MATERIAL SAFETY DATA SHEET
TM
FOR CHEMICAL
EMERGENCY
CHROMATE INDUSTRIAL CORPORATION? Call ChemTrec day/night:
5250-A Naiman Parkway, Solon, OH 44139 ?888-567-2206 ?www.chromate.com 1-800-424-9300
SECTION 1 ?PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: CONTACT CLEANER E.S. DATE PREPARED: APRIL 27, 2009
PART NUMBER: 74180
CHROMATE INDUSTRIAL CORPORATION
PRODUCT TYPE: AEROSOL CLEANER 5250-A Naiman Parkway, Solon, OH 44139 ?(888) 567-2206
SECTION 2 ?COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME % BY WEIGHT OSHA PEL ACGIH TLV STEL CAS #
1,1-DICHLORO- 93 N/E N/E N/D 1717-00-6
1-FLUOROETHANE
METHANOL 4 200 ppm (skin) 200 ppm (skin) 250 ppm (skin) 67-56-1
CARBON DIOxIDE 3 5000 ppm 5000 ppm N/D 124-38-9
* An asterisk (*) indicates the toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and
Community Right-to-Know Act of 1986 and 40 CFR 372.
SECTION 3 ?HAZARDS IDENTIFICATION
NFPA RATING: HEALTH: 3 FLAMMABILITY: 0 REACTIVITY: 0 SPECIFIC: 0
HMIS RATING: HEALTH: 3 FLAMMABILITY: 0 REACTIVITY: 0 PERSONAL PROTECTION: B
PRIMARY ROUTES OF ENTRY: INHALATION, SkIN, EyES
EFFECTS OF OVEREXPOSURE:
INHALATION: May cause nervous system depression. Extreme overexposure may result in unconsciousness and possibly death.
Headache, dizziness, nausea and loss of coordination are indications of excessive exposure to vapors or spray mists.
SKIN CONTACT: Redness and itching or burning sensation may indicate excessive skin exposure.
EYE CONTACT: Irritation. Redness and itching or burning sensation may indicate excessive eye exposure.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: None generally recognized.
CHRONIC HEALTH HAZARDS: Prolonged overexposure to solvent ingredients in Section II may cause adverse effects to the liver and
urinary systems. Reports have associated repeated and prolonged overexposure to solvents with permanent
brain and nervous system damage.
SECTION 4 ?FIRST AID MEASURES
EMERGENCY FIRST AID PROCEDURES:
INHALATION: If affected, remove from exposure. Restore breathing. keep warm and quiet.
INGESTION: Get medical attention.
SKIN CONTACT: Wash affected area thoroughly with soap and water. Remove contaminated clothing and launder before re-use.
EYE CONTACT: Flush eyes with large amounts of water for 15 minutes. Get medical attention.
SECTION 5 ?FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USE): N/A FLAMMABLE LIMITS: LEL: N/A UEL: N/A
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, foam.
FIRE FIGHTING PROCEDURES: Full protective equipment including self-contained breathing apparatus should be used. Water spray may be
ineffective. If water is used, fog nozzles are preferrable. Water may be used to cool closed containers to
prevent pressure build-up and possible auto-ignition or explosion when exposed to extreme heat.
UNUSUAL AND EXPLOSION HAZARDS: Isolate from heat, electrical equipment, sparks and open flame. Closed containers may explode
(due to build-up of pressure) when exposed to extreme heat. Application to hot surfaces requires
special precautions. During emergency conditions overexposure to decomposition products may
cause a health hazard. Symptoms may not be immediately apparent. Obtain medical attention.
N/A -- NOT APPLICABLE N/D -- NOT DETERMINED N/E -- NONE ESTABLISHED N/R -- NOT REGULATED
N/L -- NOT LISTED
Page 1 of 3 REV 04/27/2009 BJM
RED LION RESEARCH-CHROMATE INDUSTRIAL CORPORATION CONTACT CLEANER E.S. P/N 74180
SECTION 6 ?ACCIDENTAL RELEASE MEASURES
SPILLS OR LEAKS: Remove all sources of ignition. Ventilate and remove with inert absorbent.
SECTION 7 ?HANDLING AND STORAGE
SPECIAL PRECAUTIONS: Keep away from heat, sparks or open flame. Vapors will accumulate readily and may ignite explosively. During
use and until all vapors are gone: Keep area ventilated ?Do not smoke ?Extinguish all flames, pilot lights and
heaters ?Turn off stoves, electric tools and appliances, and any other sources of ignition. Consult NFPA Code.
