None of the components of this product at concentrations greater than or equal to 0.1% are listed
as a carcinogen or potential carcinogen by NTP, IARC, and OSHA.
Orelube recommends an exposure limit of 5 mg/m3 based on data for oil mist in air.
4 HEALTH HAZARD DATA
EYE: Will cause acute eye irritation upon contact.
SKIN: Prolonged and/or repeated contact tends to remove skin oils, possibly leading to irritation
and dermatitis.
INGESTION: Do not induce vomiting. Small amounts aspirated into lungs during ingestion or
vomiting may cause mild to severe pulmonary injury. LD50 is not established; refer to Hazardous
Ingredients for TLV. Ingestion can cause nausea and/or irritation of gastric system.
INHALATION: Mists or vapors may cause respiratory irritation.
EFFECTS OF OVEREXPOSURE: Prolonged and/or repeated inhalation may cause irritation to
mucous membranes and respiratory passages. Prolonged and/or repeated skin contact may
cause irritation.
5 FIRST AID MEASURES
SKIN: Wash off with plenty of soap and water. If irritation occurs, get medical attention.
EYE: Flush with large amounts of water. If any irritation persists, get medical attention.
INGESTION: Remove material from mouth. Do not induce vomiting. Get medical attention.
INHALATION: Remove to fresh air.
6 EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING MEASURES: This product may be an inhalation hazard and, unless ventilation is
adequate, the use of approved respiratory protection is recommended. Avoid inhaling mists or
vapors.
VENTILATION: Mechanical (general) is satisfactory. Use local exhaust in areas where mists or
vapors are generated. If airborne concentrations pose a health hazard, become irritating, or
exceed recommended limits, use a NIOSH-approved respirator.
HYGIENE MEASURES: Avoid contact with skin and eyes. Wash thoroughly after handling.
OCCUPATIONAL EXPOSURE LIMITS: No occupational exposure limits have been established.
HANDS: Protective gloves to avoid prolonged or repeated skin contact.
EYES: Splash goggles or face shield when eye contact may occur.
7 PHYSICAL / CHEMICAL PROPERTIES
PHYSICAL STATE: Paste
COLOR: Clear amber
ODOR: Alkaline
BOILING POINT: Not determined
VAPOR PRESSURE: < 1 mm Hg @ 20 C
VAPOR DENSITY: Heavier than air
SPECIFIC GRAVITY: ~ 0.961 g/ml @ 20 C
DENSITY: ~ 8.0 lb/gal
SOLUBILITY IN WATER: Soluble
EVAPORATION RATE (Butyl acetate = 1): < 1
pH (Neat): Highly alkaline
8 STABILITY / REACTIVITY
STABILITY: Stable under normal conditions.
HAZARDOUS POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition will evolve oxides of
carbon and nitrogen.
MATERIALS TO AVOID: Oxidizing agents.
9 FIRE / EXPLOSION DATA
FLASH POINT: None
AUTOIGNITION TEMPERATURE: Not determined.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None expected.
EXTINGUISHING MEDIA: Foam, dry chemical, carbon dioxide, water spray.
SPECIAL FIRE FIGHTING PROCEDURES: Use air-supplied breathing equipment for enclosed
areas.
BOELUBE 70105 C MSDS
2
10 SPILL / LEAK PROCEDURES
Recover free product. Contain any spill to prevent entry to sewers or streams. Add sand, earth or
suitable absorbent to spill area. Transfer to closed container.
11 WASTE DISPOSAL METHODS
Separate any oily contaminants and if required, neutralize to pH 6.8-7.2, diluting with large
amounts of water for disposal in accordance with local, state, and federal laws governing disposal
of alkaline organics.
12 PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store in closed containers away from heat or open flames. Do not store with oxidizing agents. Not
for internal use. Empty containers may contain product residue. Do not cut heat or weld on or
around empty containers. Avoid freezing temperatures.
13 TOXICOLOGICAL INFORMATION
This product is a mixture not tested as a whole for toxicity. If sprayed or misted may cause
chemical pneumonitis.
14 ECOLOGICAL INFORMATION
This product is not expected to be harmful to aquatic organisms. This product is biodegradable.
15 REGULATORY INFORMATION
All components of this product are listed on the TSCA Inventory.
This product does not contain a SARA Title 3 Section 313 (40 CFR 372) reportable chemical.
This product is not considered a controlled product according to the criteria of the Canadian
Controlled Products Regulations.
CALIFORNIA PROPOSITION 65: No reportable components.
16 TRANSPORTATION INFORMATION
Not regulated by US DOT, IMO, or ICAO.
17 OTHER INFORMATION
This information is furnished without warranty, expressed or implied, except that it is accurate to
the best knowledge of The Orelube Corporation. The Orelube Corporation assumes no legal
responsibility for the use or reliance upon this data.
Please note that the chemical identity of some or all of the ingredients that may or may not be
listed herein is confidential business information and is being withheld as permitted by 29 CFR
1910.1200 and various State Right-to-Know Laws.