MATERIAL SAFETY DATA SHEET
ONC N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: 12/00
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Instant Finish Emulsifier Supplier's Name: Noble Chemical Inc.
Generic Name: Instant Finish Emulsifier Supplier's Address: 2209 Old Philadelphia Pike
Lancaster, PA 17602
Chemical Family: Solvent Detergent Blend
Supplier's Phone #: 888-256-6400
Formula: Proprietary
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
2-Butoxyethanol 111-76-2 20 to 30 25 ppm 25 ppm N/A
8mg/M3
Ethanolamine 141-43-5 0 to 5 N/A N/A
Isopropyl Alcohol 67-63-0 0 to 5
Sodium Xylene Sulfonate 1300-72-7 O to 5
E.D.T.A. 64-02-8 0 to 5
Nonionic Surfactant 9016-45-9 0 to 5
Dye N/A <0.1
Perfume Oils N/A < 1.0
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 148 F. (TCC)
Specific Gravity: 1.002
Boiling Point (癋): 210 F.
Upper Explosion Limit: 12.0 Lower Explosion Limit: 2.0
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: Alcohol foam, water fog, CO2 or dry chemical.
% Volatile: 96+ pH: 12.0 ?13.0
Special Firefighting Procedures: Wear self-contained breathing apparatus
Solubility in Water: Complete Evaporation Rate (Water=1): <1
for confined areas. Keep fire exposed containers cool with water spray.
Physical Description: Thin yellow liquid with characteristic odor.
Unusual Fire and Explosion Hazards: Vapors heavier than air.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.
SECTION 6-STORAGE AND HANDLING INFORMATION
Combustible liquid- Avoid contact with heat, spark or open flame. Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away
when applying to floor. Keep container closed during storage. For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Wear protective
eyewear, gloves and footwear when handling. Avoid breathing of vapors. Use in well-ventilated area only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use NIOSH approved organic vapor respirator or self-
Skin: Severe skin irritant. May cause moderate reddening, swelling, and possible contained breathing apparatus in confined or poorly ventilated areas.
skin damage. Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section 2
Eyes: Severe eye irritant. Liquid and mists may damage eyes, causing corneal ingredients below acceptable limits.
damage. Protective Gloves: Chemical resistant rubber or neoprene.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose, Eye Protection: Chemical splash goggles or full-face shield.
throat, and lungs. Other Protective Equipment: Eye wash station nearby. Protective outerwear and
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, rubber boots should be worn when using.
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become
Eyes: Contact damage is immediate. Immediately flush with large quantities of slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
water, holding eyelids open. Seek medical attention immediately.
Waste Disposal Method: Any method in accordance with local, state and federal
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
laws. Best method is to recycle or reuse for intended purpose. Consult local
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
attention immediately.
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound Flammability 1
Yes - Immediate (acute) Health Hazard Reactivity 0
Yes - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
111-76-2 Glycol Ether 20%
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product