MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens A/C Flush (Solvent Based)
MSDS NO. 6544
Revision Date: 10/29/2009
Date Printed 10/29/2009
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Trade Name: Johnsens A/C Flush (Solvent Based)
Synonyms: None
Emergency Telephone (24 hr.): CHEMTREC 1-800-424-9300
Supplier: Technical Chemical Company, P.O. Box 139, Cleburne, Texas 76033
2. COMPOSITION/INFORMATION ON INGREDIENTS
Weight % OSHA TWA OSHA STEL OSHA SKIN
Component
72-77 Not Listed Not Listed Not Listed
Heptane
142-82-5
20-30 Not Listed Not Listed Not Listed
Isopropyl Alcohol
67-63-0
Weight % OSHA Z PEL OSHA Z TWA OSHA Z Ceiling
Component
2000 mg/m3 500 ppm 1600 mg/m3 400 ppm
72-77 Not Listed
Heptane
142-82-5
980 mg/m3 400 ppm 980 mg/m3 400 ppm
20-30 Not Listed
Isopropyl Alcohol
67-63-0
ACGIH TLV TWA ACGIH TLV STEL ACGIH TLV Ceiling
Component
400 ppm 500 ppm Not Listed
Heptane
142-82-5
200 ppm 400 ppm Not Listed
Isopropyl Alcohol
67-63-0
3. HAZARDS IDENTIFICATION
Emergency Overview: Danger: Extremely flammable. May be fatal if swallowed. Harmful or fatal if liquid is aspirated into lungs.
Causes severe eye irritation. May cause severe skin irritation. This material is readily absorbed through the
skin in liquid or vapor phase. Gross inhalation overexposure may cause: Central nervous system
depression with dizziness, confusion, incoordination, drowsiness or unconsciousness or death.
HMIS Classification: Health: *2 Flammability: 3 Physical Hazard: 0
NFPA Rating: Health: 1 Flammability: 3 Reactivity: 0
4. FIRST AID MEASURES
Eye Contact: In case of contact, or suspected contact, immediately flush eyes with plenty of water for at least 15 minutes
and get medical attention immediately after flushing.
Ingestion: DO NOT INDUCE VOMITING. Give nothing by mouth. Get medical attention! If vomiting occurs, keep head
lower than hips to prevent aspiration.
Inhalation: If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
breathing is difficult give oxygen. Get medical attention.
Skin Contact: Wash with soap and water for 15 minutes. Get medical attention if irritation persists.
5. FIRE FIGHTING MEASURES
Flammable Properties
Flash Point 癋(癈): 15 F (-26 C) (lowest Component)
Flash Point Method: TAG Closed Cup
Flammable Limits in Air - Lower (%): 1.2% (lowest Component)
Flammable Limits in Air - Upper (%): 6.7% (lowest Component)
Page 1 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens A/C Flush (Solvent Based)
MSDS NO. 6544
Revision Date: 10/29/2009
Date Printed 10/29/2009
5. FIRE FIGHTING MEASURES
Autoignition Temperature 癋(癈): Not Determined
Extinguishing Media: Carbon dioxide. Dry chemical. Foam. Use water spray to keep containers cool that are exposed to heat or
flames.
Protection Of Fire-Fighters:
Special Fire-Fighting Procedures: Wear approved positive-pressure self-contained breathing apparatus and protective clothing. Vapor may
cause flash fire. Closed containers may explode if exposed to extreme heat. Water fog or spray may be
used to cool exposed equpment and containers. Do not spray water directly on fire - product will float and
could be reignited on surface of water.
Hazardous Combustion Products: Oxides of Carbon. Mixed hydrocarbons. Fumes and Smoke.
Aerosol Comments: Not Applicable
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions: Wear appropriate protective clothing and equipment to prevent skin and eye contact.
Spill Procedures: Wear protective equipment specified. Avoid all sources of ignition; heat, sparks and open flames.
Action to be taken if material is released orPersons not trained should evacuate area. Remove sources of ignition. Increase area ventilation. Wipe,
spilled: scrape, or soak up in an inert material and put in a container intended for flammable materials for disposal.
Environmental Precautions: Do not allow to enter sanitary drains, sewer or surface and subsurface waters.
7. HANDLING AND STORAGE
Handling and Storage: Warning: Flammable. Use only in a well ventilated area. Avoid breathing vapors, if exposed to high vapor
concentration, leave area at once. Keep container closed when not in use. Keep away from food and
smoking materials. Wash hands before eating and smoking. Keep away from heat and open flame. Good
hygienic practices should be observed. Work clothes should be washed separately at the end of each work
day. Contaminated disposable clothing should be discarded in accordance with local, state and federal
rules. Bond and ground during transfer.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls: Exhaust ventilation. Showers. Eyewash stations.
Eyes: Chemical goggles; also wear a face shield if splashing hazard exists. Do NOT wear contact lenses.
Skin Protection: Avoid skin contact. Wear protective clothing and gloves. Use gloves resistant to the material being used
(Viton, Nitrile). Launder contaminated clothing before reuse.
Respiratory Protection: Use local exhaust to capture vapor, mists or fumes, if necessary. Provide ventilation sufficient to prevent
exceeding recommended exposure limit or buildup explosive concentrations of vapor in air. No smoking, or
use of flame or other ignition sources. Use approved NIOSH respiratory protection if TLV exceeded..... Or
over exposure is likely.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Colorless to light yellow liquid
Odor: Solvent/Lemon
pH Value: Not Determined
Vapor Pressure: Not Determined
Vapor Density (Air=1): Not Determined
Boiling Point (癋): 180 F (82 C) (lowest Component)
Melting/Freezing Point: Not determined.
