:
Use NIOSH-approved organic vapor mask if vapor levels exceed TLV.
Ventilation: Do not use in closed space. Ventilation required.
Hands: Solvent-resistant gloves such as Viton(R)*, Polyvinyl alcohol.
Eyes: Wear splash-proof safety goggles or glasses.
Special Precautions:
Keep aerosol cans in cool place out of direct sunlight. Keep this and
all chemicals out of reach of children. This product for industrial
use only.
* * * * * * * IX--OTHER INFORMATION * * * * * * *
-------------------------------------------------------------------------
Note: Toxicity tests have not been completed on dichlorofluoroethane
(141b). Thus, a TLV cannot be assigned. A working TLV of 350ppm has
been adopted until the tests are completed.
* Viton(R) is a registered trademark of DuPont Dow Elastomers
-------------------------------------------------------------------------
Prepared By: J. Witcher Date: 6-7-91
NL=Not Listed NIF=No Information Found NE=Not Established
NA=Not Applicable
Page 3 of 3
|