MSDS: CHAIN LUBRICANT SPRAY
MATERIAL SAFETY DATA SHEET
瓹hampion Bow Tie logo is a trademark of Federal-Mogul Corporation, used under license.
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
CHAIN LUBRICANT SPRAY
Synonyms:
CHAMPION?CHAIN LUBE MULTI-PURPOSE SPRAY GREASE
Company Identification
Champion Brands, L.L.C., 1001 Golden Drive, Clinton, MO 64735
PHONE: 800-821-5693 WEBSITE: www.championbrands.com
CAS Registry Number Not Applicable
Synonyms None
Generic/Chemical Name Mixture
Product Type Petroleum Based Lubrication Spray
Preparation Date April 10, 2008
Transportation Emergency Response
CHEMTREC: (800) 424-9300
Product Information
Product Information and MSDS Requests: (800) 821-5693 and www.championbrands.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient CAS EU WHMIS Reg? %wt
Heptane 142-82-5 Unk nown Unknown 40 - 70
Distillates (petroleum), hydrotreated heavy 64741-84-0 Not controlled under DSD (Europe) No 0 - 40
Mineral Oil 8012-95-1 Not controlled under DSD (Europe) No 0 - 40
Propane 74-98-6 Unknown Unknown < 25
Butane 106-97-8 Unknown Unknown 0 - 25
3. HAZARD IDENTIFICATION
IMMEDIATE HEALTH EFFECTS
Emergency Overview: Warning: Extremely Flammable. Content under pressure. This material is an eye and skin
irritant. Keep away from heat, sparks and flame. Causes respiratory irritation. Possible redness and defatting may
result from prolonged skin exposure to this material. Excessive inhalation causes headache, dizziness and nausea.
Ingestion of this product may cause gastrointestinal distress with symptoms of nausea, vomiting, diarrhea and
abdominal pain.
4. FIRST AID MEASURES
Eye: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the
upper and lower lids. Seek medical attention if irritation persists.
Skin: Wash with soap and water for 15 minutes. If irritation persists or signs of toxicity occur, seek medical attention.
Remove contaminated clothing and shoes, and launder before reuse.
Ingestion: If swallowed, induce vomiting immediately by giving two glasses of water and sticking fingers down throat;
never give anything to an unconscious person. Get medical attention.
Inhalation: If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
breathing is difficult, give oxygen. Get medical attention.
5. FIRE FIGHTING MEASURES
FIRE CLASSIFICATION:
OSHA Classification (29 CFR 1910.1200): Classified by OSHA as flammable.
NFPA RATINGS: Health: 2 Flammability: 4 Reactivity: 0
REV DATE: 4/10/2008 PAGE 1 OF 4
MSDS: CHAIN LUBRICANT SPRAY
FLAMMABLE PROPERTIES:
Flashpoint: 25F TAG Closed Cup
Autoignition: 433F
Flammability (Explosive) Limits (% by volume in air): Lower: 1 Upper: 7
EXTINGUISHING MEDIA: Alcohol foam.
PROTECTION OF FIRE FIGHTERS:
Fire Fighting Instructions: Wear approved positive -pressure self-contained breathing apparatus and protective
clothing.
Combustion Products: Not determined.
Aerosol Comments: NFPA Level 3 Aerosol
6. ACCIDENTAL RELEASE INFORMATION
Protective Measures: Wear appropriate protective clothing and equipment to prevent skin and eye contact.
Spill Management: Stop the source of the release if you can do it without risk. Contain release to prevent further
contamination of soil, surface water or groundwater. Clean up spill as soon as possible, observing precautions in
Exposure Controls/Personal Protection. Use appropriate techniques such as applying non-combustible absorbent
materials or pumping. Where feasible and appropriate, remove contaminated soil. Place contaminated materials in
disposable containers and dispose of in a manner consistent with applicable regulations.
Reporting: Report spills to local authorities and/or the U.S. Coast Guard's National Response Center at (800) 424-
8802 as appropriate or required.
