Pressure-Lube, Inc. Approval Date 3/13/2007
Material Safety Data Sheet Supersedes Date 1/29/2007
Section I. Chemical Product and Company Identification
JAX GREEN-CLEAN CLEANER/DEGREASER Product JAX00122
Product Name/
ID No.
Trade Name
(BULK, TRIGGER SPRAY)
Emergency Telephone
PRESSURE-LUBE, INC.
Supplier
W134 N5373 CAMPBELL DRIVE For Chemical Emergency, Spill, Leak, Fire,
Exposure or Accident, Call CHEMTREC:
MENOMONEE FALLS, WI 53051 USA
NORTH AMERICA 800-424-9300
INTERNATIONAL +01-703-527-3887 Collect
Non-Emergency Contact
Synonym(s) None
JAX: 262-781-7660
Chemical Family Detergent/cleaner JAX/FAX: 262-781-3906
Chemical Formula Mixture
Material Uses Detergent/cleaner
Section II. Composition and Information on Ingredients
Name PEL/TLV, Source CAS # % by Weight
PROPRIETARY FORMULA.
Diphosphoric acid, tetrapotassium salt NE 7320-34-5 1-5
Sodium gluconate NE 527-07-1 <1
6 mg/m3, OSHA
Monoethanolamine 141-43-5 <1
Glycols, polyethylene, mono [(1,1,3,3-tetramethylbutyl)phenyl] ether 9036-19-5 1-5
10 mg/m3, ACGIH
n,n-Diethanolamine 111-42-2 1-5
2 mg/m3, ACGIH
Ethylene glycol monobutyl ether 111-76-2 5-10
50 ppm, OSHA
LC50, LD50 of Ingredients Not available
Section III. Hazards Identification
Emergency Overview Adverse effects on human health are not expected from this product. Chronic effects and medical conditions aggravated by
overexposure to this product have not been established. Unnecessary exposure to this product or any chemical should be
avoided.
Potential Health Effects:
Eye Contact Mild eye irritant. May cause slight irritation and redness.
Skin Contact Prolonged and repeated contact may cause irritation in sensitive individuals. Exposure to sensitive skin may cause persistant
irritation. Repeated daily application without rinsing, or continuous contact of this product on the skin may lead to temporary, but
reversible, irritation.
Ingestion Relatively non-toxic by ingestion.
Inhalation Exposures to concentrate/mist may cause mild irritation of nasal passages or throat.
Continued on Next Page
PAGE 2 OF 4
JAX GREEN-CLEAN CLEANER/DEGREASER (BULK, TRIGGER SPRAY)
Section III. Hazards Identification (cont'd)
HAZARD RATINGS
0
1 0 Physical Hazard:
HMIS Code Health: Fire: 0 Minimal Hazard 3 Serious Hazard
1 Slight Hazard 4 Severe Hazard
2 Moderate Hazard
Section IV. First Aid Measures
Immediately flush with water for a minimum of 15 minutes or until material is removed. Be sure to remove contact lenses, if
Eye Contact
present, and to lift upper and lower eyelids during rinsing. Get medical attention if irritation persists.
Skin Contact Rinse skin with water. Rinse shoes and launder clothing before reuse. Reversible reddening may occur in some dermal-sensitive
users; thoroughly rinse area and get medical attention if reaction persists.
Give several glasses of water to dilute. DO NOT induce vomiting. If stomach upset occurs, consult physician.
Ingestion
Inhalation Remove to fresh air. Get medical attention if irritation persists.
Section V. Fire and Explosion Data
Not available
Autoignition Temperature
Flash Point None
Flammable Limits (Approx.) LOWER Flammable Limit: Not applicable UPPER Flammable Limit: Not applicable
See Lower and Upper Flammable Limits
Explosion Hazards
Products of Combustion Hazardous decomposition products include oxides of phosphorus, oxides of potassium, nitrogen oxides, and ammonia.
Fire Fighting Media Not applicable -- product is water-based and nonflammable.
and Instructions
Special Remarks - None
Fire and Explosion
Hazards
Section VI. Accidental Release Measures
Release or Spill Recover material by convenient method; residual may be removed by wiping or with a wet mop. If necessary, unrecoverable
material may be washed to drain with large quantities of water.
Environmental Impact Report spills as required to the appropriate authorities. U.S Coast Guard Regulations require immediate reporting of spills that
could reach any waterway including intermittent dry creeks. Report spill to the Coast Guard toll-free number 800-424-8802.
Section VII. Handling and Storage
Do not get into eyes, on skin or clothing. Do not breathe vapor or mist. Do not store or transfer to unmarked container. Read label
Handling
before using.
Store in tightly sealed containers. Do not store in direct sunlight. Keep away from heat, sparks and open flame. Store containers
Storage
below 120癋 (49癈). Do not throw empty container into fire or trash compactor. Keep out of reach of children.
Continued on Next Page
PAGE 3 OF 4
JAX GREEN-CLEAN CLEANER/DEGREASER (BULK, TRIGGER SPRAY)
Section VIII. Exposure Controls and Personal Protection
NIOSH/MSHA-approved air-supplied respirator is advised in absence of proper environmental control.
