MATERIAL SAFETY DATA SHEET SECTION V - HEALTH HAZARD DATA
Cortec, Spray Technologies Division EMERGENCY AND FIRST AID PROCEDURES:
1300 South River Street Eye Contact: Flush eyes with water for at least 15 minutes.
Spooner, WI 54801 Consult a physician. Skin Contact: Wash affected area with
PHONE: 715-635-8711 TOLL FREE 1-800-826-6791 soap and water. If irritation develops or persists, consult a
FAX: 715-635-2200 physician. Inhalation: Remove victim to fresh air,
EMERGENCY PHONE NO.: (FOR SPILL, LEAK, FIRE, administer oxygen if necessary. If victim has stopped
EXPOSURE OR ACCIDENT): 1-800-535-5053 breathing begin CPR, get immediate medical attention.
Ingestion: If material is swallowed, consult a physician
* * * * * * * * CIRCUIT WASH 11169, 11170, 11171 * * * * * * immediately. DO NOT induce vomiting unless physician
** directed. If spontaneous vomiting occurs, keep victim's
(Previously AERO CIRCUIT WASH 11169, 11170, 11171) head below hips to prevent aspiration of vomitus into lungs.
MEDICAL CONDITIONS PRONE TO AGGRAVATION BY
SECTION I - PRODUCT IDENTIFICATION EXPOSURE: Cardiovascular disease, pre-existing skin
PRODUCT NAME: Circuit Wash (aerosol) conditions
PRODUCT DESCRIPTION: A safe, non-flammable, non-toxic PRIMARY ROUTES OF ENTRY: Inhalation, skin and eye
cleaning solvent of high dielectric strength. Quick drying contact.
time, residue-free, cleans all types of electronic equipment. HEALTH HAZARDS (acute and chronic) / EFFECTS OF
Tested safe for most plastics. OVEREXPOSURE: Excessive inhalation of high vapor
RESTRICTIONS: Commercial / industrial use only concentrations may cause dizziness, weakness, fatigue,
nausea, headache, unconsciousness. Extreme inhalation
SECTION II - HAZARDOUS INGREDIENTS overexposure may cause asphyxiation.
INGREDIENT CAS# OCCUPATIONAL
NAME(S) EXPOSURE LIMITS SECTION VI - REACTIVITY DATA
TLV OR PEL ORAL STABILITY: Stable under normal use and storage conditions.
LD-50 HAZARDOUS POLYMERIZATION: Will not occur.
1,1-Dichloro- 1717-00-6 500 ppm 5 gm / kg HAZARDOUS DECOMPOSITION PRODUCTS (under fire
fluoroethane (See below *) (rat) conditions): Hydrogen fluoride, perfluoroisobutylene, other
toxic and corrosive gases.
Methyl Nona- 163702- 600 ppm 5 g/kg (rat) INCOMPATIBILITY: Avoid alkali or alkaline earth metals,
Fluorobuty- 07-6 (See below**) finely divided reactive metals.
ether CONDITIONS TO AVOID: Avoid contact with heat, flame,
high-intensity energy sources.
Methyl 163702- 600 ppm 5 g/kg (rat)
nonafluoroiso- 08-7 (See below**) SECTION VII - SPILL OR LEAK PROCEDURES
Butylether STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED
OR SPILLED: Remove ignition / combustion sources,
Carbon Dioxide 124-38-9 5000 ppm N.E. ventilate area. Take up spilled material on an inert,
absorbant material and place into a DOT approved closed-
* Recommended Workplace Environmental Exposure Level top waste container for disposal. Prevent spilled material
(WEEL) as established by American Industrial Hygiene from entering sewers or drains.
Association WASTE DISPOSAL: Comply with all existing Federal, State
** Minnesota Mining and Manufacturing Company (3-M) and Local environmental regulations. Waste or unwanted
Medical Department developed exposure guideline product may be reclaimed or incinerated by permitted
Carcinogenic: OSHA = no NTP = no IARC = no facilities.