7. HANDLING AND STORAGE
Precautionary Measures: Caution: Contents under pressure. Keep away from heat and open flame. Use only in a
well ventilated area. Avoid breathing vapors, if exposed to high vapor concentration, leave area at once. Use only in
well ventilated areas. Keep container closed. Keep out of the reach of children. Use ground strap.
General Handling Information: Avoid contact with skin and eyes. Avoid contaminating soil or releasing this material
into sewage and drainage systems and bodies of water.
Container Warnings: Do not puncture, incinerate or store above 120 F. Exposure to high temperatures may cause
bursting. DO NOT store in the passenger compartment of an automobile.
8. EXPOSURE CONTROL/PERSONAL PROTECTIVE EQUIPMENT
ENGINEERING CONTROLS:
Use in a well ventilated area. Local exhaust ventilation as necessary to maintain exposures to within applicable limits.
PERSONAL PROTECTIVE EQUIPMENT
Eye/Face Protection: Wear safety glasses or goggles to protect against exposure.
Skin Protection: Avoid skin contact. Wear protective clothing and gloves.
Respiratory Protection: Do not breath mist or vapor. Use in a well ventilated area. Appropriate respiratory protection
should be worn when applied engineering controls are not adequate to protect against inhalation exposure.
Occupational Exposure Limits:
OSHA PEL OSHA PEL ACGIH TLV ACGIH TLW
Component Wt % TWA CEILING LIMITS TWA STEL
Heptane CAS 142-82-5 0 - 10% 500 ppm Not Known 400 ppm 500 ppm
Propane CAS 74-98-6 < 25% 1000 ppm Not Known 2500 ppm Not Known
Butane CAS 106-97-8 < 25 % None Established None Established None Established None Established
D istillates (petroleum),
hydrotreated heavy < 50% 5 mg/m3 None Established 5 mg/m3 -
CAS# 64741-84-0
9. PHYSICAL AND CHEMICAL PROPERTIES
Attention: the data below are typical values and do not constitute a specification.
Appearance and Odor: MILD SOLVENT Solubility: Soluble in hydrocarbons; insoluble in water
pH: NA Freezing Point: NA
Vapor Pressure: 46 psig @ 70癋 Melting Point: NA
Vapor Density (Air = 1): NA VOC Content(%): 72
Boiling Point: 209F
REV DATE: 4/10/2008 PAGE 2 OF 4
MSDS: CHAIN LUBRICANT SPRAY
10. STABILITY AND REACTIVITY
Chemical Stability: This material is considered stable under normal ambient and anticipated storage and handling
conditions of temperature and pressure.
Conditions to Avoid: Keep away from heat, sparks and flame. Avoid any source of ignition.
Incompatibility With Other Materials: May react with strong oxidizing agents, such as chlorates, nitrates, peroxides.
Hazardous Decomposition Products: Carbon monoxide.
Hazardous Polymerization: Hazardous polymerization will not occur.
11. TOXILOGICAL INFORMATION
Toxicological Data
Component Route Species Dose
Heptane CAS 142-82-5 Inhalation Rats LC50 103 gm/m3/4H
Butane 106-97-8 Inhalation Rats LC50 57 pph/15M
Carcinogenicity: No data available.
IMMEDIATE HEALTH EFFECTS
Eye Irritation: The eye irritation hazard is based on evaluation of data for similar materials or product components.
Skin Irritation: The skin irritation hazard is based on evaluation of data for similar materials or product components.
Skin Sensitization: No product toxicology data available.
Acute Dermal Toxicity: The acute dermal toxicity hazard is based on evaluation of data for similar materials or
product components.
Acute Oral Toxicity: The acute oral toxicity hazard is based on evaluation of data for similar materials or product
components.
Acute Inhalation Toxicity: The acute inhalation toxicity hazard is based on evaluation of data for similar materials or
product components.
