Material Safety Data Sheet (MSDS)
Current Product Status: Active
MSDS Status:
Product Name: Sentinel WB Revision Date: 2006-10-19
1729 Version: 2006.2
Product Code:
SECTION I - CHEMICAL PRODUCT/COMPANY IDENTIFICATION
MIXTURE
Chemical Name:
NOT APPLICABLE
CAS No.:
Water based damproofing
Product Description:
1 0 0
Hazard Classification: HEALTH - FLAMMABILITY - REACTIVITY -
GMX, INC.
Manufacturer/Supplier:
9105 WAY AVE.
CLEVELAND, OHIO 44105
PH: (216) 641-7502 FAX: (216) 641-0633
http://www.gmxwaterproofing.com
Internet Address:
24 HR EMERGENCY ASSISTANCE: 1-800-762-8225
SECTION II - HAZARDOUS INGREDIENTS/COMPOSITION
OSHA PEL AGCIH TLV
COMPONENTS %WT CAS NUMBER (TWA) (TWA)
PETROLEUM ASPHALT 50-70 8052-42-4 * 0.5mg/m3
(asphalt fumes)
WATER 15-40 7732-18-5 NAV NAV
ELASTOMERIC LATEX 7-13 - NAV NAV
SYNTHETIC RESIN 0.5-3 8050-90-7 5ppm 10ppm
POTASSIUM HYDROXIDE 0.5-3 1310-58-3 2ppm 2ppm
2-AMINO-2-METHYL-1-PROPANOL 0.1-1 124-68-5 NAV NAV
BYCYCLIC OXAZOLIDINES 0.1-1 56709-13-8 NAV NAV
DEFOAMER 0.1-1 - NAV NAV
DISPERSANT 0.1-1 - NAV NAV
RHEOLOGICAL MODIFIERS 0.1-1 - NAV NAV
2,2,4-TRIMETHYL-1,2-PENTANEDIOL 0.1-1 25265-77-4 NAV NAV
MONO(20METHYLPROPANOATE
* OSHA HAS NOT ESTABLISHED A SPECIFIC PEL FOR ASPAHLT FUMES. THEY ARE CONSIDERED
AS PARTICULATES NOT OTHERWISE REGULATED" WITH A PEL OF 5mg/m3 FOR RESPIRABLE
DUST FRACTION AND 15mg/m3 FOR THE TOTAL DUST FRACTION.
NAV = Not Available
SECTION III - HAZARDS IDENTIFICATION
ROUTES OF ENTRY: INHALATION, DERMAL, INGESTION
CARCINOGENICITY: NOT ESTABLISHED
1729 v2006.1
HEALTH HAZARDS (Acute & Chronic):
INHALATION: Prolonged inhalation of vapor or mist of sufficient concentration
may cause interference with respiratory function.
SKIN: Minimal irritation. Repeated or prolonged contact may cause dermatitis.
EYES: Minimal irritation.
INGESTION: Product has low order of acute toxicity and may cause gastrointestional
irritation, nausea, vomiting and diarrhea.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: This product as with any chemical, may
enhance allergic conditions on certain people. Above results are based on similar
product testing. Chronic skin or respiratory disorders.
SECTION IV - FIRST AID PROCEDURES
EYE CONTACT: Flush eyes with water for at least 15 minutes, contact physician.
SKIN CONTACT: Wash with soap and water. Contact physician if redness or itching
persists.
INHALATION: Remove to fresh air and obtain medical attention if respiratory functions
are impaired.
INGESTION: Do not induce vomiting, contact physician.
SECTION V - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: Water based
AUTOIGNITION TEMP.: Not available
LEL (LOWER EXPLOSION LIMIT): Not applicable
UEL (UPPER EXPLOSION LIMIT): Not applicable
EXTINGUISHING MEDIA: NAP, but if water dries, then use FOAM, CARBON DIOXIDE, DRY
CHEMICAL, or WATER FOG.
SPECIAL FIRE FIGHTING PROCEDURES: Use light water spray to cool exposed surfaces.
Wear self contained breathing apparatus with full facepiece operating in positive
pressure mode.
UNUSUAL FIRE AND EXPLOSION HAZARD: May foam if heated to temperatures of 2120F or
higher, or if mixed with materials above 2120F. Avoid using water stream to
prevent frothing. Never use welding or cutting torch near drum (even empty)
because product (even residue) can ignite explosively. Carbon monoxide and other
organic compounds may be formed upon combustion.
A) SENSITIVITY TO IMPACT: NO
B) SENSITIVITY TO STATIC DISCHARGE: NO
SECTION VI - ACCIDENTAL RELEASE MEASURES
SMALL SPILL: Wipe up material with absorbant material. Use soap and water
immediately for easy cleanup.
LARGE SPILL: Contain spilled material with dike and pump salvageable material into
clean container for re-use. Mix remaining material with sand, aggregate or other
absorbant material and shovel into containers.
Page 2 of 4
1729 v2006.1
SECTION VII - SAFE HANDLING AND STORAGE
Keep material from freezing. Store in a cool, dry, well ventilated area. Do not take
internally.
