232376 E. Pacifica Place Rancho Dominguez, CA 90220 (800) 675-1118 www.alliedhightech.com
MATERIAL/CHEMICAL SAFETY DATA SHEET
SECTION 3: HAZARDS IDENTIFICATION
SECTION 1: CHEMICAL PRODUCT & COMPANY IDENTIFICATION
No immediate hazard.
Product Details
Product Name: Cutting Fluid - High Speed Fire may produce CO, CO2, NOx
Allied Item No.: 80-10150, 80-10155
Chemical Name: Chemical/Synthetic Fluid
SECTION 4: FIRST AID MEASURES
Company Identification Potential First Aid/
Health Effects Medical Info.
Allied High Tech Products, Inc.
Eye Contact:
Remove contact lenses.
2376 East Pacifica Place Transient irritation.
Immediately flush eyes
Rancho Dominguez, CA 90220
with plenty of water for at
(310) 635-2466 least 15 minutes.
Contact Point
Transportation for United States
Skin Contact:
Chemtrec (800) 424-9300 * (202) 483-7616 Possible defatting, Wash affected area
nonirritating and/or immediately with warm
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENT nonsensitizer. water and soap. Remove
contaminated clothing.
Exposure Limits in Air Carcin.
Chemical Name CAS No. ACGIH TLV or TWA OSHA PEL Y/N
Inhalation:
Triethanolamine 102-71-6 5 mg/m3 NA N Non-toxic. Remove to fresh air.
20-30%
Monoethanolamine 141-43-5 3ppm 3ppm N
1-10%
The exact chemical identities and percentages of the raw materials Ingestion:
Non-toxic. If large quantities are
used are trade secrets. This information is being withheld as
ingested seek medial
provided for in the OSHA Hazard Communication Rule (29 CFR
attention immediately.
1910.1200).
Note:
SECTION 5: FIRE FIGHTING MEASURES
Extinguishing Media: As appropriate for the surrounding fire. Alcohol
foam, carbon dioxide, dry chemical or water.
Fire Fighting Instruction: Wear full protective clothing and OSHA/
NIOSH self-contained breathing apparatus with full facepiece.
Special Hazards: None
SECTION 6: ACCIDENTAL RELEASE MEASURES
Mop up or use dry absorbent.
HMIS Ratings
Ingredients are listed on the TSCA Inventory of
1
Health:
Chemical Substances.
Flammability: 0
Those not identified are non-hazardous.
Reactivity: 0
Page 1 of 2:
2376 E. Pacifica Place ?Rancho Dominguez, CA 90220 ?(800) 675-1118 ?www.alliedhightech.com
SECTION 7: HANDLING & STORAGE SECTION 12: ECOLOGICAL INFORMATION
Handling: Avoid contact with skin and eyes. Wash hands No data available.
thoroughly after handling. Do not swallow. Observe good
housekeeping practices. This product contains amine. Do not
add nitrite or other nitrosating agents to this product due to the
potential for nitrosamine formation.
Storage: Keep in tightly closed original container in well-
ventilated areas.
SECTION 8: EXPOSURE CONTROL & PERSONAL PROTECTION SECTION 13: DISPOSAL INFORMATION
If pre-treatment is needed, chemical treatment or
Engineering Measures: General and/or local exhaust ventilation.
ultrafiltration may be used. Dispose of waste material
Respiratory Protection: None according to Federal, State and Local regulations.
Protective Gloves: None
Eye Protection: Safety glasses or chemical splash goggles.
Other: Eye wash and shower facility should be available.
SECTION 9: PHYSICAL & CHEMICAL PROPERTIES SECTION 14: TRANSPORT INFORMATION
The product is not regulated as hazardous by the
Appearance: Dark blue liquid
Department of Transportation.
Odor: Mild
Solubility: 100%
Boiling Point: 209癋 (98癈)
Melting Point: NA
Flash Point: NA
Vapor Pressure: <1
Vapor Density: NE
Evaporation Rate: <0.032
SECTION 15: REGULATORY INFORMATION
Specific Gravity: 1.103 VOC: 0.34 lbs/gal
Flammable Limits LEL: NA Superfund: Does not contain any Section 302/304 Extremely Hazardous
Substances or Section 313 Toxic Chemicals.
Flammable Limits UEL: NA PH: 9.1-10.0
Toxic Substance Control Act TSCA: All ingredients are TSCA listed.
SECTION 10: STABILITY & REACTIVITY
EPA Hazardous Waste Number: None
Stability: Stable
For details on specific requirements, you should contact the appropriate agency in
your state.
Conditions to Avoid/Incompatibilities: Strong oxidizers, acids and
alkalis.
SECTION 16: OTHER INFORMATION
Decomposition Products: May produce carbon monoxide, carbon
dioxide and NOx in a fire.
WHMIS (SIMDUT) NOT REGULATED SUBSTANCE and all
ingredients are listed on the Canadian DSL
Hazardous Polymerization: Will not occur.
Legend
SECTION 11: TOXICOLOGICAL INFORMATION NAIF: No Applicable Information Found
NA: Not Available/Applicable
Non-toxic. NE: None Established
DISCLAIMER: The above information and recommendations are
believed accurate and reliable. Because it is not possible to anticipate
all conditions of use, additional safety precautions may be required.
ALLIED HIGH TECH PRODUCTS, INC. makes no warranty, either
express or implied, as to its accuracy or completeness and none is
made as to the fitness of this material for any purpose. The
manufacturer/distributor shall not be liable for damages to person or
property resulting from its use. Nothing herein shall be construed as a
recommendation for use in violation of any patent.
Page 2 of 2: Form Prepared By: Allied High Tech Products, Inc. January 2010