12. ECOLOGICAL INFORMATION
ECOTOXICITY
No adverse ecological effects are expected but may cause damage to the environment. Consequently, this material
should be kept out of sewage and drainage systems and all bodies of water.
ENVIRONMENTAL FATE
This material is not expected to be readily biodegradable.
13. DISPOSAL INFORMATION
Oil collection services are available for used oil recycling or disposal. Place contaminated materials in containers and
dispose of in a manner consistent with applicable regulations. Contact your sales representative or local
environmental or health authorities for approved disposal or recycling methods. (See B.C. Reg. GY/92 Waste
Management Act; R.R.O. 1990, Reg. 347 General-Waste Management; C.C.SM.c. W40 The Waste Reduction and
Prevention Act; N.S. Reg. 51/95 and N.S. Reg. 179/96 for examples of Provincial legislation.)
14. TRANSPORTATION INFORMATION
U.S. DOT: Proper Shipping Name: Consumer Commodity, ORM -D
IMDG: Proper Shipping Name: Aerosols (Limited Quantity)
Hazard Class: 2.1
UN No.: UN1950
Packing Group: None
IATA: Proper Shipping Name: Consumer Commodity, ID 8000, Class 9 label
REV DATE: 4/10/2008 PAGE 3 OF 4
MSDS: CHAIN LUBRICANT SPRAY
15. REGULATORY INFORMATION
EU Regulations
Hazard: Irritant, Dangerous for the environment
Risk Phrases :
UNKNOWN
Safety Phrases :
UNKNOWN
Additional Warning Phrases : Not applicable.
US Federal Regulations:
SARA 313/302: Not listed hazardous per OSHA 29 CFR 1910.1200
SARA 311/312 Hazard Categories:
Accute : Health - YES, Chronic Health - NO, Fire - YES, Reactive - NO, Pressure - YES
State Regulations:
California Prop. 65: Not Listed
U.S. TSCA: The components of this product are listed on the TSCA Inventory.
Canadian Regulations
WHMIS (Classification) : UNKNOWN
16. DISCLAIMER
NFPA RATINGS: Health: 2 Flammability: 4 Reactivity: 0
HMIS RATINGS: Health: 2 Flammability: 4 Physical Hazard: 2
(0-Least, 1-Slight, 2-Moderate, 3-High, 4-Extreme, PPE:- Personal Protection Equipment Index recommendation, *-
Chronic Effect Indicator). These values are obtained using the guidelines or published evaluations prepared by the
National Fire Protection Association (NFPA) or the National Paint and Coating Association (for HMIS ratings).
REVISION STATEMENT: Revision updates many sections and the MSDS should be read in its entirety.
ABBREVIATIONS THAT MAY HAVE BEEN USED IN THIS DOCUMENT:
TLV - Threshold Limit Value TWA - Time Weighted Average
STEL - Short-term Exposure Limit PEL - Permissible Exposure Limit
CHA - Champion LLC CAS - Chemical Abstract Service Number
NDA - No Data Available NA - Not Applicable
<= - Less Than or Equal To >= - Greater Than or Equal To
Prepared according to the OSHA Hazard Communication Standard (29 CFR 1910.1200) and the ANSI MSDS
Standard (Z400.1) by Champion LLC, 1001 Golden Drive, Clinton, Missouri 64735.
The information presented herein has been compiled from sources considered to be dependable and is accurate to the best knowledge of
Champion Brands, L.L.C. Champion Brands, L.L.C., makes no warrantywhatsoever expressed or implied of merchantability or fitness for the
particular purpose, regarding the accuracy of such data or the results to be obtained from the use thereof. Champion Brands, L.L.C., assumes no
legal responsibility for use or reliance upon this data. Since this information may be applied under conditions beyond our control and with which we
may be unfamiliar and since data made available subsequent to the date hereof may suggest modifications of the information, we do not assume
any responsibility for the results of its use. This information is furnished upon condition that the person receiving it shall make his own determination
of the suitability of the material for his particular purpose.
REV DATE: 4/10/2008 PAGE 4 OF 4
|