SECTION III - PHYSICAL DATA SECTION VIII - SAFE HANDLING AND USE INFORMATION
APPEARANCE: Transparent liquid, no color RESPIRATORY PROTECTION: Not normally required;
ODOR: Slightly sweet, ethereal odor mechanical (general) ventilation is generally adequate. Wear
BOILING POINT: 90 degrees F. (32.22 degrees C.) a NIOSH approved organic vapor respirator in nuisance璴evel
VAPOR DENSITY (Air = 1): >1 vapor concentrations, a positive-pressure, air-supplied
VAPOR PRESSURE: 4380 mmHg respirator in high vapor concentrations or oxygen-deficient
SOLUBILITY IN WATER: Nil atmospheres.
SPECIFIC GRAVITY: 1.40 PROTECTIVE GLOVES: Chemical resistant rubber or plastic
EVAPORATION RATE (Ether = 1): >1 EYE PROTECTION: Safety glasses, splash goggles, face
shield
SECTION IV - FIRE AND EXPLOSION DATA OTHER PROTECTIVE EQUIPMENT: Eye wash station.
HMIS RATING: Health ?1, Fire ?0, Reactivity - 1
FLASH POINT : Non-flammable SECTION IX - SPECIAL PRECAUTIONS AND STORAGE
FLAMMABLE LIMITS: LEL: N.A. UEL: DATA
N.A. PRECAUTIONS TO BE TAKEN IN HANDLING: Avoid eye and
EXTINGUISHING MEDIA: Dry chemical, CO2 skin contact with liquid. Avoid excessive inhalation of
UNUSUAL FIRE AND EXPLOSION HAZARDS: Contents vapors. Use in a well-ventilated environment. Intentional
decompose to produce irritating, toxic and corrosive gases. inhalation of contents is harmful and may be fatal.
Heated containers may become over-pressurized and fail PRECAUTIONS TO BE TAKEN IN STORING: Store
explosively. containers below 120篎 (48篊), away from heat sources,
SPECIAL FIRE FIGHTING PROCEDURES: Fire fighters open flame, out of direct sunlight.
should wear self-contained breathing apparatus and
protective clothing. Cool fire-exposed containers with water SECTION X ?SHIPPING DATA
fog.
(continued on page 2)
Page 2
Circuit Wash 11169, 11170, 11171
U.N/N.A. NUMBER: UN1950
DOT/IATE SHIPPING NAME: Aerosols, non-flammable, (each
not exceeding 1L capacity)
DOT/IATA HAZARD CLASS: 2.2
DOT REQUIRED LABELS: 2, Non-flammable gas (air
shipment only)
DOT EXCEPTION: See code 49 section 172.101, column
(8A). Section 173.306(h) permits "limited quantity" materials
(inner packagings which do not exceed 1L capacity / 61
cubic inches and for which internal pressures do not exceed
180 psig at 130 degrees F.) meeting section 171.8 definition
of "consumer commodity" to be renamed "Consumer
commodity" and reclassed as ORM-D when shipped via
ground mode, domestically.
IMDG SHIPPING NAME: Aerosols, non-flammable, (each
less than 1L capacity)
FREIGHT CLASS: NMFC 48580, Sub 3
LTL: 55 TL: 35
MW: 36
T.S.C.A. STATUS: All components listed
PREPARED BY: Roger Hanson
DATE PREPARED: 07-21-00 SUPERSEDES: 01-26-
00
DISCLAIMER: This information is furnished without warranty,
expressed, or implied, except that it is accurate to the best
knowledge of Cortec, Spray Technologies Division. The data
on this sheet relates only to the specific material designated
herein. Cortec, Spray Technologies Division assumes no
legal responsibility for use or reliance upon this data.
N.E. = NOT ESTABLISHED N.A. = NOT APPLICABLE
|