Respiratory Protection
Local mechanical exhaust ventilation capable of maintaining emissions at the point of use below the PEL/TLV.
Ventilation
Any lined non-permeable rubber gloves.
Protective Gloves
Eye Protection Chemical splash goggles or face shield in compliance with OSHA regulations are advised when eye contact may occur.
Wash exposed areas with soap and water when finished using this product. Do not eat or drink when using this product. Do not
Personal Hygiene
swallow. Wash hands before eating or using washroom.
Implement engineering controls so that workplace exposure limit(s) of product or any component is not exceeded. Use impervious
Engineering Controls
protective clothing (gloves, boots, apron or full body suit) depending on operation to protect skin from liquid contact.
Exposure Limit See PEL/TLV of ingredients in Section II
Section IX. Physical and Chemical Properties
Appearance/Odor Transparent green-colored liquid with mild Vapor Pressure Not available
characteristic detergent odor
Vapor Density Not available
Percent Volatile Not available
Odor Threshold Not available
Evaporation Rate Not available
Specific Gravity 1.02-1.06 @ 70癋
Not available Solubility in Water 100%
Density
Coefficient of Water/Oil Not available
Not available
pH
Distribution
Boiling Point Not available
Liquid at room temperature
Physical State
Freezing/Melting Point Not available
Section X. Stability and Reactivity Data
Stable under normal temperatures and pressures.
Stability
Conditions of Reactivity Not available
Conditions and Materials Avoid strong oxidizers.
to Avoid
Hazardous Polymerization Hazardous polymerization will not occur.
Hazardous Decomposition Hazardous decomposition products include oxides of phosphorus, oxides of potassium, nitrogen oxides, and ammonia.
Products
Section XI. Toxicological Information
Dermal contact, eye contact, inhalation, ingestion.
Routes of Entry Ingestion Not available
Toxicity to Animals Not available Inhalation Not available
Effects of Acute Exposure Not available Toxically Synergistic Not available
Products
Acute Effects of Not available
Sensitization
Chronic Effects on Humans:
Carcinogenic Effects This product does not contain a carcinogen or potential carcinogen as listed by NTP, IARC, or OSHA [29 CFR 1910.1200(D)#4].
Mutagenic Effects No data available to indicate any components present at greater than 0.1% may present a mutagenic hazard.
Continued on Next Page
PAGE 4 OF 4
JAX GREEN-CLEAN CLEANER/DEGREASER (BULK, TRIGGER SPRAY)
Section XI. Toxicological Information (cont'd)
Teratogenic Effects No data available to indicate any components present at greater than 0.1% may present a teratogenic hazard.
Reproductive Effects No data available to indicate any components present at greater than 0.1% may present a reproductive hazard.
Section XII. Ecological Information
There is no data available on the adverse effects of this material on the environment.
Ecotoxicity
Section XIII. Disposal Considerations
Consult federal, state or local authorities for proper disposal and reporting procedures. All disposals must comply wtih federal,
Waste Disposal
state and local regulations.
Section XIV. Transportation Information
I.A.T.A. Air Transportation: U.S. D.O.T. Ground Transportation:
Shipping Name None Consumer Commodity ORM-D
Shipping Name
Hazard Class None
UN Number None
Packing Group None The above U.S. D.O.T. information applies to
U.S. D.O.T. Remarks
I.A.T.A. Remarks Not regulated shipping BY GROUND ONLY.
Section XV. Regulatory Information
U.S. Federal Regulations:
Release of the following chemical(s) at quantities equal to or greater than the reportable quantities (RQ), is regulated by
CERCLA
40 CFR 302.4 :
Diethanolamine, CAS #111-42-2, RQ = 100 lbs.
SARA (Section 313) This product contains the following chemical(s) listed in Section 313 at or above the de minimis concentrations:
SARA 313 Category: Glycol ethers, Amount < 10.0%
SARA 313 List: Diethanolamine, CAS #111-42-2, Amount < 3.0%
This product contains greater than 1.0% of the following chemical(s) on the SARA Extremely Hazardous Substances List:
SARA Extremely
Hazardous List
None
TSCA Inventory All components of this material are on the U.S. TSCA Inventory.
This product contains the following chemical(s) known to the State of California to cause birth defects or other reproductive
California Prop. 65
harm:
None
International Regulations:
Canada All components are in compliance with the Canadian Environmental Protection Act. This product has been classified in
accordance with the hazard criteria of the CPR and this MSDS contains all the information required by CPR.
Japan MITI Not available
Australia Not available
Switzerland Not available
Section XVI. Other Information
3/13/2007
Approval Date
1/29/2007
Supersedes Date
Technical Services 262-781-7660
Prepared by
Section II
Sections Revised
Since Last Version
The information and recommendations contained herein are, to the best of Pressure-Lube, Inc.'s knowledge and belief, accurate and reliable as of the date
issued. Pressure-Lube, Inc. makes no warranty or guarantee, expressed or implied, of their accuracy or reliability, and Pressure-Lube, Inc. shall not be liable
for any loss or damage based upon the criteria supplied by the developers of these rating systems, together with Pressure-Lube, Inc.'s interpretation of the
available data.
|