Solubility in Water: approx. 25%
Bulk Density at 20癈: 6.00 lb/gal
Molecular Weight: Mixture
Specific Gravity (H20=1): .92 @ 60 F
Viscosity: .83 cSt @ 100 F
Evaporation Rate: Not Determined
VOC Content(%): Not Determined.
Decomposition Temperature: Not Known
10. STABILITY AND REACTIVITY
Chemical Stability: STABLE.
Page 2 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens A/C Flush (Solvent Based)
MSDS NO. 6544
Revision Date: 10/29/2009
Date Printed 10/29/2009
10. STABILITY AND REACTIVITY
Conditions to Avoid: Avoid any source of ignition. High temperatures. Avoid contact with strong oxidants such as liquid chlorine
and concentrated oxygen.
Materials to Avoid: Aluminum metals, NITROFORM. Strong oxidizing agents. Sulfuric Acid. Concentrated oxygen.
Hazardous Decomposition Products: Oxides of carbon. Mixed Hydrocarbons. Smoke and Fumes.
Hazardous Polymerization: WILL NOT OCCUR
11. TOXICOLOGICAL INFORMATION
Toxicological Data:
Component
Route Species Dose
LC50 103 gm/m3/4H
Inhalation Rats
Heptane
142-82-5
Inhalation Rats LC50 16,000 ppm
Isopropyl Alcohol
67-63-0
Carcinogenicity:
Component
IARC NTP OSHA
Not Listed Not Listed Not Listed
Heptane
142-82-5
Not Listed Not Listed Not Listed
Isopropyl Alcohol
67-63-0
12. ECOLOGICAL INFORMATION
Remarks: Ecological testing has not been conducted on this product.
13. DISPOSAL CONSIDERATION
Waste Classification: Not determined.
Waste Management: Not determined.
Disposal Method: Disposal should be made in accordance with federal, state and local regulations.
14. TRANSPORTATION INFORMATION
U.S. DOT:
Proper Shipping Name: Flammable Liquid, n.o.s. (Heptane, Isopropyl Alcohol)
Hazard Class: 3
UN/NA Number: UN 1993
DOT Packing Group: PG II
IMDG:
Proper Shipping Name: Flammable Liquid, n.o.s., (Heptane, Isopropyl Alcohol)
Hazard Class: 3
Hazard Subclass: Not determined.
UN No.: UN 1993
Packing Group: PG II
Marine Pollutant: No
15. REGULATORY INFORMATION
US Federal Regulations:
Page 3 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens A/C Flush (Solvent Based)
MSDS NO. 6544
Revision Date: 10/29/2009
Date Printed 10/29/2009
SARA 313 SARA 302 TPQ RQ
Component
Not Listed Not Listed Not Listed Not Listed
Heptane
142-82-5
Listed. Not Listed Not Listed Not Listed
Isopropyl Alcohol
67-63-0
SARA 311/312 Hazard Catagories: Not Determined.
State Regulations:
California Prop. 65 California - Prop 65 California Prop. 65 California Prop. 65
Component
Cancer list Developmental Toxicity Reproductive Female Reproductive Male
Not Listed Not Listed Not Listed Not Listed
Heptane
142-82-5
Not Listed Not Listed Not Listed Not Listed
Isopropyl Alcohol
67-63-0
New Jersey Right-to-Know List:
Component
Substance no. 2422
Heptane
Substance no. 2423
142-82-5
Substance no. 2425
Substance no. 2426
Substance no. 2427
Substance no. 2428
Substance no. 2429
Substance no. 2430
Substance no. 1339
Substance no. 1076
Isopropyl Alcohol
Substance no. 2079
67-63-0
Substance no. 2422
Substance no. 2423
Substance no. 2425
Substance no. 2426
Substance no. 2427
Substance no. 2428
Substance no. 2429
Substance no. 2430
Substance no. 2381
U.S. TSCA: The components of this product are listed on the TSCA Inventory.
Canadian Inventory: The components of this product are listed on the Canadian DSL or NDSL Inventory.
Consumer Product Safety Improvement Act of 2008 General Conformity Certification
The Supplier identified in Section 1 of this MSDS has evaluated this product and certifies it to be labeled and packaged in
compliance with the applicable provisions of the Federal Hazardous Substance Act as stated in 16 CFR 1500 and enforced
by the Consumer Product Safety Commission, and where applicable the products that require Child Resistant Closures are
packaged in accordance with the Poison Prevention Packaging Act as stated in 16 CFR 1700 and enforced by the
Consumer Product Safety Commission. All closures have been tested in accordance with the latest protocols. No other
testing is required to certify compliance with the above. The date of manufacture is stamped on the product container.
16. OTHER INFORMATION
General Notes: Do not allow undiluted material or large quantities to reach groundwater, bodies of water or sewer system.
Page 4 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens A/C Flush (Solvent Based)
MSDS NO. 6544
Revision Date: 10/29/2009
Date Printed 10/29/2009
16. OTHER INFORMATION
Disclaimer: The information and recommendations contained herein are based upon tests believed to be reliable.
However, the manufacturer/distributor of this product does not guarantee their accuracy or completeness
NOR SHALL ANY OF THIS INFORMATION CONSTITUTE A WARRANTY, WHETHER EXPRESSED OR
IMPLIED, AS TO THE SAFETY OF THE GOODS, THE MERCHANTABILITY OF THE GOODS, OR THE
FITNESS OF THE GOODS FOR A PARTICULAR PURPOSE. Adjustment to conform to actual conditions of
usage may be required. The manufacturer/distributor assumes no responsibility for results obtained or for
incidental or consequential damages, including lost profits, arising from the use of these data. No warranty
against infringement of any patent, copyright or trademark is made or implied.
Page 5 of 5
|