Use approved bonding and grounding procedures. Contents under pressure. Do not puncture, incinerate or
expose to temperature above 120篎. Heat from sunlight, radiators, stoves, hot water and other heat sources
could cause container to burst. Do not take internally. keep out of the reach of children. Intentional misuse by
deliberately concentrating and inhaling the contents may be harmful or fatal.
SECTION 8 ?EXPOSURE CONTROLS / PERSONAL PROTECTION
PRECAUTIONS TO BE TAKEN IN USE: Use only with adequate ventilation. Avoid breathing vapor and spray mist. Avoid contact with skin
and eyes. Wash hands after using.
RESPIRATORY PROTECTION: If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted
organic vapor/particular respirator approved by NIOSH/MSHA for protection against materials in Section II.
EYE PROTECTION: Wear safety spectacles with unperforated sideshields.
OTHER EQUIPMENT: None required for normal application of aerosol products where minimal skin contact is expected. For long or
repeated contact, wear chemical resistant gloves.
EXPOSURE GUIDELINES: Local exhaust preferable. General exhaust accceptable if the exposure to materials in Section II is maintained
below applicable exposure limits. Refer to OSHA Standards 1910.94, 1910.107, 1910.108.
SECTION 9 ?PHYSICAL / CHEMICAL PROPERTIES
BOILING POINT: <0篎 to 150篎 PRODUCT WEIGHT: 10.02 lb./gal.
VAPOR PRESSURE PSIG at 70篎: N/D SPECIFIC GRAVITY (H2O = 1): 1.21
VAPOR DENSITY (AIR = 1): Heavier than air MELTING POINT: N/A pH: N/A
SOLUBILITY IN WATER: N/A EVAPORATION RATE (BUTYL ACETATE = 1): Faster than ether
PERCENT VOLATILE BY VOLUME: 100% VOLATILE WEIGHT: 3.88% (less Federally Exempt Solvents)
APPEARANCE AND ODOR: Clear, Solvent FORM: Liquid VOLATILE COMPONENTS: N/D
SECTION 10 ?STABILITY AND REACTIVITY
STABILITY: Stable
CONDITIONS TO AVOID: None known.
HAZARDOUS POLYMERIZATION: Will not occur.
INCOMPATIBILITY (MATERIALS TO AVOID): None known.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: By fire: carbon dioxide, carbon monoxide.
N/A -- NOT APPLICABLE N/D -- NOT DETERMINED N/E -- NONE ESTABLISHED N/R -- NOT REGULATED
N/L -- NOT LISTED
Page 2 of 3 REV 04/27/2009 BJM
RED LION RESEARCH-CHROMATE INDUSTRIAL CORPORATION CONTACT CLEANER E.S. P/N 74180
SECTION 11 ?TOXICOLOGICAL INFORMATION
EYE: No data available.
SKIN: No data available.
INGESTION: No data available.
INHALATION: No data available.
SUBCHRONIC: No data available.
CHRONIC CARCINOGENICITY
NTP: N/L IARC MONOGRAPH: N/L OSHA REGULATED: N/R
TERATOLOGY: No data available.
REPRODUCTION: No data available.
MUTAGENICITY: No data available
SECTION 12 ?ECOLOGICAL INFORMATION
ECOTOXICOLOGICAL INFORMATION: No data available.
CHEMICAL FATE INFORMATION: No data available.
SECTION 13 ?DISPOSAL CONSIDERATIONS
RCRA HAZARD CLASS: No data available.
WASTE DISPOSAL METHOD: Waste from this product may be hazardous as defined under the Resource Conservation and Recovery Act
(RCRA) 40 CFR 261. Waste must be tested for ignitability to determine the applicable EPA hazardous waste
numbers. Do not incinerate. Depressurize container. Dispose of in accordance with Federal, State and Local
regulations regarding pollution.
SECTION 14 璗RANSPORT INFORMATION
TRANSPORTATION REQUIREMENTS (49CFR172-101)
D.O.T. CLASSIFICATION: Consumer Commodity ORM-D D.O.T. SHIPPING NAME: None
SECTION 15 璕EGULATORY INFORMATION
EXPOSURE LIMITS: No data available.
SECTION 16 璒THER INFORMATION
The information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy
of these data or the results to be obtained from the use thereof. Vendor assumes no responsibility for injury to vendee or third persons
proximately caused by the material if reasonable safety procedures are not adhered to as stipulated in this MSDS. Additionally, vendor
assumes no responsibility for injury to vendee or third persons proximately caused by abnormal use of the material even if reasonable safety
procedures are followed. Furthermore, vendee assumes the risk in his use of the material.
N/A -- NOT APPLICABLE N/D -- NOT DETERMINED N/E -- NONE ESTABLISHED N/R -- NOT REGULATED
N/L -- NOT LISTED
Page 3 of 3 REV 04/27/2009 BJM
|