#1018
MATERIAL SAFETY DATA SHEET
NFPA RATING: Health = 1 Flammability = 0 Reactivity = 0
HMIS RATING: Health = 1 Flammability = 0 Reactivity = 0
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (0982A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: SPRAY CLEAN HD
Address: 302 North Fourth Street Date Prepared: March 30, 2010 (version 2)
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire,
exposure or accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
(Specific Chemical Identity: OTHER LIMITS
Common Name(s) CAS# OSHA PEL ACGIH TLV RECOMMENDED %
Ethanolamine 141-43-5 3 ppm 3 ppm N/A 0.1-1%
Dipropylene glycol methyl ether 34590-94-8 100 ppm 100 ppm N/A 1-5%
Water 7732-18-5 none none N/A ---
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
Specific Gravity (H2O = 1): 25篊 = 1.01 *Density= 3.35 lbs/gal.
Boiling Point: 208F
17.5 *Percent Volatile by Weight (%): greater than 98.75%
Vapor Pressure (mm Hg.):
0.74 Evaporation Rate (ethyl ether = 1): slower than 1
Vapor Density (AIR = 1):
complete Slightly hazy, dark purple liquid;
Solubility in Water: Appearance and Odor:
11 - 12 mountain berry odor
*pH (concentrate):
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
None (T.C.C.) Flammable Limits: LEL = N/A UEL = N/A
Flash point:
Extinguishing Media: Water, carbon dioxide, dry chemical or foam
Special Fire Fighting Procedures: Normal fire fighting procedures may be used. Cool and cautiously approach or
handle fire-exposed containers.
Unusual Fire and Explosion Hazards: N/A
SECTION V -- PHYSICAL HAZARDS
Stable N/A
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Oxidizing materials and strong acids
Hazardous Decomposition Products or Byproducts: Produces normal products of combustion when exposed to fire.
Hazardous Polymerization: Will not occur None known
Conditions to Avoid:
SECTION VI -- HEALTH HAZARD DATA
Routes of entry: Inhalation? Yes Skin? Yes Ingestion? Yes
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. When tested per the Federal Hazardous Substance Act concentrate was not considered a primary skin irritant but
prolonged contact with eyes may cause irritation. It was not acutely toxic orally at 5 g./kg. Prolonged and repeated
exposure to skin may produce irritation. DO NOT SPRAY CONCENTRATED PRODUCT. Only spray diluted product.
Inhalation of fine fog mist can cause irritation of mucous membranes. Fine fog mist application is not recommended.
Inhalation of spray mist may result in varying degrees of irritation. 2. None known to Hillyard, Inc.
Chemical listed as Carcinogen or Potential Carcinogen:
No No No
National Toxicology Program = I.A.R.C. Monographs = OSHA =
page 2 of - #1018 Quick & Clean Spray Clean HD
SECTION VI -- HEALTH HAZARD DATA continued
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
Signs and Symptoms of Exposure: Concentrated product may produce skin and eye irritation. Ingestion may produce
burns of the mouth, throat, esophagus and stomach.
Medical Conditions Generally Aggravated by Exposure: Skin problems such as industrial dermatitis.
Emergency and First Aid Procedures: Inhalation: Remove person to fresh air. If breathing difficulty persists or
occurs later, call physician. Skin and eye contact: Immediately flush with plenty of water for 15 minutes. Get prompt
medical attention. Remove and wash all contaminated clothing before reuse. Ingestion: Immediately give large amounts
of water and CALL A PHYSICIAN, hospital emergency room or poison control center.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Absorb with floor dry or similar inert material. Sweep or
scrape up and put in appropriate container. Rinse spill area thoroughly with water. Use appropriate protective equipment.
Waste Disposal Method: Disposal is regulated by the Resource Conservation and Recovery Act; concentrate is
corrosive per EPA Hazardous Waste classification. Disposal of regulated quantities should be neutralized at a permitted
facility in accordance with all federal, state and local requirements.
Precautions To Be Taken In Handling And Storing: Keep container closed when not in use. Container disposal:
Triple rinse (or equivalent) then offer clean, dry container for recycling or reconditioning. Waste from normal use may be
sewered to public-owned treatment works in compliance with applicable federal, state and local requirements.
Other Precautions: Do not use with fog mist or fine droplet sprayer without respiratory protection. This product
contains no reportable quantities of toxic chemicals subject to reporting requirements of Section 313 of SARA Title III
Emergency Planning and Community Right to Know Act of 1986 and 40 CFR Part 372.
SECTION VIII -- CONTROL MEASURES
Respiratory Protection (Specify Type): No special air handling needed with diluted material in normal use.
Ventilation:
Recommended Recommended
Local Exhaust = Mechanical (General) =
N/A N/A
Special = Other =
Other Protective Clothing or Equipment: Not usually necessary.
Work / Hygienic Practices: Wash thoroughly after handling.
SECTION IX - TRANSPORTATION INFORMATION
Applicable regulations: DOT = no; IMCO = no; IATA = no
Proper shipping name: Cleaning compound
UN No.: not applicable Limited Qty.: not applicable Hazard Class: not applicable
Labels required: not required DOT Exception: not applicable
EPA Hazardous waste/number code: not listed
Hazardous waste characteristics:
Ignitability = not applicable; Corrosivity = yes; Reactivity = not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY,
FITNESS FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE
PRODUCT(S) OR INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29
CFR 1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information
contained herein is presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF
THIS PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE
OR LOCAL REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
Version 2, * Denotes revisions since last published MSDS. Supersedes Version 1 August 23, 2001
|