DO NOT LET AIR INTAKES DRAW ODOR INDOORS
KEEP OUT OF REACH OF CHILDREN
SECTION VIII - EXPOSURE CONTROL/PERSONAL PROTECTION
VENTILATION: ADEQUATE LOCAL EXHAUST. NO MECHANICAL NEEDED.
GLOVES: IMPERVIOUS OR RUBBER GLOVES.
EYE PROTECTION: CHEMICAL OR SAFETY GLASSES.
INHALATION: NIOSH APPROVED CARTRIDGED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES SHOULD
BE WORN IN CONFINED AREA.
CLOTHING: NORMAL LONG-SLEEVED AND LONG-PANTS WORK CLOTHES. WEAR BOOTS, IMPERVIOUS
COATS AND FACE SHIELDS WHEREVER NECESSARY. CHANGE IMMEDIATELY IF CONTAMINATED AND
BE SURE TO WASH THOROUGHLY BEFORE REUSE.
HYGIENIC PRACTICES: DO NOT WEAR CONTACT LEASES WHEN HANDLING THIS MATERIAL. WASH
HANDS BEFORE EATING, SMOKING OR USING THE TOILET. DO NOT SMOKE IN ANY CHEMICAL
HANDLING OR STORAGE AREA. FOOD OF BEVERAGES SHOULD NOT BE CONSUMED IN THE AREAS
IMMEDIATE TO THE USE OF THIS PRODUCT. A COMPLETE SOAP/WATER SHOWER SHOULD BE
TAKEN AT THE END OF EACH WORK DAY. PROVIDE READILY AVAILABLE EYE WASH STATIONS
AND WASHING STATIONS.
OTHER PROTECTIVE EQUIPMENT: ON SPECIFIC SITUATIONS, SPECIAL RECOMMENDATIONS SHOULD
BE USED.
SECTION IX - PHYSICAL/CHEMICAL CHARACTERISTICS
EVAPORATION RATE: <1 (Butyl Acetate = 1)
SOLUBILITY IN WATER: miscible
2120F (1000C) (water)
BOILING POINT:
PHYSICAL STATE: liquid
18 mm Hg @ 200C (water)
VAPOR PRESSURE:
SPECIFIC GRAVITY: 1.0 g/cc
VAPOR DENSITY: >1 (air = 1)
VOLATILES: 60-65%
320F (00C) (water)
FREEZING POINT:
pH: 9.0 - 11.0
ODOR AND APPEARANCE: brown-black liquid with mild oil/asphalt odor
SECTION X - STABILITY AND REACTIVITY DATA
STABILITY: Stable.
MATERIALS TO AVOID: Avoid contact with water, acids, petroleum solvents and soaps.
HAZARDOUS DECOMPOSITION: Thermal decomposition may produce carbon monoxide and other
unknown organic compounds.
WILL POLYMERIZATION OCCUR: No
Page 3 of 4
1729 v2006.1
SECTION XI - TOXICOLOGICAL INFORMATION
No information available.
SECTION XII - ECOLOGICAL INFORMATION
No data available.
SECTION XIII - DISPOSAL CONSIDERATIONS
Dispose of according to applicable Federal, State, County, and Local requirements.
SECTION XIV - TRANSPORTATION INFORMATION
NON-BULK < 119 gallon container size
DOT-U.S./MOT-CANADA/INTL.(TRUCK/RAIL)
PROPER SHIPPING NAME: NONREGULATED MATERIAL
HAZARD CLASS: NOT APPLICABLE
IDENTIFICATION NO: NOT APPLICABLE
PACKAGING GROUP: NOT APPLICABLE
Reclassed under 49CFR 173.120(b)(2). Not regulated under 49CFR 173.150(f)(2).
SECTION XV - REGULATORY INFORMATION
WHMIS: This material contains the following ingredient(s) at, or above the
minimum concentration specified on the WHMIS Ingredient Disclosure List under
the Hazardous Products Act of Canada:
Potassium Hydroxide CAS No. 1310-58-3 >0.1%
SARA313: This product DOES NOT contain material(s) subject to the reporting
requirements under Section 313 of Title III of the Superfund Amendments and
Reauthorization Act of 1986 and 40 CFR 372.
CA PROP 65: This products contains a chemical known to the State of California to cause cancer.
SECTION XVI - ADDITIONAL INFORMATION
Changes: Product name change.
Disclaimer
The information contained in this Material Safety Data Sheet has been prepared in accordance with
the OSHA Hazard communication Standard CFR 1910.1200. This information relates specifically to the
product designated and may not be valid for the product when used in combination with any other
materials or products or in a particular process. The information is, to the best of our knowledge
and belief, accurate and reliable as of the date compiled. However, no representation, warranty or
guarantee is made as to its accuracy, reliability or completeness, whether originating within the
company or not. The user should review this information, satisfy itself as to its suitability and
completeness, and pass on the information to its employees or customers in accordance with
applicable federal, state or local hazard communications requirements. We do not accept
responsibility for any loss or damage which may occur from the use of this information.
John Wenneman 12/17/2003
Prepared By: Date:
Modified By:
Page 4 of 4
1729 v2006.1
|